1998 Kia Sportage Problems

THIS IS A REPEAT OF CONFIRMATION NO. 10514519, BUT WITH "WAS THERE AN INJURY OR FATALITY? MARKED "YES" ABOVE. DRIVER AND PASSENGER SCALDED WITH BOILING RADIATOR FLUID WITH FOOT ON PEDAL, HAD TO KEEP FOOT ON PETAL TO GET OFF ROAD. ON MAY 30, 2013, AT APPROX. 4:30PM EDT, I WAS DRIVING MY 1998 KIA SPORTAGE ON THE GARDEN STATE PARKWAY NORTH, JUST AFTER ENTERING THE HIGHWAY AT EXIT 98 IN WALL, NJ. THE AIR CONDITIONER HAD NOT BEEN WORKING WELL. THE LOCAL TEMPERATURE WAS IN THE HIGH 90S, NEAR 100 DEGREES. I HAD A PASSENGER IN THE FRONT PASSENGER SEAT. SUDDENLY, ANTI-FREEZE SMOKE CAME OUT OF THE DASHBOARD VENTS, THEN, HOT SCALDING ANTI-FREEZE BEGAN FALLING ON MY RIGHT FOOT AS IT WAS ON THE ACCELERATOR PEDAL. AT THE SAME TIME, THE FRONT-SEAT PASSENGER WAS ALSO GETTING SCALDED. IN MY CASE, I SUSTAINED A 1ST TO 2ND DEGREE BURN ON MY RIGHT SMALL (PINKY) TOE, WHICH WAS BLISTERED. IT WAS FORTUNATE THAT I WAS ABLE TO GET OFF AT THE MONMOUTH SERVICE AREA AT MILEPOST 100 OF THE GARDEN STATE PARKWAY IN WALL, NJ. MY VIEW IS THAT THIS IS A SERIOUS SAFETY ISSUE CAUSED BY DESIGN OVERSIGHT, NOT MERELY A MAINTENANCE ISSUE ON A OLD CAR. FOR EXAMPLE, IF A HEATER CORE BREAKS AND DOES NOT HEAT, THAT IS A MAINTENANCE PROBLEM. HOWEVER, IF IT BREAKS AND AN UNEXPECTED DRIVER GETS HURT, AND COMPOUNDED, LOSES CONTROL OF THE VEHICLE, AND MOREOVER, HAS TO PUT HIS FOOT BACK ONTO THE ACCELERATOR PEDAL TO CONTROL THE CAR IN A HOT-LIQUID STREAM, THIS IS AN UNACCEPTABLE SAFETY CONDITION DUE TO FAILURE TO SAFELY CONTAIN HOT LIQUIDS. *TR

DRIVER AND PASSENGER SCALDED WITH BOILING RADIATOR FLUID WITH FOOT ON PEDAL, HAD TO KEEP FOOT ON PETAL TO GET OFF ROAD ON MAY 30, 2013, AT APPROX. 4:30 PM EDT, I WAS DRIVING MY 1998 KIA SPORTAGE ON THE GARDEN STATE PARKWAY NORTH, JUST AFTER ENTERING THE HIGHWAY AT EXIT 98 IN WALL, NJ. THE AIR CONDITIONER HAD NOT BEEN WORKING WELL. THE LOCAL TEMPERATURE WAS IN THE HIGH 90S, NEAR 100 DEGREES. I HAD A PASSENGER IN THE FRONT PASSENGER SEAT. SUDDENLY, ANTI-FREEZE SMOKE CAME OUT OF THE DASHBOARD VENTS, THEN, HOT SCALDING ANTI-FREEZE BEGAN FALLING ON MY RIGHT FOOT AS IT WAS ON THE ACCELERATOR PEDAL. AT THE SAME TIME, THE FRONT-SEAT PASSENGER WAS ALSO GETTING SCALDED. IN MY CASE, I SUSTAINED A 1ST TO 2ND DEGREE BURN ON MY RIGHT SMALL (PINKY) TOE, WHICH WAS BLISTERED. IT WAS FORTUNATE THAT I WAS ABLE TO GET OFF AT THE MONMOUTH SERVICE AREA AT MILEPOST 100 IN WALL, NJ. MY VIEW IS THAT THIS IS A SERIOUS SAFETY ISSUE CAUSED BY DESIGN OVERSIGHT, NOT MERELY A MAINTENANCE ISSUE ON A OLD CAR. FOR EXAMPLE, IF A HEATER CORE BREAKS AND DOES NOT HEAT, THAT IS A MAINTENANCE PROBLEM. HOWEVER, IF IT BREAKS AND AN UNEXPECTED DRIVER GETS HURT, AND COMPOUNDED, LOSES CONTROL OF THE VEHICLE, AND MOREOVER, HAS TO PUT HIS FOOT BACK ONTO THE ACCELERATOR PEDAL TO CONTROL THE CAR IN A HOT-LIQUID STREAM, THIS IS AN UNACCEPTABLE SAFETY CONDITION DUE TO FAILURE TO SAFELY CONTAIN HOT LIQUIDS. *TR

THE ABS ON MY VEHICLE FAILS INTERMITTENTLY. I HAVE TAKEN IT TO THE DEALER. THE DEALER HAS RUN DIAGNOSTICS AND TOLD ME THAT THERE IS NO PROBLEM, DESPITE THE FACT THAT THE ABS LIGHT IS ILLUMINATED. THE DEALER CALLED KIA USA, WHO COULD OFFER NO HELP. BECAUSE THE ABS IS NOT ALWAYS RELIABLE, THE BRAKING CHARACTERISTICS OF THIS VEHICLE ARE VERY UNRELIABLE. ON 2 DECEMBER THE ABS SYSTEM SUDDENLY BECAME OPERATIONAL, CAUSING THE "FEEL" OF THE PEDAL TO CHANGE, STARTLING THE DRIVER, WHO WAS IN THE PROCESS OF BRAKING. THE VEHICLE STRUCK A CURB AND NARROWLY MISSED A TREE. *NM

WHILE DRIVING 20 MPH AND WHEN APPLYING THE BRAKES A THUMPING NOISE WAS HEARD COMING FROM THE PASSENGER SIDE WHEEL.CONSUMER WAS ABLE TO DRIVE THE VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC REPLACED WHEEL BEARING. *AK

1998 KIA SPORTAGE A RECALL ABOUT THE WIRING HAS BEEN REPORTED I [XXX] HAS BEEN SUFFERING FOR TRANSPORTATION DUE TO THIS MALFUNCTION JUST NEED JUSTIFICATION A.S.A.P MY MAILING ADDRESS IS [XXX] MY PH. IS [XXX] ALSO [XXX]. THANK YOU AND HAVE A BLESSED DAY. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 1998 KIA SPORTAGE. THE CONTACT STATED WHILE TRAVELING AT 25 MPH, THE VEHICLE BEGAN TO LOSE POWER. THE HOLD BUTTON ILLUMINATED ON THE DASHBOARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT WHERE AN UNKNOWN REPAIR WAS MADE TO THE VEHICLE. THE FAILURE PERSISTED. THE MECHANIC ADVISED THAT THE FAILURE WAS SIMILAR TO NHTSA CAMPAIGN ID NUMBER: 99V325000 (ELECTRICAL SYSTEM: WIRING) BUT THE CONTACT DID NOT CONFIRM IF HIS VIN WAS INCLUDED IN THE RECALL. THE FAILURE MILEAGE WAS 89,000 AND THE CURRENT MILEAGE WAS 89,835.

VEHICLE HAD FOUR RECALLS AND AIRBAG LIGHT KEPT FLASHING. RECALLS WERE ON BRAKE HOSES, FRONT BUCKLE ASSEMBLY, ELECTRICAL WIRING AND MISSING LABEL. *LA WHILE DRIVING THE VEHICLE AIR BAG LIGHT BEGAN TO FLASH. THE VEHICLE WAS TAKEN TO THE DEALER AND THE TECHNICIAN INDICATED THAT THE AIR BAG MODULE HAD FAILED. WHILE DRIVING THE VEHICLE'S CHECK ENGINE LIGHT ILLUMINATED AND THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TOT HE DEALER WHO INDICATED THAT THE COILS WERE CRACKED. TRANSMISSION LINE WAS LEAKING. *NM

SUNDAY, 11-02-2003, WHILE DRIVING ON MAIN ST IN MESA, ARIZONA, OUR 1998 KIA SPORTAGE'S GEARSHIFT LEVER SNAPPED OFF IN MY HAND. I WAS SHIFTING FROM SECOND TO THIRD GEAR AT THE TIME. THE BREAK WAS ABOUT 1 1/2 INCHES FROM FLOOR LEVEL, DOWN INSIDE THE CONSOL. I WAS LUCKY TO BE ABLE TO COAST ONTO THE MEDIAN WITHOUT CRASHING. MY PREGNANT WIFE AND THREE-YEAR-OLD SON WERE WITH ME IN THE VEHICLE.I CONTACTED KIA AND THE SHORT OF IT IS THAT THE VEHICLE IS OUT OF WARRANTY AND THEY CLAIM THAT THEY DON'T HAVE TO DO ANYTHING ABOUT THIS. I FEEL THAT THIS IS A LIFE-THREATENING DEFECT. KIA SHOULD BE VERY INTERESTED IN FINDING OUT HOW OR WHY A VEHICLE WITH NO HISTORY OF ACCIDENTS COULD HAVE THIS CRITICAL PART BREAK OFF UNEXPECTEDLY! NOT GIVING THE BRUSH-OFF! I HAVE DIGITAL PHOTOS THAT I AM WILLING TO EMAIL.*AK

CONTINUAL FAILURE OF BATTERY , REPLACED 5 TIMES AND REPLACED ALTERNATOR BUT CONTIUES TO HAVE BATTERY FAILURE ALSO WINDOWS AND DOOR LCKS GO ON AND OFF BY THEMSELVES.*AK

DUE TO A DEFECT THE HEATER VENTS BLOW EXTREMELY HOT AIR THAT SMOKE COME THOUGH THE VENTS. PLEASE PROVIDE ADDITIONAL INFORMATION. TS

REAR FRAME RUST/ROT IS INCREDIBLY EXCESSIVE. NOTICED TODAY WHILE CHECKING TIRE PRESSURE. ENTIRE UNDERSIDE OF FRAME IS COMPLETELY RUSTED THROUGH. REAR CROSS MEMBER IN TERRIBLE SHAPE. VISIBLE DETERIORATION HAPPENED QUICKLY. PURCHASING THE CAR IN 2012 THERE WAS NO SIGN OF ROT ON THE FRAME. NOW I FEEL UNCOMFORTABLE DRIVING THE CAR, OR SELLING IT TO SOMEONE ELSE FOR THAT MATTER. AS A MECHANICAL ENGINEER, THE INTEGRITY OF THE SQUARE TUBE FRAME IS COMPROMISED TO THE POINT THAT SAFETY IN A REAR END COLLISION IS IN QUESTION, ANY KIND OF TRAILER LOAD WOULD BE IMPOSSIBLE AND UNSAFE. REALLY A DANGER TO THE GENERAL PUBLIC BECAUSE IT COULD FAIL AT ANY TIME. *TR

DRIVING UPHILL IN ONE INCH OF SNOW THE AXEL HUBS ON THE FRONT OF VEHICLE DID NOT ENGAGE CAUSING THE LOSS OF CONTROL OF THE STEERING, SLIDING SIDEWAYS AND BACKWARDS TO A STOP. THE PARTS REPLACED WERE AS FOLLOWS: AXEL HUB SEALS, AXEL BEARINGS, UPPER BALL JOINT, VACUUM LINE AND REALIGNMENT OF FRONT END.*AK

REAR FRAME RUST/ROT IS INCREDIBLY EXCESSIVE. NOTICED TODAY WHILE CHECKING TIRE PRESSURE. ENTIRE UNDERSIDE OF FRAME IS COMPLETELY RUSTED THROUGH. REAR CROSS MEMBER IN TERRIBLE SHAPE. VISIBLE DETERIORATION HAPPENED QUICKLY. PURCHASING THE CAR IN 2012 THERE WAS NO SIGN OF ROT ON THE FRAME. NOW I FEEL UNCOMFORTABLE DRIVING THE CAR, OR SELLING IT TO SOMEONE ELSE FOR THAT MATTER. AS A MECHANICAL ENGINEER, THE INTEGRITY OF THE SQUARE TUBE FRAME IS COMPROMISED TO THE POINT THAT SAFETY IN A REAR END COLLISION IS IN QUESTION, ANY KIND OF TRAILER LOAD WOULD BE IMPOSSIBLE AND UNSAFE. REALLY A DANGER TO THE GENERAL PUBLIC BECAUSE IT COULD FAIL AT ANY TIME. *TR

EXTREME CORROSION AT REAR OF FRAME WHERE AXLE IS SUPPORTED READY TO COLLAPSE AND WILL REQUIRE REMEDIATION TO PREVENT FRAME FAILURE. *TR

THIS IS A REPEAT OF CONFIRMATION NO. 10514519, BUT WITH "WAS THERE AN INJURY OR FATALITY? MARKED "YES" ABOVE. DRIVER AND PASSENGER SCALDED WITH BOILING RADIATOR FLUID WITH FOOT ON PEDAL, HAD TO KEEP FOOT ON PETAL TO GET OFF ROAD. ON MAY 30, 2013, AT APPROX. 4:30PM EDT, I WAS DRIVING MY 1998 KIA SPORTAGE ON THE GARDEN STATE PARKWAY NORTH, JUST AFTER ENTERING THE HIGHWAY AT EXIT 98 IN WALL, NJ. THE AIR CONDITIONER HAD NOT BEEN WORKING WELL. THE LOCAL TEMPERATURE WAS IN THE HIGH 90S, NEAR 100 DEGREES. I HAD A PASSENGER IN THE FRONT PASSENGER SEAT. SUDDENLY, ANTI-FREEZE SMOKE CAME OUT OF THE DASHBOARD VENTS, THEN, HOT SCALDING ANTI-FREEZE BEGAN FALLING ON MY RIGHT FOOT AS IT WAS ON THE ACCELERATOR PEDAL. AT THE SAME TIME, THE FRONT-SEAT PASSENGER WAS ALSO GETTING SCALDED. IN MY CASE, I SUSTAINED A 1ST TO 2ND DEGREE BURN ON MY RIGHT SMALL (PINKY) TOE, WHICH WAS BLISTERED. IT WAS FORTUNATE THAT I WAS ABLE TO GET OFF AT THE MONMOUTH SERVICE AREA AT MILEPOST 100 OF THE GARDEN STATE PARKWAY IN WALL, NJ. MY VIEW IS THAT THIS IS A SERIOUS SAFETY ISSUE CAUSED BY DESIGN OVERSIGHT, NOT MERELY A MAINTENANCE ISSUE ON A OLD CAR. FOR EXAMPLE, IF A HEATER CORE BREAKS AND DOES NOT HEAT, THAT IS A MAINTENANCE PROBLEM. HOWEVER, IF IT BREAKS AND AN UNEXPECTED DRIVER GETS HURT, AND COMPOUNDED, LOSES CONTROL OF THE VEHICLE, AND MOREOVER, HAS TO PUT HIS FOOT BACK ONTO THE ACCELERATOR PEDAL TO CONTROL THE CAR IN A HOT-LIQUID STREAM, THIS IS AN UNACCEPTABLE SAFETY CONDITION DUE TO FAILURE TO SAFELY CONTAIN HOT LIQUIDS. *TR

DRIVER AND PASSENGER SCALDED WITH BOILING RADIATOR FLUID WITH FOOT ON PEDAL, HAD TO KEEP FOOT ON PETAL TO GET OFF ROAD ON MAY 30, 2013, AT APPROX. 4:30 PM EDT, I WAS DRIVING MY 1998 KIA SPORTAGE ON THE GARDEN STATE PARKWAY NORTH, JUST AFTER ENTERING THE HIGHWAY AT EXIT 98 IN WALL, NJ. THE AIR CONDITIONER HAD NOT BEEN WORKING WELL. THE LOCAL TEMPERATURE WAS IN THE HIGH 90S, NEAR 100 DEGREES. I HAD A PASSENGER IN THE FRONT PASSENGER SEAT. SUDDENLY, ANTI-FREEZE SMOKE CAME OUT OF THE DASHBOARD VENTS, THEN, HOT SCALDING ANTI-FREEZE BEGAN FALLING ON MY RIGHT FOOT AS IT WAS ON THE ACCELERATOR PEDAL. AT THE SAME TIME, THE FRONT-SEAT PASSENGER WAS ALSO GETTING SCALDED. IN MY CASE, I SUSTAINED A 1ST TO 2ND DEGREE BURN ON MY RIGHT SMALL (PINKY) TOE, WHICH WAS BLISTERED. IT WAS FORTUNATE THAT I WAS ABLE TO GET OFF AT THE MONMOUTH SERVICE AREA AT MILEPOST 100 IN WALL, NJ. MY VIEW IS THAT THIS IS A SERIOUS SAFETY ISSUE CAUSED BY DESIGN OVERSIGHT, NOT MERELY A MAINTENANCE ISSUE ON A OLD CAR. FOR EXAMPLE, IF A HEATER CORE BREAKS AND DOES NOT HEAT, THAT IS A MAINTENANCE PROBLEM. HOWEVER, IF IT BREAKS AND AN UNEXPECTED DRIVER GETS HURT, AND COMPOUNDED, LOSES CONTROL OF THE VEHICLE, AND MOREOVER, HAS TO PUT HIS FOOT BACK ONTO THE ACCELERATOR PEDAL TO CONTROL THE CAR IN A HOT-LIQUID STREAM, THIS IS AN UNACCEPTABLE SAFETY CONDITION DUE TO FAILURE TO SAFELY CONTAIN HOT LIQUIDS. *TR

DRIVING UPHILL IN ONE INCH OF SNOW THE AXEL HUBS ON THE FRONT OF VEHICLE DID NOT ENGAGE CAUSING THE LOSS OF CONTROL OF THE STEERING, SLIDING SIDEWAYS AND BACKWARDS TO A STOP. THE PARTS REPLACED WERE AS FOLLOWS: AXEL HUB SEALS, AXEL BEARINGS, UPPER BALL JOINT, VACUUM LINE AND REALIGNMENT OF FRONT END.*AK

THE VEHICLES 4-WHEEL DRIVE ENGAGED SOMETIMES THEN POPPED OUT CAUSING A LOUD NOISE. THE CONSUMER FOUND OUT ABOUT A HUB SEAL RECALL AND INQUIRED ABOUT IT AT THE DEALER . THE DEALER INDICATED THAT THE RECALL WAS PERFORMED BY THE MANUFACTURER. THE CONSUMER LOOKED UNDER THE HOOD FOR A RED MARK ON THE VACUUM CANISTER BRACKET BUT DIDN'T SEE ONE. THE CONSUMER THEREFORE BELIEVES THAT THE RECALL HAS NOT BEEN COMPLETED. *AK *NM

CONSUMER HAS A CONCERN THAT THE SPEEDOMETER NEEDLE WOULD NOT REGISTER THE PROPER SPEED. THE NEEDLE WOULD MOVE BACK AND FORTH WHILE DRIVING. PLEASE PROVIDE ANY FURTHER INFORMATION. *JP

AFTER PUTTING VEHICLE INTO PARK AND THEN PUTTING UP HAND BRAKE VEHICLE STARTED TO ACCELERATE, AND RAN THROUGH GARAGE INTO THE BASEMENT.*AK

DT*: THE CONTACT STATED WHILE DRIVING ON THE FREEWAY AT 65 MPH. THE PASSENGER REAR TIRE BLEW OUT. THE TIRE DEALERSHIP DETERMINED THE TIRE FAILED DUE TO TREAD SEPARATION. THE TIRE MANUFACTURER IS KUMHO. THE SIZE OF THE TIRE IS: 20575R15. *AK UPDATED 05/03/06

THE 4WD SYSTEM ON THE 98 KIA SPORTAGE IS UNRELIABLE. THE VACUUM SYSTEM, WHICH ACTUATES THE FRONT HUBS DOES NOT WORK. I HAVE HAD THE VEHICLE IN FOR THIS PROBLEM EVERY WINTER SINCE I PURCHASED THE VEHICLE IN 1998. THE DEALERS REPAIR LASTS A WEEK OR SO AND THEN FAILS. UNEXPECTED LACK OF 4WD IS A SAFETY ISSUE. *JB

1998 KIA SPORTAGE- TAIL GATE CABLE IS FREEZING UP, CALLED KIA WHICH HAS A RECALL ON THIS PART BUT NO ON MY VIN. HAVING A PROBLEM OPENING TAIL GATE. *LA

CONTINUAL FAILURE OF BATTERY , REPLACED 5 TIMES AND REPLACED ALTERNATOR BUT CONTIUES TO HAVE BATTERY FAILURE ALSO WINDOWS AND DOOR LCKS GO ON AND OFF BY THEMSELVES.*AK

PROBLEMS WITH HORN, STEERING WHEEL AND AIR CONDITIONER ON 1998 KIA SPORTAGE.*MR THE VEHICLE DASH LIGHTS ALSO FAILED INTERMITTENTLY. *NM

OXYGEN SENSOR HAS BEEN REPLACED THREE TIMES AFTER ROUTINE SERVICE WAS PERFORMED.*AK CONSUMER ALSO STATED THE WIPERS WERE NOT CLEARING WINDSHIELD, WINDOWS GO UP SLOWLY, 4-WHEEL DRIVE WAS INOPERATIVE,VEHICLE WAS LOOSING POWER STEERING, DEALER REPLACED THE FAN BELT,AIR CONDITION WAS INOPERATIVE,WHEEL BEARING WERE LOOSE,WEATHERSTRIP WAS REPLACED,THE ENGINE BOGGS DOWN WHILE DRIVING, FRONT BRAKES WERE NOISY.*SLC

THIS IS A REPEAT OF CONFIRMATION NO. 10514519, BUT WITH "WAS THERE AN INJURY OR FATALITY? MARKED "YES" ABOVE. DRIVER AND PASSENGER SCALDED WITH BOILING RADIATOR FLUID WITH FOOT ON PEDAL, HAD TO KEEP FOOT ON PETAL TO GET OFF ROAD. ON MAY 30, 2013, AT APPROX. 4:30PM EDT, I WAS DRIVING MY 1998 KIA SPORTAGE ON THE GARDEN STATE PARKWAY NORTH, JUST AFTER ENTERING THE HIGHWAY AT EXIT 98 IN WALL, NJ. THE AIR CONDITIONER HAD NOT BEEN WORKING WELL. THE LOCAL TEMPERATURE WAS IN THE HIGH 90S, NEAR 100 DEGREES. I HAD A PASSENGER IN THE FRONT PASSENGER SEAT. SUDDENLY, ANTI-FREEZE SMOKE CAME OUT OF THE DASHBOARD VENTS, THEN, HOT SCALDING ANTI-FREEZE BEGAN FALLING ON MY RIGHT FOOT AS IT WAS ON THE ACCELERATOR PEDAL. AT THE SAME TIME, THE FRONT-SEAT PASSENGER WAS ALSO GETTING SCALDED. IN MY CASE, I SUSTAINED A 1ST TO 2ND DEGREE BURN ON MY RIGHT SMALL (PINKY) TOE, WHICH WAS BLISTERED. IT WAS FORTUNATE THAT I WAS ABLE TO GET OFF AT THE MONMOUTH SERVICE AREA AT MILEPOST 100 OF THE GARDEN STATE PARKWAY IN WALL, NJ. MY VIEW IS THAT THIS IS A SERIOUS SAFETY ISSUE CAUSED BY DESIGN OVERSIGHT, NOT MERELY A MAINTENANCE ISSUE ON A OLD CAR. FOR EXAMPLE, IF A HEATER CORE BREAKS AND DOES NOT HEAT, THAT IS A MAINTENANCE PROBLEM. HOWEVER, IF IT BREAKS AND AN UNEXPECTED DRIVER GETS HURT, AND COMPOUNDED, LOSES CONTROL OF THE VEHICLE, AND MOREOVER, HAS TO PUT HIS FOOT BACK ONTO THE ACCELERATOR PEDAL TO CONTROL THE CAR IN A HOT-LIQUID STREAM, THIS IS AN UNACCEPTABLE SAFETY CONDITION DUE TO FAILURE TO SAFELY CONTAIN HOT LIQUIDS. *TR

DRIVER AND PASSENGER SCALDED WITH BOILING RADIATOR FLUID WITH FOOT ON PEDAL, HAD TO KEEP FOOT ON PETAL TO GET OFF ROAD ON MAY 30, 2013, AT APPROX. 4:30 PM EDT, I WAS DRIVING MY 1998 KIA SPORTAGE ON THE GARDEN STATE PARKWAY NORTH, JUST AFTER ENTERING THE HIGHWAY AT EXIT 98 IN WALL, NJ. THE AIR CONDITIONER HAD NOT BEEN WORKING WELL. THE LOCAL TEMPERATURE WAS IN THE HIGH 90S, NEAR 100 DEGREES. I HAD A PASSENGER IN THE FRONT PASSENGER SEAT. SUDDENLY, ANTI-FREEZE SMOKE CAME OUT OF THE DASHBOARD VENTS, THEN, HOT SCALDING ANTI-FREEZE BEGAN FALLING ON MY RIGHT FOOT AS IT WAS ON THE ACCELERATOR PEDAL. AT THE SAME TIME, THE FRONT-SEAT PASSENGER WAS ALSO GETTING SCALDED. IN MY CASE, I SUSTAINED A 1ST TO 2ND DEGREE BURN ON MY RIGHT SMALL (PINKY) TOE, WHICH WAS BLISTERED. IT WAS FORTUNATE THAT I WAS ABLE TO GET OFF AT THE MONMOUTH SERVICE AREA AT MILEPOST 100 IN WALL, NJ. MY VIEW IS THAT THIS IS A SERIOUS SAFETY ISSUE CAUSED BY DESIGN OVERSIGHT, NOT MERELY A MAINTENANCE ISSUE ON A OLD CAR. FOR EXAMPLE, IF A HEATER CORE BREAKS AND DOES NOT HEAT, THAT IS A MAINTENANCE PROBLEM. HOWEVER, IF IT BREAKS AND AN UNEXPECTED DRIVER GETS HURT, AND COMPOUNDED, LOSES CONTROL OF THE VEHICLE, AND MOREOVER, HAS TO PUT HIS FOOT BACK ONTO THE ACCELERATOR PEDAL TO CONTROL THE CAR IN A HOT-LIQUID STREAM, THIS IS AN UNACCEPTABLE SAFETY CONDITION DUE TO FAILURE TO SAFELY CONTAIN HOT LIQUIDS. *TR

AIR BAG LIGHT ILLUMINATED. DIAGNOSTICS REVEALED AIRBAG CONTROL MODULE FAILURE.*AK

VEHICLE HAD FOUR RECALLS AND AIRBAG LIGHT KEPT FLASHING. RECALLS WERE ON BRAKE HOSES, FRONT BUCKLE ASSEMBLY, ELECTRICAL WIRING AND MISSING LABEL. *LA WHILE DRIVING THE VEHICLE AIR BAG LIGHT BEGAN TO FLASH. THE VEHICLE WAS TAKEN TO THE DEALER AND THE TECHNICIAN INDICATED THAT THE AIR BAG MODULE HAD FAILED. WHILE DRIVING THE VEHICLE'S CHECK ENGINE LIGHT ILLUMINATED AND THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TOT HE DEALER WHO INDICATED THAT THE COILS WERE CRACKED. TRANSMISSION LINE WAS LEAKING. *NM

I CANNOT FASTEN MY SEATBELT BECAUSE IT WILL NOT EXTEND. I WENT TO POWER KIA IN SALEM, OR AND THEY WILL NOT REPAIR IT UNLESS I PAY FOR REPAIRS. SEEING HOW THIS IS A PRODUCT DEFECT CAUSING A SAFETY ISSUE, I FEEL THE MANUFACTURE SHOULD BE RESPONSIBLE FOR THIS, ESPECIALLY BECAUSE IT IS THE LAW TO FASTEN THE SEAT BELTS. PLEASE LET ME KNOW WHAT TO DO. *TR

WHILE TRAVELING AND WITHOUT PRIOR WARNING A DEER APPEARED IN THE STREET. TO AVOID HIM, CONSUMER SWERVED AND HIT AN ENBANKMENT. UPON IMPACT, AIR BAGS FAILED TO DEPLOY. *AK CONSUMERS SEAT BELT POPPED CAUSING CONSUMER TO LURCH FORWARD AND AND HIT HER HEAD. CONSUMER SUSTAINED MULTIPLE INJURIES. *JG

THE VEHICLE CHECK ENGINE LIGHT IS CONSTANTLY ON, VEHICLE HAS BEEN TO DEALER SEVERAL OCCASIONS, TO HAVE VARIOUS PARTS REPAIRED AND REPLACED, VEHICLE BEGAN SMOKING FROM THE ENGINE COMPARTMENT, DEALER HAS TRIED ALL TYPES OF REMEDIES BUT PROBLEM STILL EXISTS.*JB

WHEEL ASSEMBLY BECOMES "LOOSE" AND REQUIRES ROUTINE TIGHTENING BY DEALER. LOOSE WHEEL CAUSES SAFETY HAZARD & POTENTIAL FOR LOSS OF CONTROL AS WELL AS NEEDLESS DAMAGE TO REMAINING HUB ASSEMBLY AND DRIVE TRAIN COMPONENTS TOTALING AS MUCH AS $3,500 PER INCIDENT TO REPAIR.*AK

RECALL 99V325000 CONCERNING STALLING. VEHICLE WAS EXPERIENCING AN ELECTRICAL PROBLEM THAT INTERFERED WITH PERFORMANCE. VEHICLE WAS RECALLED AND REPAIRS DONE, BUT SYMPTOMS RETURNED. MANUFACTURER CLAIMED NO RESPONSIBILITY BECAUSE CONSUMER WAS NOT THE ORIGINAL OWNER. *AK CHECK ENGINE LIGHT WAS ON. THE VEHICLE VIBRATED, SMOKED AND WAS OVERHEATING. THE LEFT FRONT TIRE BLEW OUT. IGNITION COILS CRACKED AND WERE REPLACED. VEHICLE HAD A BLOWN HEAD GASKET. FRONT LEFT TURN SIGNAL CLIPS BROKE. OXYGEN SENSOR FAILED. RIGHT FRONT DOOR LOCK FELL OFF. VEHICLE HAD SEVERAL PARTS ON RECALL BEFORE THE CONSUMER PURCHASED IT AND THE CONSUMER BELIEVED THOSE RECALLED PARTS WERE THE SOURCE OF THE PROBLEM. *YH

CONDENSATION IN LEFT HEADLIGHT- THEY CLEANED OUT VENT HOLE- SAME PROBLEM ON1/1/98 , HOWEVER LIGHT WAS REPLACED THEN. *AK