2004 Kenworth T2000 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2004 Kenworth T2000, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Driver assistance133.3%
- Engine133.3%
- Tires & wheels133.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
WHILE DRIVING 65-70 MPH LOST STEERING CONTROL AND VEHICLE WANDERED ACROSS THE ROAD. VEHICLE HAD BEEN TO THE DEALER ON TWO SEPARATE OCCASIONS. DEALER INFORMED CONSUMER THAT NOTHING WAS WRONG WITH THE VEHICLE.*AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
APPARENTLY, CERTAIN TURBO CHARGERS INSTALLED ON THE CAT C-15, EITHER ORIGINALLY OR AS A REPLACEMENT, HAVE A FACTORY-INSTALLED DEVICE IN THE CASING THAT SEALS A HOLE WHERE AN OPTIONAL 'EMISSIONS SENSOR' WOULD OTHERWISE BE LOCATED. ON MY TRUCK THIS PLUG DEVICE BLEW OUT, LEAVING A 1.5 INCH-DIAMETER HOLE IN THE EXHAUST SIDE OF THE TURBO. THE HOLE IN THE TURBO CASING EMITTED RAW TOXIC EXHAUST FUMES DIRECTLY INTO THE ENGINE COMPARTMENT AND CAB. THIS DISCHARGE OVERHEATED ADJACENT ELECTRICAL COMPONENTS ON BOTH SIDES OF THE FIREWALL. SURFACES ON THE PLASTIC DASH AND GLOVEBOX IN THE CAB WERE ABNORMALLY HOT TO THE TOUCH! METAL STRUCTURES INSIDE THE COMPARTMENT WERE ALSO VERY HOT. I CONTACTED CAT SEVERAL TIMES ABOUT THE DEFECT. THEY RESPONDED WITH THE FOLLOWING STATEMENT:. 'CATERPILLAR INC. WILL NOT BE PARTICIPATING IN ANY HELP ON THIS.' (MARK SANDSCHAFER, JANUARY 19, 2017)
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
2004 KENWORTH T2000 RIGHT FRONT TIRE BLEW. *TS THE VEHICLE SUSTAINED TO DAMAGE TO THE RIGHT FRONT STEER TIRE, HOOD, RIGHT FRONT RIM, RIGHT HEADLIGHT AND SIGNALS AND RIGHT REARVIEW MIRROR (OHIO TRAFFIC CRASH REPORT). *NM
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .