2012 Lincoln Mks

The contact owns a 2012 Lincoln MKS. The contact stated that while driving 40 MPH, there was an abnormal fuel odor coming from the vehicle. The contact pulled over the right side of the road and exited the vehicle and became aware of a leak underneath the vehicle. No warning light was illuminated. The vehicle was not taken to a dealer or an independent mechanic to be diagnosed. The vehicle was not repaired. The contact associated the failure with NHTSA Campaign Number: 13V109000 (FUEL SYSTEM, GASOLINE); however, the VIN was not included in the recall. The vehicle was repaired. The manufacturer was not notified of the failure The approximate failure mileage was 130,000.

NHTSA ID

11755941

Incident

Aug 8, 2026

Mileage

130,000 mi

This is additional information related to my prior complaint 1167880 regarding the 2012 Lincoln MKS steering issue.

NHTSA ID

11679596

Incident

Jul 20, 2025

I’ve owned my 2012 Lincoln MKS for 3 years. A warning recently appeared saying “Power Steering Assist Fault,” and now the steering is very hard to turn, especially at low speeds. I’ve already paid around $1,800 in the past to fix this issue once, but now I’m experiencing the same or similar problems again. I haven’t had it officially diagnosed this time because both Ford and the dealer told me it wouldn’t be covered, since the recall (15S18) is now expired. This is a serious safety issue. The car is difficult to control and unsafe to drive. I’m a full-time worker and a father of two toddlers, and I’m still making payments on this car that I now can’t safely use — or only for short trips while constantly worrying about steering failure. I just found out about this old recall, and the dealership never told me anything about it when I bought the car used. I strongly believe I’m experiencing the same issue Ford previously recalled these vehicles for, and I’m asking NHTSA to investigate or reopen the recall so it can be repaired before me or my family is seriously injured.

NHTSA ID

11678807

Incident

Jul 24, 2025

After starting the vehicle on Thursday 6/26/2025, the Power Steering Assist Fault message appeared in the message center. The owner's manual was consulted and as recommended, the engine was turned off for over 10 seconds, turned back on, and the message returned. The Power Steering Assist Fault message has appeared each time upon starting the engine (both by remote and push-button) for 8 days and counting. In September of 2015, the recall associated with a fault in the electric power steering system (number 15S18) was completed at the dealership. The recommended maintenance scheduled has been followed since the vehicle was purchased in January 2012.

NHTSA ID

11671050

Incident

Jun 26, 2025

The contact owns a 2012 Lincoln MKS. The contact stated while attempting to drive out of a parking space, the message "Power Assist Failure" was displayed, and the vehicle lost power steering functionality. The vehicle was towed to an independent mechanic, where it was determined that the Power Steering Control Module (PSCM) needed to be reprogrammed, and the steering rack needed to be replaced. The mechanic related the failure to Ford Campaign Number: 15N01. The vehicle was then taken to the dealer, where the same assessment was made. The dealer ordered the part for the repair; however, the manufacturer's warranty department denied the claim for the repair after several attempts. The vehicle was not repaired. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 158,000.

NHTSA ID

11618842

Incident

Aug 25, 2024

Mileage

158,000 mi

Power Steering Assist Failure

NHTSA ID

11609153

Incident

Jul 11, 2024

The contact owns a 2012 Lincoln MKS. The contact stated while driving 30 MPH, the vehicle jerked and lost power steering functionality. There was no warning light illuminated. The contact stated that after several minutes the vehicle regained power steering functionality. The vehicle was taken to the dealer and the dealer stated that the lower control arms and bushing needed to be replaced. The vehicle was also taken to an independent mechanic and the mechanic stated that the lower control arms and bushing did not need to be replaced. The vehicle was not repaired. The manufacturer was contacted, and the manufacturer stated that the VIN was not included in NHTSA Campaign Number: 15V340000 (Steering) and referred the contact to the NHTSA to file a complaint. The failure mileage was 104,000.

NHTSA ID

11514419

Incident

Mar 8, 2023

Mileage

104,000 mi

I heard on the news that there is a recall on the brake hose and I am always putting brake fluid in i just put some in 03/27/2023 but when I put my vin # in nothing comes up for a recall I have a 2012 lincoln mks awd

NHTSA ID

11514029

Incident

Mar 27, 2023

While performing a transmission repair on some 2012-2024 Ford and Lincoln vehicles, a transmission seal kit may be on backorder due to supply chain interruptions. While performing a transmission repair on some 2012-2024 Ford and Lincoln vehicles, a transmission seal kit may be on backorder due to supply chain interruptions.

For 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to cause errors and is not recommended. It is also not recommended to order a replacement module using a vehicle identification number (VIN) from a different vehicle. Most modules on these affected vehicles are VIN/vehicle specific and hardware variations between modules do exist. Swapping a module from a vehicle or ordering a module using a different vehicle/VIN can cause ineffective repairs and additional vehicle down time. Make sure all appropriate Workshop Manual (WSM) procedures are followed when diagnosing the condition prior to all module replacements and only order modules using the correct VIN.

Some 2009-2020 Ford and Lincoln vehicles equipped with turbochargers may exhibit an oil leak from the turbocharger oil supply or return tubes, O-rings or 6.7L pedestal gasket. Although oil may collect on the turbocharger, it is very rare for a turbocharger to leak oil. To isolate the source of the leak, refer to Workshop Manual (WSM), Section 303-00 General Information > Diagnosis and Testing > Engine > Engine Oil Leaks - Fluorescent Oil Additive Method procedure. When an oil leak is present at a turbocharger oil supply or drain tube, remove the affected oil tube and inspect for damage, and replace the O-ring seals, pedestal gasket or oil tube as required. Refer to WSM, Section 303-04. For claiming, use the affected oil tube or pedestal gasket as the causal part and applicable labor operations in Sections 6 and 9 of the Service Labor Time Standards (SLTS) Manual.

Some 2010-2020 vehicles may exhibit distorted glass with a subtle orange peel pattern or streaking etched into the surface. This is caused by hydrofluoric acid which is used in some car wash solutions as a cleaning agent. Hydrofluoric acid can attack the glass and cause visual distortion and/or discoloration on the outer surface which cannot be removed by further cleaning. If this type of distortion is found, inspect the area of the glass that is covered by the cowl and/or molding. The portion of glass that is covered by the cowl or molding will not be affected by the acid. Hydrofluoric acid damage is not a defect in material or workmanship and is not a warrantable condition.

For Ford and Lincoln vehicles that require positive or negative battery terminal replacement, it is not necessary to replace the complete battery cable harness (14300 and 14301) for this concern. Positive battery cable clamp BT4Z-14450-AA and negative battery cable clamp BT4Z-14450-BA are available for this type of repair. Do not cut or shorten the battery cable, instead carefully remove the affected battery cable clamp and clean the cable end as necessary to preserve wire length. Some rework may be necessary for some vehicle environments. Bend the new positive battery cable clamp as needed and crimp it to the existing battery cable. Make sure to use heat shrink tubing over the battery cable to battery cable clamp connection. Obtain the heat shrink tube locally.

On vehicles equipped with an automatic transmission it is imperative that the converter pilot hub be greased with Motorcraft Multi-Purpose Grease Spray XL-5-A even if grease was not applied from the factory. Also verify that the engine/transmission alignment dowel pins are present as well as the engine crankshaft dowel pin, if equipped, when installing the transmission. Failure to adequately lubricate the converter hub greatly increases the likelihood of the flexplate cracking in the future. Missing dowels may cause a misalignment issue also resulting in a premature failure. Refer to Workshop Manual (WSM), Section 307-01.