2025 Kia Sorento Hybrid Electrical Problems

Wireless cell phone charging pad causes phone to overheat. I have tried other vehicles (Ford Explorer) and this had no detrimental effect on cell phone. As well as heating the cell phone (Apple iPhone 16) it also doesn’t charge the phone. I have also tried other cell phones (Apple iPhone 16 and 14) and same issues were presented. The safety issue is the inability to charge the cell phone reliably as well as the very hot condition caused to the cell phone. I purchased this vehicle new in July 2025 and I realized the issue almost immediately. I did let my Kia service department know of this and was told at the time that this is very common and that a recall (repair) would likely be available soon. To be best of my knowledge this hasn’t happened. The only reason I am bringing it up now is that my son in law (the Ford Explorer) mentioned that he utilizes his with no problem. Thank you

NHTSA ID

11748874

Incident

Jul 2, 2025

1. I'm not sure what component or system malfunctioned. The dealership has said something different every time it's had to be taken in. The first time they said it could have been the dip stick. The second time they said they didn't know but did an update to the car's system. Last week, was the third time we've had to take it in and they said they are doing an oil change and replacing the air intake hose assy, GDI fuel pump, High pressure fuel pump, valve cover assy, oil filter and oil but didn't say if this would fix the issue. 2. We have loss confidence in this car's safety and reliability and the dealership's ability to repair it. It's been in the shop multiple times and continues to fail. The issue with the vehicle is that when we got a warning the power to the car shuts off. It doesn't allow you to do anything with the gas pedal no matter what speed you are going. We have experienced this multiple times on city streets and the highway. The potential for an accident is very high when the car does this. 3. We have taken it to the dealership and they don't know what's wrong with it. I created a case with Kia and have not heard back from a case manager at all. 4. The vehicle has only been inspected by the dealership and no one else. They have contacted Kia corporate for solutions via messaging but this is the third time the car has just loss power while we are driving. 5. There were some warning signs like check hybrid batter system on the dashboard. The kia Access app allow shows diagnostic alerts like ADAS_DRV. I have attached some photos and some of the documentation we have. There have been multiple dates but I put the first date that the car broke down. Other dates include (1/28/26 and 2/6/26).

NHTSA ID

11717334

Incident

Jan 16, 2026

Incident #1: Car suddenly and without warning had complete loss of power, with gas engine shutting off and only using battery power. Car was traveling at 45mph in morning traffic. Pedal was pushed to the floor, but car would only go a maximum of 20mph. Warning dash lights then appeared saying "Hybrid Malfunction/Pull Over Immediately/Turn off car". I was able to pull off road and turn off car and then turn back on. Car ran normally the 2 miles back home. Incident #2: 2 days later, while driving my kids to school the car again, suddenly and without warning had complete loss of power, with gas engine shutting off and only using battery power. Again, warning dash lights: "Check Hybrid System. Stop Safely!". I did so and car ran normally back to my house (distance approx: 2.5 miles). I immediately called KIA of Beaverton and they said to have it towed right away. Once at dealer, they were unable to diagnose any issues and said that no codes showed up, but also said that the car "deleted codes". Car was in shop for 2 days and determined "car operates as designed." I picked up the car. Incident #3: 7 days later, with kids in the car, again car had complete power loss with no warning. Warning lights again told of "Check Hybrid System. Stop Safely!" Pulled over (in heavy Friday rush hour traffic) and turned off car. Turned on again, but this time car drove for less than a quarter mile before complete power loss happened again with all warning lights. This time we took video of the car not having power, all the warning lights etc. as evidence. We turned off the car and upon turning it on, it instantly had no power. We pulled car over and had to park it that night at a local business for towing. Car was towed again to Beaverton KIA. Again, dealer said they were not able to replicate problem after driving 250 miles on it. Insisted we pick up car, despite numerous comm's saying how unsafe we felt taking it. Dealer claimed KIA told them to remove .5 Qt of oil.

NHTSA ID

11715726

Incident

Jan 13, 2026

Was driving home from work, and suddenly all the indicator lights came on on the dash, (check engine, warring lights, indicator that the battery was critically low, etc etc.) the car notified me to safely pull off the road. I pulled off the road in limp mode, the engine would not engage when pedal was pressed, and then lost power. I was stuck in the middle of the lane on a side road in park. I turned the car off, then turned it back on and let it idle for a bit thinking it may be the battery (which is new). After several minutes drove it home and have not had any other issues. I researched this issue on the internet and there were reported similar problems exactly like this. Note. I put it on a reader at home and it did not show any codes.

NHTSA ID

11713723

Incident

Jan 26, 2026

Beginning at approximately 750 miles on a brand-new 2025 Kia Sorento Hybrid EX, the vehicle experienced a flashing Check Engine Light accompanied by severe shaking while driving, rough idling, loss of power, and loud engine/exhaust noise. The vehicle became difficult and unsafe to operate due to the vibration and reduced drivability. These symptoms appeared suddenly on November 22, less than three weeks after purchase. The vehicle was taken to the dealership on November 24. Their technician retrieved diagnostic codes P0300 (Random Misfire) and P0304 (Cylinder #4 Misfire) and identified a failed ignition coil on Cylinder #4. The coil was replaced, and the dealership reported the issue resolved. However, less than 24 hours later, with the vehicle still under 800 miles, the exact same symptoms reoccurred: heavy shaking while driving, vibration while idling, loss of power, and unstable engine operation. This indicates the underlying issue may be more serious than a single coil failure. The problem has been reproduced and confirmed by the dealership, and the vehicle is currently back in their possession for further inspection. A loaner vehicle was issued because the vehicle was not safe to drive. The sudden shaking, engine misfire, and loss of power created a significant safety risk, especially if this failure were to occur at highway speeds or while turning across traffic. Given the extremely low mileage and recurrence immediately after repair, this may indicate a broader defect affecting engine performance or ignition components in this model. The vehicle remains available for inspection by NHTSA, the manufacturer, or investigators.

NHTSA ID

11702272

Incident

Nov 22, 2025

Safety Concern – 2025 Kia Sorento Prestige Hybrid (VIN [XXX] ) Around October 13, 2025, my leased 2025 Kia Sorento Prestige Hybrid experienced a sudden and severe loss of power while I was driving on the highway. The vehicle was towed to the dealership, where the High Power Control Unit (HPCU), part number 36601-3DPG3, was replaced. No clear explanation of the root cause was provided. Less than a month later, on November 6, the same failure occurred again—this time in heavy highway traffic—creating a serious safety risk and increasing the chance of a collision. The vehicle is primarily driven by my wife, who regularly uses highways to transport our son. The recurring and unpredictable nature of this issue has made us feel unsafe and anxious. We are deeply concerned that another failure could lead to a serious accident or fatality. We respectfully request that the National Highway Traffic Safety Administration (NHTSA) investigate this matter as a potential safety defect. Without a clear understanding of the cause, we are documenting these incidents to encourage action. It is critical that Kia resolves this issue to protect families and maintain trust in its brand. Thank you INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11698214

Incident

Oct 13, 2025

Driving on highway car would suddenly lose power.it has happened 7 times. 4 times the car told you to get off road pull to sideband leave engine running to have battery recharge.after doing this sometimes it would allow you to continue.not always sometimes would continue to have no power. car has been to 2 dealerships nothing resolved yet. they tell me to wait.

NHTSA ID

11680885

Incident

Apr 16, 2025

The front and rear passenger side windows of my 2025 Kia Sorento intermittently fail to operate. When attempting to roll them down, all that can be heard is a clicking sound, and the windows do not move. This issue occurs randomly and without warning. The malfunction poses a safety concern, as functioning windows are necessary for proper ventilation, emergency egress, and communication with others outside the vehicle, including law enforcement or toll booth operators. The issue was first reported to Kia of Bowie on December 9, 2024. However, the dealership stated they could not recreate the problem and, therefore, could not make repairs, citing that Kia would not reimburse them unless they could verify the defect. I was advised to record a video of the issue should it occur again. The problem has persisted multiple times, but due to being the driver, capturing a video was difficult. I was recently able to record the malfunction, showing both windows failing to operate with only the clicking sound audible. On February 17, 2025, I returned to the dealership with a scheduled appointment to address this issue. After waiting 2.5 hours, I was informed that they again could not recreate the issue and that my video evidence was not considered sufficient for a repair. Despite following the dealership's instructions, no resolution has been provided. Additionally, my Kia Connect system is not functioning properly, and the radio sound intermittently cuts in and out. These electrical issues raise concerns about potential broader system malfunctions that could compromise vehicle safety. No warning lights or error messages have appeared related to these issues. The vehicle remains available for inspection upon request.

NHTSA ID

11643265

Incident

Dec 2, 2024