2013 KTM 690 Duke Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2013 KTM 690 Duke, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Fuel system375.0%
- Driver assistance125.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
WHILE RIDING THE MOTORCYCLE TO COMMUTE TO WORK ON CITY STREETS, I COULD SMELL GASOLINE. WHEN STOPPED AT A REDLIGHT, I LOOKED AT THE TOP OF THE TANK AND GAS WAS COMING OUT OF THE TOP OF THE TANK FROM AROUND THE CAP MOUNT/SEAL IS BOLTED TO THE TANK. THIS TANK IS A REPLACEMENT THAT KTM PUT ON ABOUT A YEAR AGO AFTER HAVING THIS SAME ISSUE BEFORE. I KNOW KTM PUT OUT A RECALL ON LATER MODELS, 2015 AND LATER I THINK, THAT WERE HAVING THE SAME PROBLEM, BUT I DON'T BELIEVE MY REPLACEMENT TANK FROM KTM IS ONE OF THE CORRECTED TANKS. NOW, I'M ON MY 2ND TANK WITH THE SAME PROBLEM OF GASOLINE COMING FROM THE TOP OF IT AND SPILLING ONTO THE MOTOR. ANY HELP IS GREATLY APPRECIATED.. *TT
THE FUEL TANK LEAKS FROM THE GAS CAP. ALSO, THIS IS NOT MY FIRST KTM, WHICH HAS HAD A LEAKING GAS CAP. IT'S MY 3RD ONE. THIS ISSUE IS VERY WELL-DOCUMENTED ON THE FORUMS AS WELL AS ON YOUTUBE. GASOLINE POURS RIGHT OUT OF THE GAS CAP ESPECIALLY WHEN IT IS FULL OR WHEN ACCELERATING OR DECELERATING BRISKLY. I AM FAIRLY CERTAIN THIS IS AN ISSUE TO DO WITH THE HIGH ETHANOL CONTENT PRESENT IN ALL U.S. GAS. THE STANDARD FUEL IS E10, WHICH MEANS 90% GASOLINE AND 10% ETHANOL. THERE HAS ALREADY BEEN A CLASS ACTION LAWSUIT AGAINST DUCATI IN THE PAST FOR THIS ISSUE ALTHOUGH IT HAS CROPPED WITH OTHER MANUFACTURERS. THE ISSUE ARISES FROM A REACTION WITH ETHANOL IN PLASTIC TANKS. IT IS NOT AN ISSUE WITH METAL TANKS. MOST MANUFACTURERS HAVE FIXED THE ISSUE OR STOPPED USING THE PLASTIC. HOWEVER, KTM REMAINS A MAJOR PROBLEM AS SEEN ABOVE. EVEN THE NEWEST 2016 AND 2017 MODELS HAVE THE SAME ISSUES, WHICH ARE AGAIN DOCUMENTED IN THE FORUMS. IT IS UNACCEPTABLE AND DANGEROUS. *TT *JS
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
THE MOTORCYCLE STALLS VERY OFTEN MOST PROMINENTLY WHEN BRAKING AGGRESSIVELY AND PULLING IN THE CLUTCH TO STOP. THE BIKE WILL ALSO SOMETIMES STALL RANDOMLY WHEN OPERATING AT ENGINE SPEEDS BELOW 3,000 RPM. THE THROTTLE RESPONSE IS ALSO EXTREMELY JERKY BELOW 4,000 RPM LIKE AN ON/OFF SWITCH MAKING THE MOTORCYCLE NEARLY IMPOSSIBLE TO RIDE. I HAD THE EXACT SAME ISSUE WITH 2008 KTM 690 SMC AND IN NEARLY A DECADE, THE ISSUE HAS NOT BEEN FIXED. UNACCEPTABLE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .