Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 7 NHTSA owner-reported complaints for the 2017 KTM 690 Duke. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–7 of 7
FUEL TANKS WARP AROUND FUEL FILLER NECK AND CAUSE FUEL TO LEAK OVER HOT ENGINE. HAD RECALL DONE AT DEALER TO REPLACE FUEL-FILLER NECK GASKET UNDER RECALL, WHICH WORSENED LEAK. KTM THEN PROVIDED A WHOLE REPLACEMENT FUEL TANK, WHICH CONTINUES TO LEAK. BIKE HAS BEEN SITTING FOR OVER A YEAR NOW - KTM HAS NOT RELEASED A PROPER SOLUTION TO FIX THIS ISSUE THAT MOST 2016+ KTM 690 DUKE OWNERS HAVE BEEN CONSTANTLY DEALING WITH.
The contact owns a 2017 KTM 690 Duke Orange Motorcycle. The contact stated that while the motorcycle was parked there was an abnormal odor of fuel detected. The contact noticed fuel leaking. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was 4,161.
PLASTIC FUEL TANK DEFORMS AND LEAKS
THE PLASTIC GAS TANK HAS WARPED CAUSING LEAKS BOTH ON THE BOTTOM OF THE TANK WHERE THE FUEL PUMP ATTACHES AND ON THE TOP OF THE TANK WHERE THE FILLER NECK IS ATTACHED. THE LEAK FROM THE FUEL PUMP AREA OCCURS BOTH WHEN THE BIKE IS RIDDEN AND STATIONARY, THE LEAK FROM THE FILLER AREA OCCURS WHEN THE BIKE IS RIDDEN AND GAS SLOSHES TO THE TOP OF THE TANK.
PLASTIC GAS TANK WARPS AND FUEL LEAKS
TL* THE CONTACT OWNS A 2017 KTM 690 DUKE. THE CONTACT STATED THAT THERE WAS A FUEL LEAK ON THE MOTORCYCLE THAT TRAVELED TO THE MOTOR. THE CONTACT SPOKE WITH SCOTT POWERSPORTS, INC. (1675 PA-309, COOPERSBURG, PA 18036, 610-282-4800) AND WAS INFORMED OF NHTSA CAMPAIGN NUMBER: 17V388000 (FUEL SYSTEM, GASOLINE); HOWEVER, THE RECALL DID NOT APPLY TO THE BOTTOM PORTION OF THE FUEL TANK, ONLY THE TOP PORTION. THE MOTORCYCLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 5,300.
FUEL TANK LEAKS FUEL AT THE FUEL FILLER NECK, BETWEEN THE TANK AND THE GAS TANK CAP, PAST THE GASKET. THE TOP OF THE TANK (PLASTIC) IS WARPED, AND THE GASKET DOES NOT SEAL. FUEL LEAKS DOWN ONTO ENGINE POTENTIALLY CREATING A FIRE THAT WOULD CONSUME THE BIKE, THE RIDER AND ANY OBJECTS AROUND IT.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Data on this page last refreshed .