2021 Lincoln Corsair

While driving on the highway my vehicle experienced a sudden severe loss of power that led you a metallic rattling noise under the front of the vehicle and smoke coming out the exhaust pipes. Took it to a Ford dealership for diagnosis and repair however, it recommendations were long engine block replacement due to coolant intrusion from a cylinder wall cracking due to a manufacturer defect that is a widely known and has a large class action lawsuit. Well, I’m being told I have to pay $11,000 out-of-pocket because my vin is not included in the active recalls of the vehicles of the same making and model as mine. The issues with my vehicle is not caused from wear and tear is a manufacturer defect and should be included to be repaired being that this vehicle is less than five years old under 100,000 miles and I’ve only had the vehicle since November 2024.

NHTSA ID

11745510

Incident

Jun 9, 2026

Transmission locked up while driving with no warning.

NHTSA ID

11745117

Incident

Jun 17, 2026

One day, the bright headlamps stopped working. The light on the dashboard indicating that they are on still works but the lights themselves, do not turn on. Yes, it is available for inspection. There was and has been no warning. It has not been looked at by a dealer or anyone else.

NHTSA ID

11741560

Incident

Jan 6, 2026

The contact owns a 2021 Lincoln Corsair. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 25V048000 (Back Over Prevention); however, the failure occurred after the recall repair. The contact stated that while reversing, the rear view camera failed to alert her when there was a pedestrian or vehicle. The vehicle was taken back to the dealer on three separate occasions. The dealer replaced the rear view camera, but the failure persisted. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 40,216.

NHTSA ID

11736965

Incident

Apr 13, 2026

Mileage

40,216 mi

For most of 2025 and now into April 2026, I have been unable to use my car’s electric capabilities. This is due to active recalls for which no permanent repair is available. Temporary fixes have not resolved these issues. Thus, for an extended period of time, a primary feature of my car, a feature for which I purchased this vehicle, has been unavailable to me. I want to be clear: •The defect involves a major advertised and purchased function of the vehicle (plug-in hybrid operation); •The condition has persisted for a year; •Neither Lincoln nor the dealership have provided a reliable repair or accurate timeline for resolution; •Interim measures have failed to restore functionality.

NHTSA ID

11732248

Incident

Oct 16, 2025

I received the recall notice, dated August 2025, regarding the rear camera on my 2021 Lincoln Corsair. To date, the vehicle has not been repaired. I have received no notice from Lincoln or from any Lincoln dealer regarding the parts for this issue. This is unacceptable. Please advise. Thank you for your assistance.

NHTSA ID

11730902

Incident

Apr 13, 2026

The contact owns a 2021 Lincoln Corsair. The contact received notification of NHTSA Campaign Number: 25V048000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

NHTSA ID

11712341

Incident

Jan 21, 2026

The contact owns a 2021 Lincoln Corsair. The contact stated that while reversing, the rear-view camera displayed a blurry image. The contact stated that the failure made it very difficult to reverse while driving at night. The contact received a recall notification NHTSA Campaign Number: 25V048000 (Back Over Prevention). The dealer was made aware of the failure, however the contact was informed that the parts to do the recall repair were not available. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and referred the contact to the dealer. The failure mileage was approximately 8.

NHTSA ID

11707452

Incident

Dec 15, 2021

Mileage

8 mi

This bulletin supersedes 26-2194. Reason for update: update the Parts list to correct a part description " Loctite 638", update the claim quantity for the drain/fill plug, update the claim quantity of the wheel hub bolts (Corsair) and limited the parts list for Edge/Nautilus to only the rear drive unit fluid. Some of the vehicles listed in the Model statement above may exhibit all of the following conditions:  Shudder chatter condition, most noticeable at low speeds turning  No relevant diagnostic trouble codes (DTCs) present This may be due to internal rear drive unit (RDU) fluid contamination.

Some 2020-2026 Corsair/Escape, 2021-2026 Bronco Sport, and 2022-2026 Maverick vehicles equipped with an 8F35 transmission may exhibit a shudder condition, most noticeable at speeds below 60 mph (100 km/h), with no relevant diagnostic trouble codes (DTC) stored in the powertrain control module (PCM). Sometimes, this may be perceived/felt as an engine misfire. This may be due to the torque converter. If Pinpoint Test K: Torque Converter Clutch Operation in Workshop Manual (WSM), Section 307-01 > Diagnosis and Testing > Diagnosis by Symptom directs to replace the torque converter, remove and replace the torque converter and torque converter seal. Refer to WSM, Section 307-01 > Removal and Installation > Torque Converter Seal. Remove the main control valve body. Refer to WSM, Section 307-01 > Removal and Installation > Main Control Valve Body. Overhaul and thoroughly clean the main control valve body. Refer to WSM, Section 307-01 > Overhaul > Main Control Valve Body. Reverse the removal procedure to reassemble the transmission. Install the transmission. Refer to WSM, Section 307-01 > Installation. For claim

Customer Satisfaction Program 26N09 Certain 2020 Model Year Escape, 2020-2021 Corsair, 2020-2021 Aviator, and 2020- 2021 and 2023 Explorer Vehicles Front Windshield Wiper Motor Replacement, if Required After Dealer Evaluation

This bulletin supersedes 25-2346. Reason for update: add Bronco Sport and Escape vehicles and add labor operations to repair the rear right/left carpet area. Some of the vehicles listed in the Model statement above may exhibit a condition where the carpet is loose or torn near the front/rear scuff plate trim panel. This may be due to the carpet tearing at or near the retainer hole.

Certain 2021-2024 Model Year Bronco, 2021-2024 Model Year Bronco Sport, 2020-2022 Model Year Corsair and Escape, 2016-2024 Model Year Explorer, 2019-2020 Model Year Fusion, 2016-2018 Model Year Focus RS, 2022-2024 Model Year Maverick, 2016-2019 Model Year MKC and 2019-2024 Model Year Ranger Vehicles Equipped with a 2.0L or 2.3L Engine and Engine Block Heater System Block Heater Replacement

Some 2020-2026 Corsair/Escape, 2021-2026 Bronco Sport, and 2022-2026 Maverick vehicles equipped with an 8F35 transmission may exhibit a shudder condition, most noticeable at speeds below 60 mph (100 km/h), with no relevant diagnostic trouble codes (DTC) stored in the powertrain control module (PCM). Sometimes, this may be perceived/felt as an engine misfire. This may be due to the torque converter. If Pinpoint Test K: Torque Converter Clutch Operation in Workshop Manual (WSM), Section 307-01 > Diagnosis and Testing > Diagnosis by Symptom directs to replace the torque converter, remove and replace the torque converter and torque converter seal. Refer to WSM, Section 307-01 > Removal and Installation > Torque Converter Seal. Remove the main control valve body. Refer to WSM, Section 307-01 > Removal and Installation > Main Control Valve Body. Overhaul and thoroughly clean the main control valve body. Refer to WSM, Section 307-01 > Overhaul > Main Control Valve Body. Reverse the removal procedure to reassemble the transmission. Install the transmission. Refer to WSM, Section 307-01 > Installation.