2025 Lincoln Corsair

The contact owns a 2025 Lincoln Corsair. The contact stated that the turn signal noise was faint and could barely be heard by the driver. The contact stated that this failure could be a hazard to other drivers as the turn signal could be left on and the driver would not have any indication that the turn signal remained on. The vehicle was taken to the dealer and was informed that there was no remedy for the failure. The manufacturer was also notified of the failure and the representative acknowledged that the turn signal matter was a common issue reported to them from other owners. The contact was informed that there was a shift in how the digital audio was processed which caused the change in sound. The contact was again informed that there was no fix for the defect. The vehicle was not repaired. The failure mileage was 5.

NHTSA ID

11741273

Incident

Nov 1, 2025

Mileage

5 mi

The contact owns a 2025 Lincoln Corsair. The contact received notification of NHTSA Campaign Number: 26V122000 (Engine and Engine Cooling); however, the part for the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not informed. The contact had not experienced a failure.

NHTSA ID

11726636

Incident

Mar 5, 2025

The contact owns a 2025 Lincoln Corsair. The contact stated that while driving at an undisclosed speed, the battery system became inoperable. The contact stated that the vehicle displayed inaccurate battery capacity information. The contact received notification of NHTSA Campaign Number: 26V091000 (Electrical System); however, the part for the recall repair was not yet available. The dealer was contacted. The vehicle was not diagnosed or repaired. The dealer confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The approximate failure mileage was 5,700.

NHTSA ID

11721546

Incident

Mar 2, 2026

Mileage

5,700 mi

My 2025 consair notification app alerted me about my hybrid battery, on Jan 24, 2026 at 3:32pm. These are the list of information reported: Electrical system fault detected. Your vehicle may shut down without further warning." "What Is Happening? The powertrain control system has detected a fault in the high voltage battery charging system. What Should I Do? Have your vehicle checked by an authorized dealer as soon as possible."What Is Happening? Illuminates when the system has detected a powertrain or a four-wheel drive fault." "What Should I Do? A Powertrain or All Wheel Drive (AWD)/Four Wheel Drive (4WD) fault has been detected, contact your authorized dealer as soon as possible. These alerts are extremely concerning, as they indicate a potential safety risk and the possibility of sudden vehicle shutdown While i was on the highway driving. This situation has caused significant stress and inconvenience, as I am now uncertain whether the vehicle is safe to drive or be plug up in my garage. I expect this matter to be taken seriously for my safety. Nick Mayers on Mayfield rd, Ohio told me to bring it in ASAP. They called me the next day to let me know that my hybrid battery was over heating. I only charged that battery one time since i bought it. Nick Mayers will be fixing it within a week.Dealer has to order the part. I have a loaner until, they fix my car.

NHTSA ID

11713762

Incident

Jan 24, 2026

I am filing this complaint regarding a safety-related windshield defect on my 2025 Lincoln Corsair Grand Touring. My vehicle is included in Lincoln/Ford recall 25C60 (NHTSA 25V730), which involves windshields manufactured with air bubbles in the laminate layer that can impair visibility and violate FMVSS 205 – Glazing Materials. Although my windshield does not show the “large air bubbles” described in the recall, it has a different but significant defect: visible distortion when sunlight hits the glass. This distortion creates a warped, uneven visual field that interferes with my ability to see clearly through the windshield during normal daytime driving and is a distraction. The problem is consistent and repeatable under direct sunlight. The dealership inspected the vehicle but refused to replace the windshield because it does not match the exact bubble-related condition described in the recall. However, FMVSS 205 prohibits any glazing defect that impairs driver visibility, not only bubbles. The distortion I am experiencing clearly affects visibility and therefore presents a safety concern under the same federal standard cited in the recall. Based on the recall description and the nature of my defect, it appears possible that my windshield was produced using the same manufacturing process or materials that led to the recalled windshields. My issue may represent an additional manifestation of the same underlying defect. I am requesting that NHTSA review this issue as a potential related safety defect and consider whether the recall population should be expanded to include windshields exhibiting distortion rather than only those with visible bubbles. I can provide photos or video demonstrating the distortion in sunlight.

NHTSA ID

11710784

Incident

Nov 3, 2025

The audible on the turn signal is very quiet and hard to hear. The dealership inspected this and confirmed it was very low. The dealership compared it against another Corsair and noted that was also low. I checked with another user of the same 20025 Corsiar. She had the same problem. I feel that this low audible signal will cause accidents. This occurred since I first leased the car.

NHTSA ID

11700526

Incident

Nov 18, 2025

2025 Corsair had a transmission failure with 1900 miles. Extremely hard shifting and near stall conditions until it failed completely.

NHTSA ID

11699526

Incident

Oct 31, 2025

Some 2021-2026 Ford/Lincoln vehicles may exhibit various symptoms including but not limited to the auto start/stop system not operating as intended with a "Check Charging System" message in the instrument panel cluster (IPC) while the charging system is operating properly with no charging related diagnostic trouble codes (DTC) stored. This may be due to someone using an aftermarket programmer to change the body control module (BCM) configuration to disable the auto start/stop system or perform other unsupported programming modifications. To correct this condition on F-150 and Bronco vehicles, download and run the Ford Diagnosis and Repair System (FDRS) application titled "BCM-Charging System Configuration Correction". Running this application will determine if the BCM configuration was modified by the customer and if so, provide the option to return the configuration back to factory settings. For other vehicle models exhibiting concerns related to unsupported aftermarket BCM programming, submit a Technical Support Request (TSR) requesting support to revert the BCM configuration

Some of the vehicles listed in the model statement above equipped with SYNC4 may experience a blank center display screen or black center display after welcome animation. The rear-view camera will still function when shifting the vehicle to reverse under these conditions.

Some 2020-2026 Corsair/Escape, 2021-2026 Bronco Sport, and 2022-2026 Maverick vehicles equipped with an 8F35 transmission may exhibit a shudder condition, most noticeable at speeds below 60 mph (100 km/h), with no relevant diagnostic trouble codes (DTC) stored in the powertrain control module (PCM). Sometimes, this may be perceived/felt as an engine misfire. This may be due to the torque converter. If Pinpoint Test K: Torque Converter Clutch Operation in Workshop Manual (WSM), Section 307-01 > Diagnosis and Testing > Diagnosis by Symptom directs to replace the torque converter, remove and replace the torque converter and torque converter seal. Refer to WSM, Section 307-01 > Removal and Installation > Torque Converter Seal. Remove the main control valve body. Refer to WSM, Section 307-01 > Removal and Installation > Main Control Valve Body. Overhaul and thoroughly clean the main control valve body. Refer to WSM, Section 307-01 > Overhaul > Main Control Valve Body. Reverse the removal procedure to reassemble the transmission. Install the transmission. Refer to WSM, Section 307-01 > Installation. For claim

Some of the following vehicles: 2025-2026 Mustang Mach-E vehicles built on or before 27-Jan-2026 2025-2026 Maverick/Bronco Sport vehicles built on or before 20-Jan-2026 2024-2026 Nautilus vehicles built on or before 02-Dec-2025 2023-2026 Escape/Corsair may exhibit reduced steering assist and a "Power Steering Assist Fault" message displayed in the instrument panel cluster (IPC) with the diagnostic trouble code (DTC) U2016:47 only, and no other steering DTCs stored in the power steering control module (PSCM). To correct this condition, reprogram the PSCM using the latest software level of the Ford Diagnosis and Repair System (FDRS). For claiming, use causal part 3C529 and labor operations 3504E and PSCM. If a software update is not available for the PSCM, the PSCM is already at the latest software level. Refer to Workshop Manual (WSM), Section 211-02 for normal diagnostics. If the vehicle does not exhibit any observable symptoms described above and the DTC is only present in continuous memory, this DTC should be ignored. No further service action

Certain 2023-2025 Model Year Escape and Corsair, 2024-2025 Model Year Nautilus, 2025-2026 Model Year Bronco Sport and 2025 Model Year Maverick Vehicles Equipped with an Engine Block Heater System Block Heater Replacement

Some of the vehicles listed in the Model statement above may exhibit all of the following conditions: * Engine misfire condition * Illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTC) P0301, P0302, P0303, and/or P0304 stored in the powertrain control module (PCM)