2024 Kia EV6 Problems

Car was totally dead even with a 68% charge. AAA came out to jump start. The next day while driving on the highway the car started to lose power. A red warning to check the electrical system came on along with "turtle mode". I was able to pull over off the highway, grateful the two small children were not with me. Car was towed to dealer who kept it for the three days. Only after repeated calling could I reach someone who said they couldn't reproduce the problem. I'm afraid to drive the car at this point as I feel it's just unsafe to do so. This seems to be an ongoing issue that Kia can't seem to fix.

We purchased a certified pre-owned 2024 Kia EV6 GT on 6/5/2026. On 6/6/2026 while driving on city streets, the display screen suddenly displayed a large and flashing red warning message "Stop vehicle and check power supply" in addition to the battery symbol. We took the vehicle to the dealership and they diagnosed that the ICCU had failed and needed to be replaced.

2024 Kia EV6 leased January 2025. Vehicle is subject to NHTSA Recall 24V-867 / Kia campaign SC327 for the Integrated Charging Control Unit (ICCU). The recall remedy was performed at an authorized Kia dealer in July 2025 (software / operational logic update). The defect was not cured. Three months after the recall remedy was performed, the vehicle suffered complete loss of electrical power and would not move. It was towed to the Kia dealer. The dealer's own diagnostic recorded code P1A9096 — the exact diagnostic code Kia's recall instructs technicians to check for — and replaced the ICCU and high-voltage fuse. This is the recall-defined failure occurring AFTER the recall remedy was applied. Approximately three months later, the vehicle again suffered total loss of power and would not start in cold weather. It was towed in. The dealer replaced only the 12-volt battery and did not address the ICCU, despite the documented prior ICCU failure on this VIN. The 12V battery failure is a known downstream symptom of ICCU failure on this platform. Approximately one month after that, the vehicle returned for charging system failure ("vehicle charges briefly then stops") and a "check electrical/hybrid system" warning that appeared while driving. Diagnosed as charging port failure. Vehicle was out of service approximately 27 consecutive days. Total cumulative days out of service across four visits: approximately 35-40. Two safety-related stranding incidents resulted from these failures. Both occurred in winter conditions in Pennsylvania. In the first, the driver was stranded in a parking lot at night during a snowstorm in sub-zero conditions; three tow trucks were dispatched before a flatbed could recover the vehicle because the EV could not be towed conventionally with no power. In the second, the vehicle died in a school parking lot during a snowstorm; the first dispatched tow truck could not recover an EV with no power, and the driver had to walk multiple miles home in freezing

Vehicle display showed a message stating 12 volt battery was low and to pull over immediately, the car the died in a parking lot. I called KIA roadside service and they connected a battery pack to the 12 volt battery and got the car started. This could have been a serious problem if I was on travelling on a public street or highway and suddenly lost power.

2024 Kia EV6 leased January 2025. Vehicle is subject to NHTSA Recall 24V-867 / Kia campaign SC327 for the Integrated Charging Control Unit (ICCU). The recall remedy was performed at an authorized Kia dealer in July 2025 (software / operational logic update). The defect was not cured. Three months after the recall remedy was performed, the vehicle suffered complete loss of electrical power and would not move. It was towed to the Kia dealer. The dealer's own diagnostic recorded code P1A9096 — the exact diagnostic code Kia's recall instructs technicians to check for — and replaced the ICCU and high-voltage fuse. This is the recall-defined failure occurring AFTER the recall remedy was applied. Approximately three months later, the vehicle again suffered total loss of power and would not start in cold weather. It was towed in. The dealer replaced only the 12-volt battery and did not address the ICCU, despite the documented prior ICCU failure on this VIN. The 12V battery failure is a known downstream symptom of ICCU failure on this platform. Approximately one month after that, the vehicle returned for charging system failure ("vehicle charges briefly then stops") and a "check electrical/hybrid system" warning that appeared while driving. Diagnosed as charging port failure. Vehicle was out of service approximately 27 consecutive days. Total cumulative days out of service across four visits: approximately 35-40. Two safety-related stranding incidents resulted from these failures. Both occurred in winter conditions in Pennsylvania. In the first, the driver was stranded in a parking lot at night during a snowstorm in sub-zero conditions; three tow trucks were dispatched before a flatbed could recover the vehicle because the EV could not be towed conventionally with no power. In the second, the vehicle died in a school parking lot during a snowstorm; the first dispatched tow truck could not recover an EV with no power, and the driver had to walk multiple miles home in freezing

Listing as all 3. ICCU/fuse went out, car decelerated to 45 MPH max and flashed a warning to pull over. The bottom left battery indicator for the 12v battery also changed to red, indicating it was not regaining power from the main EV battery. Currently in shop hoping to get part in soon

The contact owned a 2024 Kia EV6 and stated that while driving at 40 MPH, an elk suddenly appeared in front of the vehicle, resulting in a head-on collision that completely crushed the front end of the vehicle with no air bags deployed. The front end of the vehicle was crushed including the windshield. The vehicle continued with the elk after collision dragging it a couple yards ahead. The air bags did not apply. No waring lights were illuminated. No police report was filed. The contact was the only passenger during the collision. The contact suffered a sever neck issue and is not able to move his neck to the right, has chest pain and shoulder pain on both sides, and a head injury. Medical treatment is need but has not gotten any due to insurance issues. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 20,000.

I was backing out of my driveway and backed into a vehicle parked directly behind me. The collision avoidance and emergency braking system should have stopped my car before impact but it did not. No sounds other than the normal backing up beeping. Proximity alert did not ping. The vehicle is available for inspection upon request. The safety feature of collision avoidance and emergency breaking did not work. No, the problem has not been reproduced or confirmed by a dealer or independent service center. No, the vehicle component has not been inspected by the manufacturer, police, insurance representative or other. The police were called to the scene, they just looked at the damage on both vehicles. No warning lamps, messages or other symptoms of the problem prior to the failure. They only appeared once on the day of the accident. I can confirm the backup collision avoidance worked after the incident since the emergency breaking stopped my car in a parking lot after the incident of the failure.

Listing as all 3. ICCU/fuse went out, car decelerated to 45 MPH max and flashed a warning to pull over. The bottom left battery indicator for the 12v battery also changed to red, indicating it was not regaining power from the main EV battery. Currently in shop hoping to get part in soon

The vehicle’s ICCU unit stopped working out of the blue. This happened on a busy intersection and the car came to a sudden and violent halt. Luckily we were not involved in an accident. It’s a very well known issue with these vehicles and it’s really criminal that Kia has done nothing to fix it. They just change the ICCU unit and then it happens again.

Incident took place 1/31/26. I was pulling into my driveway at approximately 5 mph. Normally, as I approach the wooden driveway gate, sensors would begin to beep and I would be prompted to stop.The car normally would stop itself if a collision was imminent. This did not take place. Instead, the car picked up speed, smashed through the gate proceeded up the driveway, smashed through the garage door and the rear wall of the garage. I was alone and uninjured, but the structure was yellow tagged and there was severe damage to the contents. Airbags were not deployed. The car was towed to Caliber body shop in Santa Monica for repairs to the body. When this has been completed it will be taken to Kia of Santa Monica for analysis of the black box and braking system.

Brakes failed with unintened acceleration. We were stopped behind a truck at a stoplight when the the vehicle accelerated with a foot on the brake. We had it towed from the scene of the accident to our local dealership for testing. They had the vehicle for 4 weeks. Kia customer care was not responsive to our calls and emails or the dealerships. The dealership could not confirm the cause without their cooperation. The police were called to the scene of the accident and there is a report. The vehicle has been looked over by the service department at our local Kia lot. It was appraised for cost of damages by the collision center.

The contact owned a 2024 Kia EV6 and stated that while driving at 40 MPH, an elk suddenly appeared in front of the vehicle, resulting in a head-on collision that completely crushed the front end of the vehicle with no air bags deployed. The front end of the vehicle was crushed including the windshield. The vehicle continued with the elk after collision dragging it a couple yards ahead. The air bags did not apply. No waring lights were illuminated. No police report was filed. The contact was the only passenger during the collision. The contact suffered a sever neck issue and is not able to move his neck to the right, has chest pain and shoulder pain on both sides, and a head injury. Medical treatment is need but has not gotten any due to insurance issues. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 20,000.

I have a 2024 Kia EV6 I took my car in for an unrelated repair. Tech found an airbag code that I asked to be investigated. The airbag wiring harness was damaged and needed replacement. The repair was quoted as $6600. The dealer claimed that this was from rodent damage but the photo evidence does not look like rodent damage. It looks like the wire was pulled out of the harness. Of note, the 2024 Kia Niro and 2024 Kia Telluride have similar active recalls. Please see NHTSA Recalls 25V-024 and 23V-035.

When washing my car at an automated car wash my brakes failed when exiting the facility. When the wash was completed it gave me the approval to leave. I tapped on the gas pedal to get the car moving slowly. The car started to move down the ramp and when I applied the brakes there was no response. I pumped the brakes several times but they did not engage. I tried to hit the parking brake and shift into reverse and nothing happened. I finally had no choice but to hit a wall to keep from hitting a vehicle. I did contact the dealership and they were non responsive. They indicated they had never heard of a wet brake issue on this vehicle. I provided them with several statements from the EV6 Forum. My vehicle had less than 600 miles on the odometer.

There are alot of electrical malfunctions including unnecessary and without warning emergency breaking that has injured me ( I temporarily have a rental car to recover from a right thoracic sprain, left hip contusion, and a right anterior chest contusion- I have medical documentation), the steering wheel jerking when no correction needed, the vehicle locking up on the tow truck driver, and a lot of different electrical malfunctions that seem to indicate a bigger problem. I have more evidence, but it would not let me submit more pictures.

Listing as all 3. ICCU/fuse went out, car decelerated to 45 MPH max and flashed a warning to pull over. The bottom left battery indicator for the 12v battery also changed to red, indicating it was not regaining power from the main EV battery. Currently in shop hoping to get part in soon

The car his a module called the iccu that regulates the high voltage battery, battery range goes down, the iccu has been replaced with the vehicle only having 8k miles on the odometer

Kia has a known ICCU issue with several of their electric vehicles. Mine went out yesterday creating an extremely dangerous situation on the road. After it blew, I lost the ability to accelerate or steer. This was obviously very scary for me and the drivers around me. I feel very lucky to have not been hit by another car. Although Kia is replacing these, this does not guarantee a fix. That is to say, the ICCU has the potential to blow again after replaced because the core issue is not something that Kia group has reengineered. I should not have to fear getting into my vehicle and wonder if it will blow again. I hope the government steps in and conducts an investigation into this. It’s only a matter of time before someone, unfortunately, will lose a life over this.

[XXX] about [XXX] our 2024 Kia EV6 WIND RWD AUTO VIN: [XXX] already serviced in both NHTSA Campaign #: 24V867000 and Campaign #: 24V200000 had a sudden loss of drive power and nearly all control while driving in rush hour traffic at 65MPH on [XXX] between Atwater and Livingston. The confirmed failed ICCU component can be inspected at Modesto Ca Kia. The sudden loss of drive power and control in rush hour highway traffic put me and numerus other rush hour highway drivers at catastrophic risk of multiple crashes, this could happen to anyone with the same car and especially concerning because our car had ALREADY been serviced in the 2 previous NHTSA recalls (see above) for the very issue (ICCU) that impacted our car nearly resulting in a catastrophic outcome. The confirmed failed ICCU component has only been inspected, and confirmed failed by the KIA EV certified technician at the Modesto Ca Kia dealership. Since owning the car [XXX] a yellow 12 volt battery lamp indicator, not a warning light, on the front dash would occasionally be lit randomly while driving or parked. Just moments before the sudden loss of power and control numerus warning lights and messages were appearing and the displays were flashing on and off. We had absolutely no: warning lamps, messages, symptoms, nor any other issue whatsoever with our car prior to this sudden failure while driving on the highway. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Right front tire failed while driving on interstate highway. Sidewall blowout. The tire is available for inspection. Stability of car compromised could have caused an accident. The problem has not been reproduced. The tire was seen by a state trooper and inspected by Les Schwab tire dealer. There were no warning signs.

Rear tires on my 2024 Kia EV6 wore down to the tire wear-bar limit (2/32" remaining tread) at approximately 19,500 miles, while the front tires on the same vehicle measured roughly double that remaining tread (4/32") at the same odometer reading. The factory-installed tires are rated by the manufacturer for approximately 50,000 miles of tread life under normal use, so reaching the wear-out point on the rear tires alone at roughly 39% of that rated mileage is well outside expected wear for this vehicle at this mileage. This is not an isolated event: numerous other EV6 owners have independently reported the same front-to-rear wear disparity and premature rear tire wear online, across different driving styles and regions, which points to a vehicle characteristic (front/rear torque split, alignment or camber specification, or suspension geometry) rather than individual driver behavior. Uneven, accelerated rear tire wear reduces traction and increases stopping distance, and raises the risk of hydroplaning, tread separation, or blowout, particularly in wet weather, since the rear tires lose effective grip well before the front tires or before a typical maintenance interval would flag it. The wear was confirmed and documented, including tread-depth measurements at all four corners, by an independent third-party vehicle condition inspection performed at lease return. There were no dashboard warning lights or driver-facing alerts indicating the wear; it was only discovered through physical tread-depth measurement at that inspection. The tires inspection results are available upon request. This appears to reflect a design or specification issue affecting the vehicle's rear tires disproportionately, rather than a manufacturing defect isolated to one tire.