2022 Kzrv Durango Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2022 Kzrv Durango, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure266.7%
- Suspension133.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
I have a 2022 KZ Durango 321RKT. The frame has been flexing up in the front by the bedroom slide out. There is now a crack in the bedroom wall, which expands from when it’s on the truck to when it’s on the landing gear on the ground. It also is causing the outside of the RV to buckle in the same place. KZand Lippert both said that there’s nothing that they can do. There’s no frame flex in my camper and that they fixed it before my camper was built and they also said that it’s three years old. It’s out of warranty. Warranty and frame should not be in the same sentence together that is the main component of the camper. There is also another issue with the frame on these campers where the leaf spring hangers are breaking off from the frames because they are not braced properly. I have included both pictures of the frame flex crack, and the suspension hanger breaking.
The contact owns a 2022 KZRV Durango. The contact stated that one side of the awning fabric had detached, causing the awning to unintendedly drop. The contact stated that five people assisted in roping the awning back into place. The RV was taken to the dealer; however, the RV was not diagnosed or repaired. The manufacturer was made aware of the failure but provided no assistance. The contact related the failure to NHTSA Campaign Number: 22V552000 (Structure) however, the VIN was not included in the recall. The failure mileage was unknown.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
I have a 2022 KZ Durango 321RKT. The frame has been flexing up in the front by the bedroom slide out. There is now a crack in the bedroom wall, which expands from when it’s on the truck to when it’s on the landing gear on the ground. It also is causing the outside of the RV to buckle in the same place. KZand Lippert both said that there’s nothing that they can do. There’s no frame flex in my camper and that they fixed it before my camper was built and they also said that it’s three years old. It’s out of warranty. Warranty and frame should not be in the same sentence together that is the main component of the camper. There is also another issue with the frame on these campers where the leaf spring hangers are breaking off from the frames because they are not braced properly. I have included both pictures of the frame flex crack, and the suspension hanger breaking.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .