2017 Kia Forte Engine Problems

The vehicle exhibits a chronic, systemic electrical failure characterized by the intermittent loss of critical lighting systems, including turn signals and brake lights. This failur5e has persisted over several years and thousands of miles, independent of battery replacements or specific usage patterns. The issue has been confirmed via multiple independent service interventions. Most notably, in February 2024, a third-party professional repair - which included the replacement of the Power Distribution Unit (Central Fuse Box) was performed to address these electrical faults. Despite this professional intervention, the defect recurred in May 2026. The failure of the turn signals and brake lights while in traffic resulted in a Law Enforcement stop and the issuance of a citation. Prior to total failure, the vehicle often displays erratic engine performance, including sputtering and hesitation. These symptoms were identified early in the Vehicle's history, but inquiries regarding recall campaigns for similar Makes and Models were denied by Authorized Dealerships, who cited recall registry despite exhibiting identical Mechanical and Electrical failure modes. The failure of the brake lights and turn signals poses a severe and immediate safety risk to myself, my passengers, other motorists and those on the road...as it creates an unpredictable environment were emergency stopping and lane changes cannot be communicated to the surrounding traffic. The electrical architecture of this vehicle is fundamentally flawed, as evidenced by the recurring nature of the defect despite multiple repair attempts, including the replacement of the primary fuse distribution center. The vehicle, all service records. third-party repair receipt, and relevant law enforcement citation are available for inspection upon request to support this report. The recurring loss of safety-critical signaling systems represents a systemic design defect rather than isolated wear & tear.

NHTSA ID

11745123

Incident

May 26, 2026

The contact owns a 2017 KIA Forte. The contact stated while operating the vehicle at an undisclosed speed, the vehicle was misfiring, severely shaking and was losing motive power suddenly while operating on multiple constantly for about 3 weeks, and state she noticed a check engine warning light illuminated. The vehicle was driven to a independent mechanic where it was diagnosed to be a timing chain failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 113,922.

NHTSA ID

11735523

Incident

Apr 13, 2026

Mileage

113,922 mi

The contact owns a 2017 Kia Forte. The contact stated that while driving at 30 MPH, there was an abnormal screeching sound coming from the engine. There was no warning light illuminated. The contact attempted to pull off to the side of the road, and the vehicle shut off. The contact attempted to jumpstart the vehicle, but after several attempts, the vehicle failed to start. Due to the failure, the vehicle was towed to a dealer and was diagnosed with engine failure. The contact was initially informed that the engine would be replaced free of charge; however, the contact was later informed that there would be a charge for labor. The contact declined the repair. The manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 110,000.

NHTSA ID

11732388

Incident

Aug 1, 2025

Mileage

110,000 mi

Failure of the engine oil pump pertaining to the exact situation covered in NHTSA campaign 21V-260, but vehicle is not covered. The campaign covered vehicles manufactured from June 5, 2017 to July 24, 2017. Vehicle was manufactured in Mexico, is equipped with the 2.0 Nu MPI engine. The loss of motive power in the vehicle has increased the risk of crash and driver injury.

NHTSA ID

11723263

Incident

Mar 6, 2026

The vehicle went into Tasca Kia for a cam shaft replacement, this did not fix the issue and the vehicle needed an entire engine replacement under power train warranty. Since then, the vehicle has continuously stalled. The vehicle is not indicating a reason for stalling, it is documented in video, and I have continued to inform the dealership where the vehicle is. This vehicle has shut off on me at rates of speed of 60 mph, comes to a complete stop, and is a HUGE safety concern. I have reported it to the dealer every time, I have provided video, and I have left the vehicle with them, they have continued to ask me to pick up the vehicle and return the rental because they cannot recreate the problem and cannot continue to lose money on the rental. There are no prior issues, there were no warning lights or lights remaining on the dash when the stall happens.

NHTSA ID

11722521

Incident

Dec 18, 2025

Not providing enough oil pressure for my timing to function correctly.

NHTSA ID

11705805

Incident

Dec 6, 2025

My vehicle caught fire while driving also before fire vehicle started popping and stuttering rattling sound. I was on highway.

NHTSA ID

11701841

Incident

Nov 27, 2025

There are 3 recalls on my engine type but kia dealership says no recalls,#21V6220000,#22V031000,#21V260000. ENGINE TYOE 2.0L NU MPI ENGINE(SC210),MY ph#XXX INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11700945

Incident

Dec 31, 1969

Engine light came on around 81k miles and I've replaced several components and it fixed then light would come back on. I kept up on oil changes frequently. I had the spark plugs, o2 sensors replaced twice. It would idle low and or stall. The engine started knocking at 135k I still owe 9k on loan and it's the 2.0L NU MPI M/T ENGINE. PLEASE RECALL IT ALREADY SO MANY OWNERS ARE BEING SCREWED ON THIS VEHICLE.

NHTSA ID

11699846

Incident

Oct 10, 2025

Consumo excesivo de aceite / Defecto del motor - Kia Forte 2017 -Estimado NHTSA, Me gustaría informar de un problema de consumo excesivo de aceite en mi Kia Forte 2017, que parece estar relacionado con un defecto interno del motor similar a los problemas previamente identificados en otros motores Kia. Mi vehículo fue inspeccionado por un concesionario autorizado de Kia, Miami Lakes Kia (Florida). Realizaron una prueba oficial de consumo de aceite y confirmaron que el motor consume aproximadamente 1 litro de aceite cada 1.000 millas, lo que está muy por encima de los niveles normales. El concesionario recomendó reemplazar el motor debido al desgaste interno. Abrí un caso formal con Kia America (caso #25501358) antes de recibir su denegación. Kia America reconoció mi caso, pero más tarde declaró que mi vehículo está "fuera de garantía" y "no está incluido en el acuerdo o en la garantía extendida por consumo de aceite". A pesar de esto, el problema refleja claramente un defecto de fabricación que podría conducir a fallas del motor y riesgos de seguridad durante la conducción (pérdida de presión de aceite, posible convulsión del motor o estancamiento a velocidades de autopista). Solicito respetuosamente que la NHTSA revise este caso y lo incluya en cualquier investigación sobre el consumo excesivo de aceite o los defectos del motor en los motores Kia 2.0L "Nu". Gracias por su atención y por ayudar a proteger la seguridad del consumidor. Saludos cordiales.

NHTSA ID

11699178

Incident

Oct 30, 2023

Overconsumption of oil, led to engine damage and stalling. Car struggles to start and there is an engine knock. Mechanic advised that the car is not drivable as it will stall while driving as it has done previously and there was a noticeable burning smell when the car was running. Car is under 100,000 miles

NHTSA ID

11696833

Incident

Oct 30, 2025

I am the original owner of this car and get all my oil changes and regular maintenance on time. The car has 123k miles. I was getting into the freeway evening of 10/3 and my car stopped accelerating was making a loud noise so I pulled off to the side of the road. Per the Kia dealership service department my engine completely failed. This is a known issue with this year and model but Kia is not helping me in any way with the replacement of my engine. Please help.

NHTSA ID

11691778

Incident

Oct 3, 2025

About September 6th I was driving my vehicle. It is a blue Kia forte 2017. I just had cleaned it at a local car wash. Prior to this 1-2 weeks before my ac had just started to blow hot air. So I recharged it with some recharge that I purchased a recharge can and my buddy Scott helped me put it into my low pressure air conditioning valve area. Soon after like I said when I was leaving a car wash. And I drove down to a gas station and as I start braking my car started running a lot slower. Then finally it almost halted and all the dash lights all illuminated everywhere. And I had to turn the wheel super slow as I approached the left turn into the gas station. And then I noticed my car had shut off completely. I screamed to the men that were at a gas pump feet away to help me push the car into the station. They finally ran over and pushed it into the station. Soon after we attempted with one car, and one truck we tried to jump start my car with the batteries. It didn’t start or turn the engine over fully either few times we attempted jumping it. I finally called it quits and took a ride home. The next day my buddy tried to “ fix it “ he said it didn’t really work as properly and the battery isn’t probably the problem. He said it might be the ac compressor due to my air going out weeks before. But he was afraid to tell me it wasn’t gonna be a cheap or easy fix. He suggested I go to a mechanic. Months prior I received a few notices in the mail that stated my name and my vehicle info. I never really paid them any mind until now but I am thinking I should open them soon. I’m assuming that this info would be in there about a recall. I hope that this will be a substantial amount of evidence for my recall. The websites I reviewed and researched say the there’s a lawsuit and recalls involving my Kia forte 2017 as well. But the vin didn’t match it up fully? So I’m not completely sure why. But I am sure it only had 96k miles. Which was below the Kia 100k mile warranty too? Thanks

NHTSA ID

11690694

Incident

Sep 6, 2025

my life was unsafe by being put in this vehicle whos engine was damaged and caught on fire while driving it as a MILITARY soldier.

NHTSA ID

11688218

Incident

Jul 5, 2025

I am writing to you today regarding a persistent issue I'm experiencing with my 2017 Kia Forte. On several occasions, while driving at various speeds and coming to a stop, the vehicle has stalled. Each time, I was able to restart the vehicle after the stall. I took the car to an independent mechanic, who discovered debris from the skirt in the oil and informed me that the engine would need to be replaced. Additionally 2 days upon purchase the coils were replaced and about 5 times after that I am concerned that this issue may be related to an unknown recalls for both the coil and the engine, as I've seen similar reports. The current mileage on the vehicle is 134,071. I have already notified the manufacturer about this failure but they stated they couldn't do anything even through this started 2 days after my purchase I would appreciate any assistance you can provide in resolving this matter.

NHTSA ID

11687694

Incident

Aug 1, 2023

The contact owns a 2017 Kia Forte. The contact stated that the vehicle hesitated while depressing the accelerator pedal, with the check engine warning light illuminated. The vehicle was taken to an independent mechanic, where a scanner determined that there was a failure with the crankshaft. The contact replaced the spark plugs and crankshaft; however, the failure returned. The vehicle was taken to another independent mechanic ,where a defect with the timing belt was found, and the mechanic discovered metal shavings inside the oil pump. The contact stated that an oil change was performed on the vehicle, but the failure persisted. The contact was then informed by the mechanic that the failure was possibly linked to NHTSA Campaign Number: 21V260000 (Engine and Engine Cooling); however, the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 120,000.

NHTSA ID

11687610

Incident

Jan 21, 2025

Mileage

120,000 mi

Dear National Highway Traffic Safety Administration, I am submitting this safety complaint to request an investigation into the adequacy of Kia Motors’ recall coverage for oil pump failures in the 2017 Kia Forte. My vehicle recently experienced a complete oil pump failure, creating a serious risk of sudden engine seizure and potential loss of vehicle control. This type of failure poses an immediate danger to both occupants and other motorists. While Kia has issued recalls and service campaigns addressing oil pump defects in certain models and production ranges, my vehicle identification number (VIN) is not included—despite my case matching the symptoms, mechanical failures, and safety concerns described in those campaigns. This raises concern that the current recall scope is too limited and does not adequately protect all affected owners. Under the National Traffic and Motor Vehicle Safety Act, manufacturers are required to address safety-related defects in all affected vehicles at no cost to the consumer. If the recall scope is incomplete, other Kia Forte owners remain at risk of sudden mechanical failure, which could lead to crashes or injuries. I respectfully request that NHTSA review Kia’s recall parameters for this defect and determine whether additional VIN ranges should be included. I am prepared to provide detailed service records, diagnostic findings, and photographic evidence of the oil pump failure in my vehicle to assist with this review. Please confirm receipt of this complaint and inform me of the next steps in your investigation. I appreciate your attention to this urgent safety matter.

NHTSA ID

11682756

Incident

Jul 29, 2025

The contact owns a 2017 Kia Forte. The contact stated that while his son was driving 35 MPH, the timing chain tensioner snapped, causing the vehicle to lose automotive power. There was no warning light illuminated. The vehicle failed to restart and was towed to an independent mechanic where it was diagnosed and the contact was informed that the timing chain tensioner, and timing chain were faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 111,000.

NHTSA ID

11682120

Incident

Aug 4, 2025

Mileage

111,000 mi

Car started hesitating the RED OIL LIGHT came on on the dash it flickered on and off for a few days but and still goes on and off now but 90% of the time it stays on while car is in use. I don't have an oil leak and I'm not low on fluid. I believe foreign particles are getting clogged in oil pump and or filter. Most 2017 kia fortes already have a recall for this. I don't understand why mine isn't recalled also. Plz help. If I have engine damage and car stalls it could be a safety hazard for me and others. I have small children. Please help.

NHTSA ID

11681500

Incident

Aug 15, 2025

My car is experiencing signs of the Kia Oil Pump recall that my VIN was not included in. However, I believe that needs to be reevaluated, as my car is having those same issues, as in engine failure due to oil pump issues. My car is now currently unable to turn on due to this issue.

NHTSA ID

11678342

Incident

Jul 29, 2025

The contact owns a 2017 Kia Forte. The contact stated that on several occasions, while driving at undisclosed speeds and coming to a stop, the vehicle stalled. The vehicle was able to restart after each failure. The vehicle was taken to an independent mechanic, and it was discovered that there was debris from the skirt found in the oil, and that the engine needed to be replaced. The vehicle was then towed to a dealer, but was not yet diagnosed. The vehicle was not repaired. The contact believed that the failure was associated with an unknown recall. The manufacturer was notified of the failure. The failure mileage was 134,071.

NHTSA ID

11678242

Incident

Aug 2, 2025

Mileage

134,071 mi

Unknown vehicle just went dead while driving

NHTSA ID

11676143

Incident

Jul 6, 2025

There is high oil consumption in my catalytic converter due to a failed oil pump or piston ring. I've just got this car in march haven't even put 10,000 miles on it. Kept up with maintenance oil changes. And currently undrivable.

NHTSA ID

11675777

Incident

Jun 8, 2025

Stalling when slowing or stopping.

NHTSA ID

11675014

Incident

Jul 1, 2025

I have been financing this vehicle since [XXX], I was driving to Tucson, AZ from Flagstaff, AZ. About 30 minutes into my drive my car made a loud noise, the engine and oil lights came on at the same time, my car started shaking and the engine was smoking. I have never experienced anything like that and I was extremely fearful for my life. I was alone on the interstate for some hours before I could figure out how to get back to Flagstaff… I got my car towed to a mechanic, they ran diagnostics and said my car has catastrophic engine failure, one of the rods shot through the engine. They found a used engine to replace my engine with, but the quote is nearly $8,000. The car itself is about $11,000. I am making minimum wage, I am already struggling to make ends meet as is, I poured a lot of money into that vehicle and I really trusted Camelback Subaru to help get me into a safe, reliable car to help me get to work and live my life, I just never imagined something like this would happen. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11674009

Incident

Jul 10, 2025