2022 Lincoln Corsair PHEV Electrical Problems

I was driving down the highway at around 70 mph, with one passenger. There had been no indications that anything was wrong with the vehicle. Then I noticed the car slowing down though I had not let up on the gas, which I now understand is called 'limp mode'. The screen said 'service vehicle soon'. It kept slowing down while I carefully pulled to the side of the road. Thankfully I had been in the right lane. This was not a very safe place to be, relatively close to an overpass. I turned off the car and let it rest for a few minutes. Then I started it and tried the gas. It did speed up to about 35 mph, so I kept going to try and get past the area of high traffic and little shoulder. Once I got past the overpass, I pulled over again. I stopped, let it rest and then started up again. Still it only went up to about 35 mph, but I was able to get to an exit and pull into a parking lot. I then called a tow truck and eventually they took the car to the closest Lincoln dealership. After reviewing the car, the dealership's service center said they did not see anything wrong with the vehicle and could not reproduce the issue. They did say that records showed a similar incident had happened in May 2025, under a different owner. They suggested I take the vehicle home and come back if it happened again. Then on July 12th, I was driving down I75 again, this time in the left lane and with my son in the car, and the same thing happened. The car started slowing down and the screen said 'service vehicle soon'. I was able to pull off at the next exit and let the car rest. We happened to be only 1.6 miles from the Lincoln dealership, so I carefully drove the car there and left it since they were closed. They later said that the service bulletin suggested that if they could drive the car 4 times without an issue, they could clear the issue. I looked further into it and found that there is an open recall on the vehicle, with no remedy, Open Safety Recall 25SC4. I do NOT feel safe.

NHTSA ID

11751963

Incident

May 14, 2026

On the morning of [XXX], I lost power while driving. The dashboard remained lit, however, I had no ability to restart the car. The car was towed to the nearest dealership. Lincoln has opened case # [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11661063

Incident

May 9, 2025

The contact owns a 2022 Lincoln Corsair. The contact received notification of NHTSA Campaign Number: 24V954000 (Electrical System); however, the part to do the recall repair was unavailable. The local dealer was contacted and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11660452

Incident

May 12, 2025

The contact owns a 2022 Lincoln Corsair. The contact received notification of NHTSA Campaign Number: 24V954000 (Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11659270

Incident

Dec 5, 2024

The contact owns a 2022 Lincoln Corsair. The contact received notification of NHTSA Campaign Number: 24V954000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11657471

Incident

Jan 31, 2025

The contact owns a 2022 Lincoln Corsair. The contact received notification of NHTSA Campaign Number: 24V954000(Electrical System); however, the part to do the repair was not yet available. No further information was available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11654072

Incident

Apr 11, 2025

The contact owns a 2022 Lincoln Corsair. The contact received notification of NHTSA Campaign Number: 24V954000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11650525

Incident

Mar 25, 2025

The contact owns a 2022 Lincoln Corsair. The contact received notification of NHTSA Campaign Number: 24V954000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that while driving at approximately 73 MPH, the vehicle independently decelerated to approximately 60 MPH. No warning light was illuminated. The contact stated that the vehicle had approximately 15 miles of hybrid battery; however, the vehicle independently switched to the fuel. The vehicle was taken to a local dealer where it was diagnosed that the transmission oil pump had independently switched to Safe Mode and needed to be replaced. The vehicle was repaired under warranty. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 11,000. VIN tool confirms parts not available.

NHTSA ID

11637978

Incident

Nov 15, 2024

Mileage

11,000 mi

I was driving to work via the [XXX] in California when at approximately 6:40am I felt a jerking motion in my 2022 Lincoln Corsair Grand Touring (PHEv) and then immediately began receiving various warning lights and chimes indicating an issue. The vehicle was losing power and I was safely able to exit the freeway and pull to the side of the road. There were numerous warning indicators activated, including Service Engine Soon, Hill Start Assist failure, Pre-Collision Assist failure, EV Battery not available, and others. I exited the vehicle to ensure that there was not any visible physical damage, and did not find anything. I checked the Owners Manual for the warnings and it indicated that if the vehicle was able to be driven, it could but with caution. I proceeded to drive to work, approximately 4.7 miles away. The vehicle could not be driven over 35 MPH without violently shaking, along with a mechanical grinding noise. Drive Control was also not active and the vehicle felt like it had no suspension. Estimated repair time was approximately 1 week per the Lincoln Concierge (LC), and no root problem had been identified at the time. On Monday, 10/28 I followed up via text to the LC for an update and was informed that they checked with the Transmission technician and they had started to “tear down the transmission to find the fault.” On 10/30, I asked for another update and to inform the LC that I had a preplanned vacation to Big Bear, CA on 11/7/24 and hoped to have it back before then. On 10/31, the LC informed me that the Tech had “ordered a new transmission today and should be here by Tuesday [11/5/24].” On 11/5, I followed up via text to the LC and was informed that the new arrival date for the transmission would be 11/6 or 11/7. Because I did not have my Corsair and wanted to be cautious of the miles on the loaner, we took an alternate vehicle for the road trip. See PDF attached for additional details. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11637810

Incident

Oct 22, 2024

Electrical connector and wiring harness melted due to close proximity to the right rear exhaust pipe. Experiencing intermittent parking brake fault messages that results in a check engine light, when climbing a grade longer then 1 mile long. Suspect extra heat produced from engine load had damaged some of the internal wires of the connector. This first occurred with 2000 miles on the odometer, 2 months old. Lincoln started producing these GT model Corsairs with a heat shield missing (that was part of 2021 and some 2022 models) that probably would have protected this wiring harness. Not sure what circuits are running through this connector, but their are a lot of wires in it. The connector is melted enough that it probably cannot be unplugged anymore. There is melted plastic residue on the exhaust pipe from the connector. Dealer has confirmed the melted connecter and zip tied the connector further away from the exhaust pipe as a temporary fix till they can investigate further.

NHTSA ID

11553328

Incident

Dec 23, 2022

Electrical System. Yes. While driving in traffic both on surface streets and the freeway the power in my vehicle stopped. The vehicle went from Drive to Park on its own. The battery light came on. The Start/Stop light went from solid green to blinking green. Vehicles around me had to stop suddenly to avoid a collision and the wait until I could restart the vehicle. This has happened a few times. No. No.

NHTSA ID

11512303

Incident

Mar 9, 2023