RoadVitals

2004 Keystone Outback Owner Complaints

Reports submitted to NHTSA by owners and drivers, shown in full

Data refreshed

Complaints on fileComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
3
Latest Jul 25, 2008
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
1
Filed in the last 12 monthsReports filed with NHTSA in the trailing 365 days. Recent volume reflects attention and vehicle age as much as anything else.
0
Reports on file since May 24, 2006

What this page shows

Our database holds 3 NHTSA owner-reported complaints for the 2004 Keystone Outback. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Complaints, most recent first

Showing 1–3 of 3

Suspension
Filed Jul 25, 2008
Crash reported

WE WERE PULLING OUR 29 FT. TRAVEL TRAILER NORTH ON HWY 75 NEAR JASPER, FL., WHEN SUDDENLY IT STARTED TO FISHTAIL. WE TRIED TO CONTROL THE SWAYING, BUT IT INCREASED UNTIL THE CAMPER WAS MOVING OUR CAR AND CARRIED US OFF THE ROAD. THE CAMPER COMPLETELY COLLAPSED EVEN THOUGH WE DID NOT ROLL. WE WERE TRAVELING ON A STRAIGHT ROAD AND DID NOT MAKE ANY LANE CHANGES OR SUDDEN MOVES TO START THE SWAYING. IT JUST STARTED AND INCREASED. WE BELIEVE THE AXLE BROKE OR SWAY BAR. THE DESIGN OF THIS CAMPER ADDED TO THE INCREASED SWAY AND PROBABLY LED TO THE COLLAPSING. *TR

NHTSA ID
10235798
Incident
Jul 6, 2008
Tires & wheels
Filed Sep 24, 2007

TL*THE CONTACT OWNS A 2004 KEYSTONE OUTBACK RV. THE TIRE BRAND IS DURO, HWA-FONG RUBBER INDUSTRIAL COMPANY LTD IS THE MANUFACTURER. THE TIRE SIZE WAS T115/70D15. 25RSS IS THE MODEL NUMBER. THE RV DOESN'T HAVE A MOTOR. THE CONTACT OBSERVED THAT THE TREAD IS SEPARATING ON ALL 4 OF HIS TIRES, THE FRONT PASSENGER AND DRIVER AND THE REAR DRIVER AND PASSENGER TIRES. THE ESTIMATED COST TO REPLACE THEM IS $300 PER TIRE. THESE ARE THE ORIGINAL TIRES WHEN THE RV WAS PURCHASED. THE DEALER ADVISED THE OWNER TO SPEAK WITH THE TIRE MANUFACTURER. THE MANUFACTURER ADVISED HIM TO EMAIL PHOTOS OF THE TIRES AND THEY WOULD COMPENSATE HIM FOR HALF OF THE COST. THE CONTACT WANTS THE MANUFACTURER TO REIMBURSE HIM FOR 4 NEW TIRES, INCLUDING THE SPARE. THE CURRENT APPROXIMATE TIRE MILEAGE WAS 850 AND THE FAILURE MILEAGE WAS 450. UPDATED 10.09.07. *JB

NHTSA ID
10204869
Incident
Sep 4, 2007
SuspensionTires & wheels
Filed May 24, 2006

I PURCHASED AN OUTBACK TRAILER FROM KEYSTONE RV IN 2004 AND IT CURRENTLY HAS 3000 MILES ON IT. I RECENTLY NOTICED THAT THE TIRES ON THE DRIVER SIDE HAVE STARTED TO CRACK, AND DURING THE TIRE REPLACEMENT THE MECHANIC NOTICED THAT THE HUBS ARE LOOSE ON BOTH AXLES ON THE DRIVER SIDE. I THEN TOOK THE TRAILER TO GENERAL RV IN MOUNT CLEMENS, MICHIGAN FOR REPAIR AND THEY CONFIRMED THAT THE HUBS ARE BOTH LOOSE DUE TO A LACK OF COTTER PINS THAT HOLD THE CASTLE NUT ON TO THE TRAILER ON BOTH HUBS. THE HUBS HAVE NEVER BEEN SERVICED BY REMOVAL ONLY BY ADDING GREASE THROUGH THE ZERK FITTINGS. THE DEALERS MECHANIC COULD NOT FIND ANY INDICATION OF THE COTTER PINS INSIDE THE HUBS. SO, ONE CAN ONLY ASSUME THAT THEY DID NOT EVER ADD THE COTTER PINS TO THE ASSEMBLY. THE CASTLE NUT HAD VIBRATED NEARLY OFF THE SPINDLE ON BOTH WHEELS ON THE DRIVER SIDE. THE TRAILER HAS DUAL AXLES FROM AL-KO KOBER CORPORATION. I TEND TO BELIEVE THAT THIS COULD LEAD TO SERIOUS COMPLICATIONS ON THE ROAD, AND SHOULD BE INVESTIGATED FURTHER. THANK YOU FOR YOUR TIME JEFFERY K PLAMP. *JB

NHTSA ID
10158231
Incident
May 19, 2006
Mileage
3,000 mi

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Data sources

Data on this page last refreshed .