2016 Keystone Carbon Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2016 Keystone Carbon, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure360.0%
- Interior & seats240.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
BRACE, ARTICULATING STEPS - FRACTURE. THE ARTICULATING STEPS TO THE MAIN CABIN ARE UNSUPPORTED DUE TO A FRACTURE IN THE REARMOST WELD OF THE BRACE IN WHICH THE STEP ASSEMBLY RESTS ON IN THE FULLY ARTICULATED/OPEN STATE. ENTRY AND EGRESS BY AN OCCUPANT IS CHARACTERIZED BY A SUDDEN DROP DURING ENTRY/EXIT. LOADING THE BRACE CAUSES THE BRACE TO DISENGAGE FROM ITS MATING SURFACE DUE TO THE BROKEN WELD; THE STEP ASSEMBLY DROPS ON 1 SIDE CAUSING THE OCCUPANT TO BECOME UNSTABLE AND LOSE BALANCE. CONDITION IS WITNESSED ON A 5TH WHEEL TOY HAULER; STEPS ARE USED WHEN STATIONARY.
CARBON 387: ARTICULATING ROOF ACCESS LADDER FASTENERS (MULTIPLE) LOOSEN AND BACK OUT OF THE SIDE WALL DURING ROAD MOTION/ USE. LADDER BRACKETS BEGIN TO SEPARATE FROM SIDE WALL CREATING AN UNSAFE CLIMBING CONDITION.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Interior & seats
Reports naming seats, latches, locks, linkages and interior fittings.
From owner reports, verbatim
CARBON 387: REAR ELECTRIC BED WITH INTEGRATED COUCH WAS REPLACED DUE TO DEFECTS IN OUTER SEATING MATERIAL. SAFETY RELEASE LATCHES (1 EACH SIDE OF BACK REST) THAT WERE PRESENT IN THE ORIGINAL DESIGN TO PREVENT UNINTENDED PINCH AND/OR INJURY FROM COUCH SEAT BACK ARTICULATION ARE COMMUNICATED BY DEALER TO BE DISCONTINUED BY THE MANUFACTURER. ARTICULATING SEAT BACK MOVES FROM A HORIZONTAL TO A VERTICAL POSITION ON LINKAGE BARS THAT ACT IN A "SCISSOR-LIKE" MOTION. WITHOUT DUAL RELEASE LATCHES (AS ARE INSTALLED ON REMAINING 7 SEAT BACKS) THE RISK OF INJURY TO FINGERS, UNINTENDED PINCH, IS GREATLY INCREASED.
CARBON 387: REAR ELECTRIC BED WITH INTEGRATED COUCH HAS MANUALLY ARTICULATING AND LOCKING SUPPORT LEGS ATTACHED. SUPPORT LEG LOCKS LOOSEN AND DO NOT STAY ENGAGED AFTER USE. UNEXPECTED FAILURE TO STAY IN THE STOWED POSITION CREATES A HIGH RISK FOR INJURY DURING LOADING AND UNLOADING OF THE GARAGE AREA.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .