2007 Kia Sedona Engine Problems

The contact owns a 2007 Kia Sedona. The contact stated that while his son was in the driveway about to drive off, the vehicle started smoking. There were no warning lights illuminated. The contact associated the failure with NHTSA Campaign Number: 20V088000 (Electrical System, Service Brakes, Hydraulic). The contact would replace the parts. The contact stated that the manufacturer was delaying the repair and the buyback process. The vehicle was taken to the local dealer, and the contact was informed that parts were on backorder. The vehicle was not diagnosed or repaired. The manufacturer was contacted, and a case was opened. The manufacturer offered a buyback. The failure mileage was approximately 210,000.

NHTSA ID

11753707

Incident

Jul 4, 2026

Mileage

210,000 mi

Car stopped working on highway, took to dealer where we got it used a year prior. Shop said these engines are notorious for failure. They said the engine was needing to be replaced due to malfunction of vehicle

NHTSA ID

11542507

Incident

Aug 28, 2023

The contact owns a 2007 Kia Sedona. The contact stated that he initially received notification of NHTSA Campaign Number: 20V088000 (Electrical System, Service Brakes, Hydraulic). A year after the recall repair was performed, while his wife was driving 55 MPH, grayish smoke started coming from under the hood. While she was pulling over, the ABS warning light illuminated the instrument panel due to both front brake calipers locking up. The contact’s wife allowed the vehicle to cool down for a while and was able to restart the vehicle and drive home without further incidence. The contact, who is a mechanic, then drove the vehicle to his dealer for an inspection and discovered that water had entered the EBCM (Electronic Brake Control Module) which caused the module to corrode. The contact also discovered that both fuses in the under-hood fuse block had blown which caused the smoke. Upon replacing the fuses, the same failure recurred with smoke coming from the engine due to the replacement fuses being blown. The contact then spoke with the dealer where the recall was performed and was provided a diagnostic fee to inspect the vehicle. The contact then reached out to the manufacturer where he was provided a case number but had not yet received a follow-up call from the manufacturer. The vehicle had yet to be repaired. The failure mileage was 135,701.

NHTSA ID

11465330

Incident

May 1, 2022

Mileage

135,701 mi

TL* THE CONTACT OWNS A 2007 KIA SEDONA. THE CONTACT STATED WHILE HER HUSBAND WAS DRIVING WITH HER AND THEIR DAUGHTER AND GRANDCHILD IN THE VEHICLE AT 25 MPH, THE VEHICLE STALLED IN THE MIDDLE OF THE ROAD. THE CONTACTS HUSBAND ATTEMPTED TO RESTART THE VEHICLE BUT IT WOULD NOT START. THE CONTACT AND HER HUSBAND THEN GOT OUT OF THE VEHICLE AND PUSHED THE VEHICLE TO THE SIDE OF THE ROAD. WHEN THEY PUSHED THE VEHICLE TO THE SIDE OF THE ROAD. THE CONTACTS HUSBAND LIFTED UP THE FRONT HOOD OF THE VEHICLE AND SAW A FIRE COMING FROM UNDERNEATH THE VEHICLE ENGINE. THE CONTACTS HUSBAND WAS ABLE TO WAIVE DOWN A DRIVER WHO STOPPED AND USED A FIRE EXTINGUISHER TO TRY TO PUT OUT THE FIRE UNTIL THE FIRE DEPARTMENT CAME TO THE SCENE AND EXTINGUISHED THE FIRE FULLY. NO ONE WAS PHYSICALLY INJURED BUT THEY DID INHALE A LOT OF SMOKE. A FIRE DEPARTMENT REPORT WAS FILED. THE CONTACT AND HER HUSBAND, THEIR DAUGHTER, AND THEIR GRANDCHILD WENT TO THE HOSPITAL FOR MEDICAL TREATMENT FOR INHALING THE SMOKE FROM THE FIRE. EVERYONE WAS RELEASED WITH NO ISSUE. THE VEHICLE WAS TOWED TO A TOW LOT. THE VEHICLE WAS NOT INSPECTED, DIAGNOSED, OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 253,000.

NHTSA ID

11404227

Incident

Mar 14, 2021

Mileage

253,000 mi

I HAVE HANDED OVER MY CAR FOR REPAIRING ON 09-23-2020 WHICH IS STILL NOT FIXED AND STILL LYING WITH HORNE KIA SERVICE CENTRE GILBERT, ARIZONA. THEY HAVE MESSED UP MY CAR WAS DIAGNOSED TWICE IN A GAP OF 2 DAYS. HORNE KIA WANTS TO COVER UP THEIR TECHNICIAN (WHOM THEY CALL THE BEST IN THEIR TEAM) THEY HAVE MESS MY ENGINE AND SENDING ME A SECOND QUOTE TO CHANGE THE ENGINE. ON THE FIRST WEEK OCTOBER 2020, I DROVE MY CAR FOR 15 MILES AFTER COLLECTING FROM HORNE KIA GILBERT AND EXPERIENCED BUNCH OR NEW PROBLEMS ON THE ROAD. 1. THE CHECK ENGINE LIGHT WAS ON 2. THERE WAS HEAVY VIBRATION AND NOISE INSIDE MY CAR 3. MY CAR WOULD RANDOMLY HALT IN THE MIDDLE OF THE ROAD, WHILE IN DRIVE MODE. SINCE THEN, MY CAR IS STILL LYING WITH HORNE KIA GILBERT, ARIZONA. I HAVE ATTACHED ALL THE EMAIL THREADS SENT/RECEIVED TO HORNE KIA GILBERT AND KIA CONSUMER ASST. CENTER. KINDLY LET ME KNOW IF YOU CAN HELP ME OUT TO SORT OUT THIS ONGOING ISSUE SINCE 09-23-2020.

NHTSA ID

11378059

Incident

Sep 29, 2020

Mileage

126,245 mi

OUR 2007 LOW MILEAGE KIA HAD BEEN PARKED FOR OVER 24 HRS. WHILE SITTING IN OUR DRIVEWAY NOT RUNNING, NO KEYS IN IGNITION, CAUGHT FIRE AND BURNED TO THE GROUND. THE FIRE TRAVELLED TO MY STORAGE BUILDING. WE LOST EVERYTHING IN OUR STORAGE AND OUR VEHICLE. KIA ASSUMES NO FAULT. ATTACHED IS FIRE DEPARTMENT REPORT AND PICS OF THE DAMAGE.

NHTSA ID

11098160

Incident

May 12, 2017

Mileage

70,000 mi

WE WENT ON A ROAD TRIP FROM OHIO TO TEXAS AND THE VEHICLE STARTED MAKING A SOUND WE IMMEDIATELY PULLED IT OVER AND ALL THE LIGHTS (OIL, ENGINE, ETC) CAME ON. WE HAD IT TOWED TO A KIA DEALERSHIP AND FOUND OUT THAT THE WHOLE BOTTOM OF THE VEHICLE WAS CORRODED. THERE WAS A HOLE IN THE THE COOLANT LINE AND ALL OF THE COOLANT LEAKED OUT OF THE CAR CAUSING THE VEHICLE TO OVERHEAT AND DESTROYED THE ENGINE. THERE WAS NO WARNING ABOUT A PROBLEM WITH THE COOLANT LINE. NOW ALL OF THE LINES NEED TO BE REPLACED BECAUSE IT IS ALL CORRODED UNDERNEATH THE CAR. THEY ARE QUOTING OVER $20,000 OF REPAIR WORK FOR THE VEHICLE. WE HAVE UNDER 80,000 MILES. WE NEVER HAD THESE PROBLEMS ON OUR 2002 KIA SPECTRA THAT WE STILL OWN. KIA IS CURRENTLY UNWILLING TO REPAIR OR REPLACE THIS DEFECTIVE VEHICLE. *TR

NHTSA ID

10695504

Incident

Mar 17, 2015

Mileage

79,000 mi

TL* THE CONTACT OWNED A 2007 KIA SEDONA. WHILE THE VEHICLE WAS PARKED, THE ENGINE COMPARTMENT CAUGHT FIRE. THE FIRE DEPARTMENT WAS ABLE TO EXTINGUISH THE FIRE. A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 80,000.

NHTSA ID

10694517

Incident

Mar 8, 2015

Mileage

80,000 mi

I HAVE READ SEVERAL COMPLAINTS ABOUT THIS SAME THING I HAVE EXPERIENCED NOW ON THREE SEPARATE OCCASIONS. I TOO HAVE SUDDENLY LOST POWER AND THE ESC LIGHT AND CHECK ENGINE LIGHT COMES ON. THE GAS PEDAL IS VIRTUALLY DEAD, YOU PUSH THE PEDAL TO THE FLOOR AND ALL YOU GET IS ABOUT 1500 RPM AND ABOUT 20 MPH. IF YOU PULL OVER AND TURN THE CAR OFF AND RE-START IT, IT WILL WORK. VERY DANGEROUS TO BE GOING DOWN THE ROAD AND SUDDENLY LOSE POWER. *TR

NHTSA ID

10643195

Incident

Aug 15, 2013

Mileage

59,000 mi

I HAVE BEEN HAVING AN INTERMITTENT "NON-START" ISSUE WITH MY CAR. I WOULD TURN THE KEY AND NOTHING. THE LIGHTS WOULD GO ON, RADIO WOULD GO ON, BUT THE CAR WOULDN'T DO ANYTHING TOWARDS CRANKING AND STARTING. NO CLICKING NOISE, NOTHING. I WOULD GET OUT OF THE CAR OPEN AND CLOSE SOME DOORS AND MOST OF THE TIME IT WOULD START. ALSO, I WAS DRIVING ON THE HIGHWAY WHEN THE ESC OFF LIGHT CAME ON. WHENEVER I STOPPED IT WOULD GO OFF UNTIL I GOT BACK ON THE HIGHWAY AGAIN. I HAD MY MECHANIC PLUG IT IN TO SEE IF ANY ERROR CODES SHOW, BUT THERE WAS NOTHING. I CHECKED ONLINE AND FOUND A RECALL FOR THESE EXACT ISSUES TIED TO THE STOP LAMP SWITCH, BUT WHEN I TOOK THE CAR TO KIA DEALERSHIP THEY SAID THEY HAD FIXED THE RECALL A COUPLE YEARS EARLIER. I BOUGHT A NEW STOP LAMP SWITCH MYSELF, (GENUINE KIA PART, NOT GENERIC,) AND HAD IT REPLACED AGAIN. (CHEAP PART OF AND INSTALLATION.) I THEN WENT ON ROAD TRIP AND NOTHING WAS FIXED. ESC OFF LIGHT WAS ON NEARLY THE WHOLE TIME AND I HAD A NON-START DURING TRIP. THERE HAS TO BE ANOTHER ISSUE INVOLVED HERE. I LIVE IN NEW YORK CITY SO I HARDLY EVER AM DRIVING ON HIGHWAYS, SO ROAD TRIPS WAS ONLY TIME I WOULD SEE ESC OFF LIGHT AND I RARELY IF EVER USE CRUISE CONTROL, SO I DON;T KNOW IF I WOULD HAVE THE CRUISE CONTROL ISSUE TIED TO THIS STANDARD GROUP OF ISSUES EITHER. *JS

NHTSA ID

10617152

Incident

Aug 1, 2013

Mileage

45,000 mi

TL* THE CONTACT OWNS A 2007 KIA SEDONA. THE CONTACT WAS DRIVING 35 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT ATTEMPTED TO RESTART THE VEHICLE SEVERAL TIMES BEFORE IT WOULD START. THE FAILURE RECURRED SEVERAL TIMES. THE DEALER WAS NOTIFIED BUT OFFERED LITTLE ASSISTANCE. THE MANUFACTURER WAS ALSO NOTIFIED AND ADVISED THE CONTACT THAT THEY WOULD BE IN CONTACT WITH THE HER AT A LATER DATE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 109,076.

NHTSA ID

10468950

Incident

Jan 3, 2012

Mileage

109,076 mi

TL*THE CONTACT OWNS A 2007 KIA SEDONA. WHEN DRIVING VARIOUS SPEEDS UP TO 35 MPH, THE VEHICLE UNEXPECTEDLY LOST POWER AND DECREASED SPEED. THE CONTACT WAS ABLE TO DRIVE TO THE EMERGENCY LANE AND SHUT THE ENGINE OFF; HOWEVER, THE FAILURE RECURRED. ON FOUR OCCASIONS THE DEALER HAS UNSUCCESSFULLY ATTEMPTED TO REPAIR THE VEHICLE. THE MECHANIC REPLACED THE OXYGEN TUBE, OXYGEN SENSORS, AND TIGHTENED THE WIRES; HOWEVER, THE FAILURE CONTINUED TO OCCUR. THE CONTACT IS AWARE OF THE SAFETY RISK AND THE INSIST THAT THE FAILURE IS RELATED TO A MANUFACTURER'S DEFECT. THE FAILURE MILEAGE WAS 25,200 AND THE CURRENT MILEAGE WAS 26,000.

NHTSA ID

10281728

Incident

Jul 17, 2009

Mileage

25,200 mi

CONSUMER HAD PROBLEMS WITH TWO LEASED KIA SEDONA AND WITH THE DEALERSHIP. *NJ THE CONSUMER HEARD AN AWFUL RATTLE NOT LONG AFTER HAVING AN OIL CHANGE. IT WAS DISCOVERED THAT THERE WAS NO OIL IN THE RESERVOIR AND OIL WAS ALL OVER THE VEHICLE. THE CONSUMER WAS ABLE TO GET TO A REPAIR SHOP AND THE MECHANIC INFORMED HIM THERE WAS NO OIL AND THE FILTER WAS NOT PROPERLY INSTALLED. THE VEHICLE BEGAN TO SHIMMY AND SHAKE. THE DEALER STATED THE PROBLEM WAS A DEFECTIVE CABLE, HOWEVER THE SHIMMY AND SHAKE RETURNED. THE CHECK ENGINE LIGHT ILLUMINATED. THE CONSUMER STATED THE SECOND SEDONA BLEW A FUSE WITHIN THE FIRST MONTH. THEN, TWO MONTHS LATER THE VEHICLE WOULD NOT START. THE DEALER REPLACED THE BATTERY AND THIS VEHICLE ALSO RATTLED. *JB

NHTSA ID

10243710

Incident

Jan 1, 1901

TL*THE CONTACT OWNS A 2007 KIA SEDONA. WHILE DRIVING AT ANY SPEED, THE VEHICLE HESITATES AS IF IT WILL STALL. THE CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY PERFORMED A DIAGNOSTIC, WHICH PRODUCED MISFIRE CODE NUMBERS P0305 AND P0300. THE VEHICLE WAS BEEN TO THE DEALER APPROXIMATELY 4 TIMES WITH NO RESOLUTION. IN ADDITION, BOTH SLIDING POWER DOORS WERE UNLOCKING AND SLIDING INTERMITTENTLY ON THEIR OWN. THE CURRENT MILEAGE WAS 22,560 AND FAILURE MILEAGE WAS 19,582.

NHTSA ID

10243343

Incident

Aug 15, 2007

Mileage

19,582 mi

I HAVE A 2007 KIA SEDONA WITH 6,000 MILES ON IT. I WAS DRIVING IT AND ALL OF A SUDDEN THE CHECK ENGINE LIGHT STARTED FLASHING AND THE VEHICLE HAD SEVERE MISFIRES. I TOOK IT TO THE DEALER THE NEXT DAY AND IT CLEARED UP ON THE WAY BUT CHECK ENGINE LIGHT REMAINED ON. THEY TOLD ME IT WAS GOOD AND THERE WAS A TECHNICAL SERVICE BULLETIN OUT FOR THE CHECK ENGINE LIGHT. WELL LATER THAT DAY CHECK ENGINE LIGHT CAME BACK ON. *TR

NHTSA ID

10210347

Incident

Nov 29, 2007

Mileage

5,900 mi

TL*THE CONTACT OWNS A 2007 KIA SEDONA. THE CHECK ENGINE WARNING INDICATOR LIGHT ILLUMINATED. THE VEHICLE WOULD JERK AT SPEEDS BETWEEN 5-35 MPH. THE VEHICLE WOULD SHAKE AS THOUGH IT WAS ABOUT TO STALL WHEN IN IDLE. THE DEALER STATED THAT THE COMPUTER IS CAUSING THE ENGINE TO MISFIRE. THE DEALER WAS UNABLE TO REPAIR THE FAILURE. THE CURRENT MILEAGE WAS 22,000. THE FAILURE MILEAGE WAS 15,000.

NHTSA ID

10200896

Incident

Apr 1, 2007

Mileage

15,000 mi