RoadVitals

2008 Keystone Sprinter Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
4
Latest Apr 29, 2019
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
4
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2008 Keystone Sprinter, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Body & structure240.0%
  • Electrical120.0%
  • Seat belts120.0%
  • Tires & wheels120.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Body & structure

Reports naming the vehicle structure, frame, body panels, doors, hood and trim.

2
reports

From owner reports, verbatim

DRIVERS SIDE DOOR GETS STUCK IN THE "WIDE OPEN" POSITION. WILL NOT CLOSE. HAD TO DRIVE THIS VEHICLE TO A GARAGE WITH DOOR IN THIS POSITION. THE DOOR HINGE/BRACKET HAD TO BE CUT INTO. THIS IS THE SECOND SPRINTER TO DO THIS. THE FIRST WAS A 2007.

NHTSA ID 10404769 · filed May 26, 2011

SEAT BELT LATCH CABLES ARE BROKEN. THE DRIVER'S SIDE SEAT BELT LATCH IS ATTACHED TO THE FLOOR WITH THREE CABLES. TWO ARE SNAPPED INTO LEAVING ONLY ONE TO CONSTRAIN DRIVER. IF THE DRIVER WRECKS THE ONE CABLE WON'T BE ENOUGH TO KEEP SOMEONE FROM BEING INJURED AS I'M SURE THE OTHER CABLE WILL SNAP UPON A HEAVY COLLISION. THIS VAN ISN'T EVEN TWO YEARS OLD.

NHTSA ID 10404768 · filed May 26, 2011

Too few reports in this category for a page of its own — they appear in the full complaint list.

Electrical

Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.

1
report

From owner reports, verbatim

THE BREAK-AWAY SWITCH ON OUR CAMPER HAD BEEN DISCONNECTED WHILE IN A CAMPGROUND FOR A COUPLE OF HOURS & CAUSED THE SWITCH TO MELT & THE INSULATION TO BURN OFF OF THE WIRES, ALONG WITH OTHER WIRES GOING INTO THE JUNTION BOX. THERE WAS GREAT POTENTIAL FOR A FIRE. THE SWITCH & WIRING IS UNDER-SIZED FOR THE APPLICATION & WILL NOT CARRY THE AMPERAGE THAT THE BRAKES DRAW. IT APPEARS THAT THE WIRES TO THE SWITCH WHICH ARE ABOUT 16 GAUGE ARE FED BY ABOUT A 10 GAUGE WIRE POWER SOURCE. LOGIC WOULD INDICATE THAT THESE WIRES SHOULD BE OF EQUAL SIZE AS THE FEED WIRE TO THE BRAKE SYSTEM. THIS IS NOT A FAIL-SAFE DESIGN & SHOULD NOT OVERHEAT TO THE POINT OF CAUSING A FIRE. I HAVE CONTACTED KEYSTONE & TRAILER LIFE MAGAZINE WHO DO NOT ACKNOWLEDGE THE POTENTIAL PROBLEM. I SUSPECT THAT THE DESIGN HAS NOT CHANGED FROM SINGLE AXLE TRAILERS TO DOUBLE/TRIPLE AXLES. SEVERAL OTHER CAMPERS HAVE COMPLAINED TO TRAILER LIFE ABOUT BREAK-AWAY SWITCH PROBLEMS TO NO AVAIL. MY (RETIRED ENGINEER) RECOMMENDATION IS TO RE-DESIGN THE SWITCH & WIRING WITH WIRING EQUAL IN SIZE TO THE BRAKE SYSTEM WIRING & INSTALL AN ALARM & TIMER WHEN THE BREAK-AWAY SWITCH IS PULLED.

NHTSA ID 11204510 · filed Apr 29, 2019

Too few reports in this category for a page of its own — they appear in the full complaint list.

Seat belts

Reports naming seat belts, buckles, retractors and pretensioners.

1
report

From owner reports, verbatim

SEAT BELT LATCH CABLES ARE BROKEN. THE DRIVER'S SIDE SEAT BELT LATCH IS ATTACHED TO THE FLOOR WITH THREE CABLES. TWO ARE SNAPPED INTO LEAVING ONLY ONE TO CONSTRAIN DRIVER. IF THE DRIVER WRECKS THE ONE CABLE WON'T BE ENOUGH TO KEEP SOMEONE FROM BEING INJURED AS I'M SURE THE OTHER CABLE WILL SNAP UPON A HEAVY COLLISION. THIS VAN ISN'T EVEN TWO YEARS OLD.

NHTSA ID 10404768 · filed May 26, 2011

Too few reports in this category for a page of its own — they appear in the full complaint list.

Tires & wheels

Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.

1
report

From owner reports, verbatim

CONSUMER HAS A 2008 KEYSTONE SPRINTER COPPER CANYON FIFTH WHEEL CAMPER WITH DURO TIRES THAT WERE SPLITTING. *NJ THE CONSUMER STATED 2 MORE TIRES WERE FOUND CRACKED AND SPLIT IN MULTIPLE PLACES. *JB

NHTSA ID 10277728 · filed Jul 17, 2009

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .