2023 Keystone Montana Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2023 Keystone Montana, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure457.1%
- Electrical228.6%
- Tires & wheels114.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
Welds all over the structure continue to break. Multiple cross member welds have failed. Multiple wall stud welds have broken Multiple floor joist welds have broken.
The frame of the trailer is failing under normal use. After owning the trailer only 3 months we found a broken cross member. It was welded and reinforced under the direction of Keystone. 15 months later we now have 2 more broken cross members as well as several broken welds at the front of the trailer. This is now the second Montana 5th wheel that we have owned with this failure in 2 years.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
It was recently discovered that a bundle of wires are routed through a steel pipe with no protection on the ends. In building construction this method of wiring would be a gross code violation and safety hazard. In a mobile application, the risk is compounded due to the movement
After only about 2000 miles of driving, it was discovered that a main cross member had broken loose from the frame rails. These cross members help maintain the structural integrity of the trailer. Had this problem gone unchecked, it could have resulted in the trailer falling apart on the road. A certified welder has reinforced the connection and pictures have been sent to the manufacturer.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
After a 170 mile trip in roughly 50F temperatures, I pulled into my destination and noticed 1 tire was rounded across the tread instead of flat. After closer inspection it is clear the tread is separating from the tire and the steel belt is visible. The tire was probably only minutes from completely blowing out. TPMS did not indicate any abnormal pressure or temperature for any tires, and the tire looked fine prior to leaving for this trip. This is the second set of Ranier tires that I have had that have blown out unexpectedly
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .