2007 Kia Sedona Brakes Problems

The contact owns a 2007 Kia Sedona. The contact stated that while his son was in the driveway about to drive off, the vehicle started smoking. There were no warning lights illuminated. The contact associated the failure with NHTSA Campaign Number: 20V088000 (Electrical System, Service Brakes, Hydraulic). The contact would replace the parts. The contact stated that the manufacturer was delaying the repair and the buyback process. The vehicle was taken to the local dealer, and the contact was informed that parts were on backorder. The vehicle was not diagnosed or repaired. The manufacturer was contacted, and a case was opened. The manufacturer offered a buyback. The failure mileage was approximately 210,000.

NHTSA ID

11753707

Incident

Jul 4, 2026

Mileage

210,000 mi

The contact owns a 2007 Kia Sedona. The contact stated that while the vehicle was parked, she was informed that smoke was emanating from the vehicle, after which she observed flames emanating from the engine compartment on the driver's side. Bystanders were able to extinguish the flames with a fire extinguisher. Local emergency services arrived. The ABS warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the wiring harness. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic); the VIN was included, but the vehicle had already been repaired. A fire report was filed. A police report was not filed, and no injuries were reported. The contact also stated that while driving at an undisclosed speed, the hood suddenly unlatched, opened, and smashed into the front windshield. The contact was able to safely pull to the shoulder of the roadway, and attempted to close the hood, but the latch failed to remain secure. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the secondary hood latch assembly. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 16V389000 (Latches/Locks/Linkages); the VIN was included, but the vehicle had already been repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA hotline for assistance. The failure mileage was unknown.

NHTSA ID

11603392

Incident

Jul 19, 2024

The contact owns a 2007 Kia Sedona. The contact stated while driving at an undisclosed speed, the ESC and ABS warning lights illuminated. In addition, the contact stated that on several occasions, the check engine warning light illuminated. The contact stated that the brake light independently activated while the vehicle was parked. The vehicle was taken to an independent mechanic where it was diagnosed with a failed stop light switch. The vehicle was not repaired. The contact researched and discovered NHTSA Campaign Number: 20V088000 (Electrical System, Service Brakes, Hydraulic); however, the recall was not associated with the VIN. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 160,000.

NHTSA ID

11600890

Incident

Jul 10, 2021

Mileage

160,000 mi

The contact owns a 2007 Kia Sedona. The contact stated that he initially received notification of NHTSA Campaign Number: 20V088000 (Electrical System, Service Brakes, Hydraulic). A year after the recall repair was performed, while his wife was driving 55 MPH, grayish smoke started coming from under the hood. While she was pulling over, the ABS warning light illuminated the instrument panel due to both front brake calipers locking up. The contact’s wife allowed the vehicle to cool down for a while and was able to restart the vehicle and drive home without further incidence. The contact, who is a mechanic, then drove the vehicle to his dealer for an inspection and discovered that water had entered the EBCM (Electronic Brake Control Module) which caused the module to corrode. The contact also discovered that both fuses in the under-hood fuse block had blown which caused the smoke. Upon replacing the fuses, the same failure recurred with smoke coming from the engine due to the replacement fuses being blown. The contact then spoke with the dealer where the recall was performed and was provided a diagnostic fee to inspect the vehicle. The contact then reached out to the manufacturer where he was provided a case number but had not yet received a follow-up call from the manufacturer. The vehicle had yet to be repaired. The failure mileage was 135,701.

NHTSA ID

11465330

Incident

May 1, 2022

Mileage

135,701 mi

vehicle break lights, Cruze control does not work at all ESV light stay on

NHTSA ID

11424363

Incident

May 1, 2021

THE KIA VAN WAS PARKED , TURNED OFF, KEYS WERE REMOVED, OUTSIDE IN OUR BUSINESS PARKING LOT. A PERSON DRIVING BY NOTICED IT WAS ON FIRE AND CALLED THE FIRE DEPARTMENT. THIS HAPPENED AROUND 12 AM. (MIDNIGHT) THE LOCAL FIRE DEPARTMENT RESPONDED TO THE CALL AND REPORTED TO THE SCENE.

NHTSA ID

11361085

Incident

Sep 24, 2020

Mileage

220,000 mi

TL* THE CONTACT OWNS A 2007 KIA SEDONA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V088000 (ELECTRICAL SYSTEM, SERVICE BRAKES, HYDRAULIC) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. NEITHER THE MANUFACTURER NOR THE DEALER WERE MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ID

11322082

Incident

Mar 23, 2020

SOME ELECTORAL PROBLEMS ARE HAPPENING. WHEN DRIVING OR PARKED THE BRAKE LIGHTS APPEAR IN FLASHING MANNER AND DURING THAT 5 SECOND TIME IT WILL LOCK AND UNLOCK MY WINDOWS AND IF I AM USING MY SUPPERS THEY STOP WORKING SOMETIMES. ALSO SOMETIME THE WINDOWS DONT WORK AND THEBRADIO ALSO MESSES UP AND CHANGES STATION WITH OUT ME TOUCHING IT. THISBHAS BEEN AN ONGOING THING FOR AG LEAST 3 YEARS. ALSO IT USE TO NOT STARTVAT FORB2 DAYS AND THEN ITBWOUKDBSTART WITH NO HELP. I WOUKD COME THROUHH THE PASENGERS SIDE AND STARTBIT FINE. LOTS IF ELECTRIC ISSUES.

NHTSA ID

11310467

Incident

Feb 7, 2017

Mileage

85,000 mi

WHILE PARKED THE BRAKE TAIL LIGHTS STAY ON; WHILE DRIVING THE CRUISE CONTROL MALFUNCTIONS, AND ESC LIGHT INDICATOR ILLUMINATES AND STAYS ON. IT IS THE SAME PROBLEMS AS THE RECALL NHTSA #13V114000 AND THE KIA RECALL #SC098, BUT MY VIN NUMBER APPARENTLY ISN'T LISTED AS ONE THAT IS AFFECTED, WHICH IT IS! I HAVE NOTICED IT A COUPLE OF MONTHS AGO, BUT NOW THEY ALL ARE GETTING WORSE. I DID NOT KNOW IT WAS A RECALL PROBLEM.

NHTSA ID

11064196

Incident

Jan 18, 2018

Mileage

159,000 mi

STOP LAMP SWITCH WAS REPLACED IN 2013 DUE TO SAFETY RECALL 13V114000. AT PRESENT THE ESC LIGHT IS MALFUNTIONING AND THE VEHICLE WILL NOT SHIFT OUT OF PARK. TOOK THE VEHICLE TO OUR KIA DEALERSHIP AND THE SERVICE DEPARTMENT DETERMINED THAT A FAULTY STOP LAMP SWITCH WAS THE CAUSE. THE SWITCH WAS REPLACED AND VEHICLE OPERATES AS NORMAL. A REQUEST FOR REIMBURSEMENT HAS BEEN SUBMITTED TO KIA FOR THE COST OF THE REPAIR. THIS IS A MAJOR SAFETY CONCERN AND I FEEL IT IS THE RESPONSIBILITY OF KIA MOTORS TO ISSUE ANOTHER RECALL.

NHTSA ID

11060692

Incident

Dec 30, 2017

Mileage

159,048 mi

THE ESC LIGHT ILLUMINATED IN MY KIA SEDONA FOR TWO YEARS ON AND OFF NOT UNTIL RECENTLY DID I REALIZE WHEN THIS HAPPED THE BRAKE LIGHTS WOULD NOT ILLUMINATE. I BROUGHT CAR IN AND WAS CHARGED $250 TO REPLACE THE BRAKE LIGHT SWITCH. I SAW THIS WAS A RECALL ON 2007 KIA SEDONA BUT DEALER STATED IT DID NOT INCLUDE MY KIA SEDONA HOW CAN THE SAME EXACT THING THAT HAPPENED ON ALMOST 1 MILLION KIA AND HYUNDAI NOT BE THE SAME THING ON MY KIA SEDONA. I BELIEVE MY KIA SHOULD HAVE BEEN PART OF THE RECALL AND I SHOULD BE ISSUED A REFUND FOR THIS REPAIR.

NHTSA ID

11005861

Incident

Jul 4, 2015

Mileage

80,000 mi

BRAKE LIGHTS NOT ILLUMINATING, ESC LIGHT IS ON THAT IT IS NOT FUNCTIONING CHECK ENGINE LIGHT LOOKED UP THAT IT WAS A RECALL ON 2007 KIA SEDONA BUT WHEN ENTERING MY VIN # IT DOES NOT SHOW UP

NHTSA ID

10914068

Incident

Oct 1, 2016

Mileage

93,000 mi

THE ELECTRICAL DOORS STOPPED WORKING AND DO NOT LATCH, THE DOOR FLY OPEN WHEN WE TURN A CORNER. THE ESC LIGHT IS ON. MY BRAKES AND TRANSMISSION HAS MALFUNCTIONED.. MALFUNCTIONS IN SC 134. SC133. SC098. THE ;SUSPENISION AND CLICKS AND CLUTTERS. SINCE THIS YEAR ALONE MY VAN HAS MALFUNCTIONED IN ALL THE AREAS, U CAN SEE WHEN LOOKED AT...THE DOORS ALONE ARE DANGERIOUS.

NHTSA ID

10883872

Incident

Jun 3, 2016

Mileage

130,000 mi

A YEAR AGO I DO RECEIVE A RECALL LETTER NOTIFYING FOR RUSTY LOWER ARMS WHEELS TO BE REPLACED BUT SUCH THING NEVER HAPPENED. THE DEALER JUST APPLY MORE RUST INHIBITORS BUT PROCEDURES WAS NOT THE APPROPRIATE CURE FOR THE PROBLEM. WHEN THE VEHICLE IS ON MOTION A VERY DISTURBING NOISE CAME JUST UNDER THE WHEELS. SEE PICTURES THEY ARE MORE SELF EXPLANATORY JUST THE DRIVER SIDE IT'S SHOWN DUE TO FILE LIMITATION.

NHTSA ID

10873523

Incident

Jun 4, 2016

TAKATA RECALL THERE IS A POPPING SOUND UNDER THE VAN WHILE YOU ARE DRIVING DOESNT MATTER WHAT KIND OF ROAD YOU ARE ON UNKNOWN WHAT PART IT IS THE ESC LIGHT KEEPS COMING ON DOESNT MATTER WHAT KIND OF ROAD YOU ARE ON AND THE BRAKES KEEP ACTING LIKE THEY ARE GOING OUT DOESNT MATTER WHAT KIND OF ROAD YOU ARE ON

NHTSA ID

10854611

Incident

Jan 15, 2016

Mileage

100,000 mi

BRAKE LIGHT SWITCH IS MALFUNCTIONING, BUT THIS VEHICLE IS NOT INCLUDED AS PART OF THE 2013 RECALL FOR THIS SAME ISSUE IN OTHER KIA AND HYUNDAI CARS.

NHTSA ID

10825747

Incident

Feb 11, 2016

TL* THE CONTACT OWNS A 2007 KIA SEDONA. WHILE DRIVING AT APPROXIMATELY 25 MPH, THE VEHICLE ACCELERATED INDEPENDENTLY. THE BRAKE PEDAL WAS DEPRESSED, BUT THE VEHICLE CONTINUED TO ACCELERATE. IN ORDER TO STOP THE VEHICLE, IT HAD TO BE RESTARTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 61,000.

NHTSA ID

10788244

Incident

Nov 3, 2015

Mileage

61,000 mi

TL* THE CONTACT OWNS A 2007 KIA SEDONA. WHILE DRIVING APPROXIMATELY 70 MPH DRIVING DOWN THE HIGHWAY, THE ACCELERATOR AND BRAKES FAILED. THE CONTACT SHIFTED THE VEHICLE INTO NEUTRAL AND PULLED OVER TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO THE DEALER WHO DIAGNOSED THAT THE BRAKE SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 96,750. THE VIN WAS NOT AVAILABLE.

NHTSA ID

10715887

Incident

May 10, 2015

Mileage

96,750 mi

THERE WAS A RECALL FOR 2007 KIA SEDONA REGARDING 2007 KIA SEDONA RECALL, ITEM AFFECTED: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH, DATE ANNOUNCED: 4/17/2009, AFFECTING VEHICLES MADE 9-20-2006 THRU 11-20-2006, HOWEVER MY VEHICLE WAS MADE 11-28-2006, EVERYTHING ON THE RECALLS DESCRIBES WHAT MY VEHICLE WAS EXPERIENCING.(THE STOP LAMP SWITCH IN THE AFFECTED VEHICLES MAY MALFUNCTION. A MALFUNCTIONING STOP LAMP SWITCH MAY CAUSE THE BRAKE LIGHTS TO NOT ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED OR MAY CAUSE THE BRAKE LIGHTS TO REMAIN ILLUMINATED WHEN THE BRAKE PEDAL IS RELEASED. A STOP LAMP SWITCH MALFUNCTION MAY ALSO AFFECT THE OPERATION OF THE BRAKE-TRANSMISSION SHIFT INTERLOCK FEATURE SO THE TRANSMISSION SHIFTER WOULD NOT BE ABLE TO BE SHIFTED OUT OF THE PARK POSITION. IT MAY ALSO CAUSE THE ELECTRONIC STABILITY CONTROL (ESC) MALFUNCTION LIGHT TO ILLUMINATE, AND IT MAY NOT DEACTIVATE THE CRUISE CONTROL WHEN THE BRAKE PEDAL IS DEPRESSED.) KIA CUSTOMER SERVICE SAID THEY WOULD NOT COVER MY PROBLEM BECAUSE THEY STATED IT WAS FIXED WITH THE PREVIOUS MODELS AND ALL MODELS MANF. AFTER 11-20-2006. THEY ADVISED ME TO FILE A COMPLAINT WITH YOU. *TR

NHTSA ID

10422515

Incident

Aug 23, 2011

Mileage

138,400 mi

TL* THE CONTACT OWNS A 2007 KIA SEDONA. WHILE STOPPED AT A STOP LIGHT THE CONTACT WAS INFORMED BY ANOTHER DRIVER THAT THE VEHICLE'S BRAKE LIGHTS WERE NOT FUNCTIONING. THE MANUFACTURER WAS CONTACTED AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN RECALL 09V130000 EXTERIOR LIGHTING: BRAKE LIGHTS: SWITCH. THE CONTACT NOTICED PRIOR THAT THE CRUISE CONTROL FEATURE WOULD NO LONGER FUNCTION AND THE ESC LIGHT HAD APPEARED ON THE INSTRUMENT PANEL. THE VEHICLE HAD NOT BEEN DIAGNOSED. THE CURRENT AND FAILURE MILEAGES WAS 68000.

NHTSA ID

10340770

Incident

Jun 23, 2010

Mileage

68,000 mi

TL*THE CONTACT OWNS A 2007 KIA SEDONA. THE CONTACT STATED THAT THE BRAKE LIGHT SWITCH FAILED WHICH ALSO PROHIBITS THE GEAR SHIFT FROM MOVING OUT OF THE PARK POSITION. THE ELECTRONIC STABILITY CONTROLS HAVE ALSO MALFUNCTIONED AS A CONSEQUENCE. THE DEALER REPLACED THE STOP LAMP SWITCH TWICE PRIOR TO THE RECALL; HOWEVER, THE REPLACEMENT PARTS HAS MALFUNCTIONED AGAIN. THE RECALL#09V130000, COMPONENT: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH WAS ISSUED AFTER THE REPLACEMENT OF CONTACT VEHICLE AND HIS VEHICLE IS NOT INCLUDED IN THIS RECALL. THE CONTACT WAS ALSO RESPONSIBLE FOR PAYING THE REPAIR COST. THE FAILURE MILEAGE WAS 30,000 THE CURRENT MILEAGE WAS 61,105.

NHTSA ID

10298555

Incident

Mar 8, 2008

Mileage

61,105 mi

TL*THE CONTACT OWNS A 2007 KIA SEDONA. THE CONTACT FEELS A LARGE AMOUNT OF VIBRATION IN THE BRAKES AND BRAKE PEDAL WHEN DEPRESSED. THE VIBRATIONS ARE ESPECIALLY NOTICEABLE WHEN TRAVELING DOWNHILL. THE DEALER MACHINED THE ROTORS IN AUGUST AND DECEMBER OF 2007, AND ALSO ON FEBRUARY 21, 2008. THE CURRENT MILEAGE WAS 10,600 AND FAILURE MILEAGE WAS 4,600. UPDATED 03/10/08. *LJ

NHTSA ID

10218833

Incident

Aug 9, 2007

Mileage

4,600 mi

I HAVE THIS KIA SEDONA SINCE SEPTEMBER 2007. IT HAS A CONSTANT SQUEALING ON THE BRAKES I TOOK IT TWICE SO FAR INTO TWO DIFFERENT DEALERSHIPS TO HAVE THEM CHECKED OUT THEY SAY IS A "NORMAL NOISE". TODAY I EXPERIENCED A GRINDING/PULSATING NOISE COMING FROM THE BRAKES WHEN I PUSHED THEM TO COME TO A STOP SIGN. I WAS AFRAID I CANNOT STOP. I AM GOING AGAIN TOMORROW TO HAVE IT CHECKED, BUT I KNOW THE ANSWER. PLEASE HELP! *TR

NHTSA ID

10211284

Incident

Dec 9, 2007

Mileage

16,725 mi