2023 Kia Sorento Hybrid Problems

While driving hybrid battery depletes and car stops accelerating. With pedal to the floor, it may get to 60 MPH, other times 15 MPH. Car doesn't sound great while this is happening. 3/4 times an error showed up stating "Check Hybrid System-Stop Safely". The 4th time the error didn't appear , but was driving on hilly road where battery charged when it was going down a hill. The problem occurred on back roads and Highways. It is VERY unsafe when you suddenly can't accelerate. The car was towed to a kia dealer twice. 1st time I was told it was "bad gas." $1,500 later, it happened again. The 3rd time I had it again towed to a Kia Dealer. 6 weeks later, I was told they couldn't find anything wrong, and Kia released the car. 1 week later, it happened again on the Highway. Dates of occurrence: November 17, 2025 November 25, 2025 December 11, 2025 February 9, 2026 (car was at the dealer from Dec 11-January 29th)

Vehicle suddenly loses power while driving. Engine does not turn on, vehicle will run on battery until battery is dead, then putting the vehicle in park once stopped. Vehicle will not accelerate normally since the engine does not turn on. Only goes 10-20 mph. Lights on the dash come on, prompting to keep car on to charge the battery. No code is found when the vehicle is scanned. Dealerships can't seem to diagnose the issue. This is a safety concern when driving on busy roads or state highways at higher speeds.

While driving on September 15, 2025, the vehicle displayed a loud beeping and the warning message “Check Hybrid System. Stop Safely.” The vehicle restarted about an hour later, but the combustion engine ran very rough. The Kia dealer inspected it but reported no stored error codes. On September 23, 2025, the vehicle suddenly lost power while driving. It appeared to operate only on electric at low speed, then died completely in the roadway. The vehicle would not power down until the start/stop button was held. It required a tow back to the dealer. Prior to the first incident, a faint electrical smoldering odor was present. The vehicle remains at the Kia dealer for evaluation. This is a serious safety concern because the vehicle experienced sudden loss of motive power and stalling in traffic, which put both myself and others at risk. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Vehicle suddenly loses power while driving. Engine does not turn on, vehicle will run on battery until battery is dead, then putting the vehicle in park once stopped. Vehicle will not accelerate normally since the engine does not turn on. Only goes 10-20 mph. Lights on the dash come on, prompting to keep car on to charge the battery. No code is found when the vehicle is scanned. Dealerships can't seem to diagnose the issue. This is a safety concern when driving on busy roads or state highways at higher speeds.

The contact owns a 2023 Kia Sorento. The contact stated that while driving approximately 40 MPH on several occasions, the vehicle stalled after the battery became drained. The vehicle was able to restart each time after waiting for the battery to recharge. The vehicle was taken to two different dealers on three occasions. During the first two visits, the dealer was unable to duplicate the failure. On the third visit, the failure was duplicated, but the dealer was unable to provide a cause for the failure. During a visit to the dealer, the vehicle stalled while a mechanic was driving it, and the vehicle was towed back to the dealer. The manufacturer was not notified of the failure. The failure mileage was 25,000.

While driving on September 15, 2025, the vehicle displayed a loud beeping and the warning message “Check Hybrid System. Stop Safely.” The vehicle restarted about an hour later, but the combustion engine ran very rough. The Kia dealer inspected it but reported no stored error codes. On September 23, 2025, the vehicle suddenly lost power while driving. It appeared to operate only on electric at low speed, then died completely in the roadway. The vehicle would not power down until the start/stop button was held. It required a tow back to the dealer. Prior to the first incident, a faint electrical smoldering odor was present. The vehicle remains at the Kia dealer for evaluation. This is a serious safety concern because the vehicle experienced sudden loss of motive power and stalling in traffic, which put both myself and others at risk. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving hybrid battery depletes and car stops accelerating. With pedal to the floor, it may get to 60 MPH, other times 15 MPH. Car doesn't sound great while this is happening. 3/4 times an error showed up stating "Check Hybrid System-Stop Safely". The 4th time the error didn't appear , but was driving on hilly road where battery charged when it was going down a hill. The problem occurred on back roads and Highways. It is VERY unsafe when you suddenly can't accelerate. The car was towed to a kia dealer twice. 1st time I was told it was "bad gas." $1,500 later, it happened again. The 3rd time I had it again towed to a Kia Dealer. 6 weeks later, I was told they couldn't find anything wrong, and Kia released the car. 1 week later, it happened again on the Highway. Dates of occurrence: November 17, 2025 November 25, 2025 December 11, 2025 February 9, 2026 (car was at the dealer from Dec 11-January 29th)

While driving on September 15, 2025, the vehicle displayed a loud beeping and the warning message “Check Hybrid System. Stop Safely.” The vehicle restarted about an hour later, but the combustion engine ran very rough. The Kia dealer inspected it but reported no stored error codes. On September 23, 2025, the vehicle suddenly lost power while driving. It appeared to operate only on electric at low speed, then died completely in the roadway. The vehicle would not power down until the start/stop button was held. It required a tow back to the dealer. Prior to the first incident, a faint electrical smoldering odor was present. The vehicle remains at the Kia dealer for evaluation. This is a serious safety concern because the vehicle experienced sudden loss of motive power and stalling in traffic, which put both myself and others at risk. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On passenger side interior between glove box and dashboard, there is a textured, metallic trim plate that during a sunny mid day, casts a reflection on the passenger side window over the top of the where the passenger side rear view mirror is.

I was driving my 2023 Kia Sorento on the I-5 freeway going about 70 MPH when the front-half of the panoramic sunroof spontaneously shattered and dropped glass into the cabin of the car. There was no debris, falling objects, or any other event to cause the glass the break. We were at a wide open area of the freeway with no overpasses and not much traffic around us. It had been almost freezing in the morning, but a very sunny day. We were traveling at about 4:30 PM pacific time on Oct. 28.

While driving hybrid battery depletes and car stops accelerating. With pedal to the floor, it may get to 60 MPH, other times 15 MPH. Car doesn't sound great while this is happening. 3/4 times an error showed up stating "Check Hybrid System-Stop Safely". The 4th time the error didn't appear , but was driving on hilly road where battery charged when it was going down a hill. The problem occurred on back roads and Highways. It is VERY unsafe when you suddenly can't accelerate. The car was towed to a kia dealer twice. 1st time I was told it was "bad gas." $1,500 later, it happened again. The 3rd time I had it again towed to a Kia Dealer. 6 weeks later, I was told they couldn't find anything wrong, and Kia released the car. 1 week later, it happened again on the Highway. Dates of occurrence: November 17, 2025 November 25, 2025 December 11, 2025 February 9, 2026 (car was at the dealer from Dec 11-January 29th)

The forward collision warning system and emergency braking were engaged when no forward object was present. Amount of times 2 Driver side rear quarter panel falsely detected a car swerving into my lane and engaged an emergency maneuver to avoid collision even though there was no car there. Amount of times 1

The sub roof exploded while on the freeway and all the glass shattered like rain onto the fabric underneath. We pulled over on the side of the freeway and are waiting for a tow. We didn't see any large objects fall or fly towards the car. It sounded like a huge explosion then left a big whole.

Sunroof Randomly exploded driving down the road.

I was driving down the highway when my vehicle shut off with no warning and the parking break engaged. I was stuck in the travel lane with cars flying by me going 50 plus MPH. My vehicle has 7000 miles on it. According to KIA the hybrid battery failed and they don’t know why. KIA has been no help and as far as I know they are not looking into this issue. Upon further research there has been multiple instances where this hybrid model has just shut down while the vehicle is moving and KIA has been unable to resolve the issue. Myself and my children could have been severely injured or killed. They need to get to the bottom of what is causing these hybrid batteries to fail on brand new vehicles.

car parked automatically while in drive. won't allow car to shift to drive or reverse due to "driving conditions not met". hybrid system light also randomly comes on.

Headlights will often turn on when unnecessary in Auto mode, for example when the sun is shining but there is no sun directly on the sensor, the headlights will turn on, when driving for example in a shady area with trees, the headlights could end up turning off and on very quickly, making it look like your trying to get someone’s attention, also when driving on the highway and going under a overpass, they turn on for a brief second until you clear it, so it looks like you are flashing your headlights, I think it’s very unsafe

We were involved in a T-bone type accident at highway speeds. I am filing a complaint because I feel Kia Of America did not pursue potential safety issues with the seatbelts. I called them to inform them of the issue to see if there was any other similar trending reports. they stated that they would send an inspector out which they never did. I believe that the seatbelt failed due to the nature of my injuries and discussion with medical experts. I was sitting behind driver. The accident resulted in a fractured sternum and rib injuries, injuries to both of my shins and injury to my coccyx. Most significant is that there was no seatbelt bruising on my chest. All suggestive of hitting back of front seat.I have pix. Also, upon attempting to exit the vehicle post impact, the seatbelt was fully extended, as I got tangled up in it trying to exit. Also to note the driver’s seatbelt was fully extended also however they were protected by airbag deployment. The front and rear passenger seatbelts were not extended and those passengers had only minor injuries. My wife’s, the driver, injuries were much more serious and has resulted in permanent damage. I contacted Kia of America to report the concern and they assured me they would send an engineer out to provide an inspection. They had multiple months to do this, and I followed up multiple times as to the status of this inspection. During that time the car switched insurance carriers hands however there was ample time to perform the inspection. After a couple months, I followed up again and they informed me that the car was destroyed. I informed them that was not satisfactory and please escalate this. They did and a gentleman called me and left a voicemail. I returned his call 4 times and left voicemails but again no follow up. I feel that this attention to a potentially significant safety issue has been neglected and I ask you to further investigate. I have emails and timelines of conversations documented. Thank you.

There is a loud squeaking sound that sounds like a rodent or bird that occurs intermittently at cold temperatures from the steering column. It has been mentioned in several forums and Facebook communities. Some dealers are aware, others are not. The repair requires a steering column replacement according to those who have had service completed. Dealers are requiring they directly hear the issue despite recorded video proof. I have a copy of my issue in hand.