2005 Keystone Montana Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2005 Keystone Montana, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Other / unspecified457.1%
- Body & structure114.3%
- Suspension114.3%
- Tires & wheels114.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
THIS REPORT WAS TAKEN OVER THE PHONE BY BOWMAN AT ODI AND RECORDED AS A VOQ. AT AN RV PARK IN AMADO, NM, THIS OWNER OF THIS MY 2005 MONTANA WAS APPROACHED BY THE OWNER OF A 2007 MY KEYSTONE MONTANA WHO HAD PREVIOUSLY EXPERIENCED THE SEPARATION (DROP TO PAVEMENT) OF THE VEHICLE STABILIZER JACK CENTER BAR WHILE THE VEHICLE HAD BEEN TRAVELING AT HIGHWAY SPEED. THIS PRIOR INCIDENT IS DESCRIBED IN VOQ 10437722. THE NEWLY-INFORMED OWNER OF THE 2005 MONTANA (REPRESENTED BY THIS VOQ) CHECKED HIS STABILIZER JACK AND DETERMINED THAT THE SCREWS INTENDED TO SECURE THE JACK CROSS MEMBER WERE NOT IN PLACE AND THE CROSS MEMBER HAD DISPLACED ITSELF LATERALLY FROM ITS INTENDED POSITION (BUT NOT TO POINT OF SEPARATION). UPDATED 03/06/12 *BF.....UPDATED 03/21/12 *BF UPDATED 03/23/12
2005 MONTANA 5TH WHEEL TRAILER WITH DOMETIC REFRIGERATOR. *NJ THE CONSUMER STATED AFTER THE RECALL WAS PERFORMED, THE REFRIGERATOR STOPPED WORKING, DUE TO A FATIGUE CRACK IN THE BOILER TUBE WHICH CAUSED AMMONIA TO LEAK. *JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2005 KEYSTONE MONTANA. THE TRAILER WAS RAISED FOUR INCHES FROM THE TRUCK BED WHEN NORMALLY IT WAS RAISED EIGHT INCHES. THE FAILURE WAS DUE TO THE FRAME WORK BEING CRACKED. THE CAMPER WAS REPAIRED. HOWEVER, IT FAILED AGAIN, AND WAS CURRENTLY BEING REPAIRED. THE CONTACT HAS PICTURES AND REPAIR INVOICES. THE FAILURE AND CURRENT MILEAGES WERE UNKNOWN.*AK THE CONSUMER WANTED TO KNOW IF HIS INFORMATION WAS RECEIVED. UPDATED 06/19/07. *JB THE CONSUMER STATED THAT THERE IS ALSO KING PIN FRAME FAILURE ON THE RV. THE CONSUMER PROVIDED VARIOUS EMAILS PERTAINING TO THE CONTACT WITH THE DEALER FOR REPAIRS AND OF VARIOUS CONSUMERS WITH THE SAME PROBLEM. THE CONSUMER WANTS TO REIMBURSED FOR REPAIRS THAT WERE NOT COVERED UNDER THE WARRANTY HOWEVER THE DEALER STATED THAT NO REFUND WILL BE ISSUED;THE WARRANTY DOES NOT COVER THE REPAIRS DUE TO THE FACT THE RV FRAME WAS ALTERED WHICH VOIDS THE WARRANTY. UPDATED 06/08/07 *TR THE CONSUMER STATED THAT A FRIEND NOTICED THAT THE PIN BOX WAS NOT LEVEL AND THAT THE LEFT SIDE WAS HIGHER THAN THE RIGHT SIDE. THE CONSUMER PROVIDED PICTURES OF THE DEFECT AND SOME OF THE COMPLAINTS FROM MONTANA OWNERS CLUB DISCUSSION FORUM. UPDATED 07/06/07 *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2005 KEYSTONE MONTANA. THE TRAILER WAS RAISED FOUR INCHES FROM THE TRUCK BED WHEN NORMALLY IT WAS RAISED EIGHT INCHES. THE FAILURE WAS DUE TO THE FRAME WORK BEING CRACKED. THE CAMPER WAS REPAIRED. HOWEVER, IT FAILED AGAIN, AND WAS CURRENTLY BEING REPAIRED. THE CONTACT HAS PICTURES AND REPAIR INVOICES. THE FAILURE AND CURRENT MILEAGES WERE UNKNOWN.*AK THE CONSUMER WANTED TO KNOW IF HIS INFORMATION WAS RECEIVED. UPDATED 06/19/07. *JB THE CONSUMER STATED THAT THERE IS ALSO KING PIN FRAME FAILURE ON THE RV. THE CONSUMER PROVIDED VARIOUS EMAILS PERTAINING TO THE CONTACT WITH THE DEALER FOR REPAIRS AND OF VARIOUS CONSUMERS WITH THE SAME PROBLEM. THE CONSUMER WANTS TO REIMBURSED FOR REPAIRS THAT WERE NOT COVERED UNDER THE WARRANTY HOWEVER THE DEALER STATED THAT NO REFUND WILL BE ISSUED;THE WARRANTY DOES NOT COVER THE REPAIRS DUE TO THE FACT THE RV FRAME WAS ALTERED WHICH VOIDS THE WARRANTY. UPDATED 06/08/07 *TR THE CONSUMER STATED THAT A FRIEND NOTICED THAT THE PIN BOX WAS NOT LEVEL AND THAT THE LEFT SIDE WAS HIGHER THAN THE RIGHT SIDE. THE CONSUMER PROVIDED PICTURES OF THE DEFECT AND SOME OF THE COMPLAINTS FROM MONTANA OWNERS CLUB DISCUSSION FORUM. UPDATED 07/06/07 *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
TIRE TREADS STARTED SEPARATING AND BUBBLED UP INSIDE OF TIRE. SAW TREAD SEPARATION BEFORE ANY ACCIDENT OCCURRED AND REPLACED DEFECTIVE TIRE. WAS TOLD THE TIRE WOULD NOT HAVE LASTED ANOTHER 200 MILES.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .