2022 Keystone Cougar Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2022 Keystone Cougar, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure150.0%
- Brakes150.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
There was a bulge showing near the front of the camper, dealer inspected and said there is frame flex, possibly broken welds on the frame, which is a common problem with the lippert manufactured frames. Model years directly before this year(2022) were recalled for the same problem. This seems to be a common issue for 2022 models as well but there still is no safety recall despite the inherent risk of them being on the road.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
Vehicle was taken to the RV dealer to have annual maintenance done. During inspection it was discovered that 3 of 4 brakes were covered with grease from blown bearing seals. The vehicle has less than 3,000 miles and if not addressed could have resulted in an accident due to inability to stop the trailer using the designed braking systems. The supplier of the axles and brake systems was contacted and they informed us the seals are only warranted for 1 year. Seal failures are very common on RV's and need to be addressed to provide a design which will not fail prematurely (Less than 1 trip across the country). There are no warning indicators or messages indicating brake failure.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .