Owner-reported complaints naming the body or structure system, filed with NHTSA
Data refreshed
Reports naming the vehicle structure, frame, body panels, doors, hood and trim. Every record below is an owner-reported complaint about the 2004 Lexus GX submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 9 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
Rusted out frame, missing entire sections of it in the rear end, body mounts are floating, Lexus inspected the car at 144,000~ miles and deemed it unsafe to drive, was owned by a friend of mine and now it is up for sale at morse road auto sales inc in columbus ohio.
2004 Lexus GX470 factory-installed Blizzard White paint is peeling off in sheets. Was told by certified body shop that there is a clear defect with the primer. The areas affected are the hood, roof, and near back windows - no impact or other damage is present. This is unsafe as it will lead to the corrosion of the body of the car. There was a recall for the 2008-2009 models with this paint color, but this needs to be extended to the 2004 model year as well. There were no warning messages and the car is available for inspection.
Vehicle maintained per manual. Frame rusted thru in numerous places, viable holes obvious. Vehicle deemed unsafe from Pep Body service personnel. Attached a frame picture from passenger side.
VEHICLE MAINTAINED PER MANUAL. FRAME RUSTED THRU IN NUMEROUS PLACES, VIABLE HOLES OBVIOUS. VEHICLE DEEMED UNSAFE UPON INSPECTION. LEXUS HDQTRS IN PLANO, TX AND PARSIPPANY NJ REFUSED ANY RESPONSIBILITY FOR LOSS OF VEHICLE. I MAILED A PACKAGE OF CORRESPONDENCE AND PHOTOGRAPHS TO YOUR ADDRESS VIA CERTIFIED MAIL OCT 7,2020, RETURN RECEIPT NOT REC'D. FRUSTRATED WITH LACK OF RESPONSE.. TOYOTA REPLACED OR REPURCHASED TRUCK W/SAME FRAME, LEXUS REFUSED RECEIVED CASE # 11362013, YOURAGENCY.
DICSCOVERED DURING MINOR REPAIR,FRAME OF VEHICLE IS COMPLETELY DETERIORATED DUE TO RUST T.FRAME PERFORATED IN NUMEROUS PLACES. RATED UNFIT TO DRIVE ,LEXUS DENIES ANY RESPONSIBILITY. VEHICLE IS IN NEED OF COMPLETE FRAME REPLACEMENT . VEHICLE AVAILABLE FOR INSPECTION. RUST APPEARS AT BOX FRAME AND WELDS THE CONSUMER STATED THE MANUFACTURER WAS CONTACTED AND DID NOT OFFER ANY ASSISTANCE DUE TO THE VEHICLE BEING OUT OF WARRANTY. *JS
2004 LEXUS GX 470. HAS FRAME ROT DUE TO THE CONDINSATION HOSE RELEASED ON TOP OF THE PASSANGER SIDE FRAME. IT RUNS DOWN THE PASSANGER SIDE FRAME AND PUT HOLES IN IT DUE TO INPROPER PLACEMENT. NOW THE PASSANGER SIDE DOOR IS SLIGHLY OUT OF ALIGNMENT WHEN CLOSED. I HAVE HAD TO WRAPP STEEL AROUND THE FRAME. FROM FRONT DOOR TO FRONT OF BACK WHEEL. CONTACTED LEXUS AT 1800-255-3987 IN PLANO TEXAS FOR CASE NUMBER [XXX]. THEN SAID ONLY A MINOR WARRANTY FOR CORRESION AND IT IS NOT COVERED. ALSO THE PERSON ON THE PHONE REFUSED TO GIVE ME TOYOTA HEADQUARTERS MAILING ADDRESS. THIS RUST IS ON TOP OF THE FRAME AND I BELIEVE WOULD TAKE 10-15 YEARS TO SHOW UP. THERE IS NOW MANY HOLES IN ONLY THE PASSANGER SIDE FRAME. HERE ARE PICTURES PICTURE 6100 SHOWS THE HOSE OVER THE FRAME. IS IT POSSIABLE THE CAR COULD BRAKE WHEN DRIVING. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TT
THE PAINT ON THE PLASTIC FENDERS, BUMPERS, AND THE METAL ROOF HAS BEEN FADING FOR THE PAST SEVERAL YEARS. THE FADING STARTED WHEN THE VEHICLE WAS ABOUT 1-2 YEARS OLD, EVEN WHEN THE VEHICLE WAS PARKED IN A GARAGE OVERNIGHT. THE VEHICLE WAS PURCHASED IN VA AND HAS BEEN USED IN CA SINCE 2006. WE HAVE ABOUT 110,000 MILES ON THE VEHICLE. WE HAVE SEEN SIMILAR MAKE/MODEL LEXUS GX 470S THAT APPEAR TO HAVE THE SAME FADED PAINT IN THE SAME ARES ON THE VEHICLE AS OURS. IN ADDITION, THE PAINT APPEARS TO BE DETERIORATING AND DISAPPEARING FROM THE ROOF AND ON THE EDGES OF THE DOORS. THIS COULD LEAD TO RUST PROBLEMS. OUR EFFORTS TO ADDRESS THIS WITH THE LEXUS DEALERS HAVE NOT MET WITH SUCCESS; THE DEALERS MORE OR LESS DISMISSED OUR COMPLAINT. OUR BODY SHOP MECHANIC TOLD US HE BELIEVES THE PAINT IS DEFECTIVE.
THE DASH IS CRACKING ALL OVER THE PLACE(BETWEEN 20-30 PACES). THE MOST CRACKING HAS OCCURRED IN FRONT OF AND AROUND THE PASSENGERS AIRBAG. THIS IS PARTICULARLY CONCERNING BECAUSE I FEAR IT THE AIRBAG NEEDED TO DEPLOY, IT WOULD NOT PROPERLY DO SO, AND ALSO THAT IT MAY BE EXTRA DANGEROUS IF THE CRACKED PIECES OF THE DASH GO FLYING IN ALL DIRECTIONS UPON AIRBAG DEPLOYMENT. THERE ARE THOUSANDS OF SUCH CONDITIONS REPORTED THROUGHOUT THE US HERE: HTTP://WWW.CLUBLEXUS.COM/FORUMS/GX-FIRST-GENERATION/427349-CRACKED-DASHBOARD.HTML IT DOESN'T SEEM TO MATTER IF THE VEHICLE WAS GARAGE KEPT, OR PARKED IN THE SUN. ALSO CLIMATE TEMPERATURE DOESN'T SEEM TO BE A FACTOR. THIS CONDITION IS BEING REPORTS ALL OVER THE US. *TR
THE DASHBOARD ON MY 2004 LEXUS GX 470 STARTED TO SHOW A FEW CRACKS BACK IN 2011. IT HAS PROGRESSIVELY GOTTEN WORSE. THE VEHICLE IS ALWAYS GARAGE-STORED. THIS APPEARS TO BE A REAL PROBLEM THAT LEXUS REFUSES TO TAKE RESPONSIBILITY FOR. *TR
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Data on this page last refreshed .