1997 Lincoln Town Car Owner Complaints

This has happened to me 3 times in the past 3 months. While driving interstate highway at night and traveling 65 to 70 miles per hr., without any warning or symptoms, the headlights turn off. They then turn on and off a few times and then seem to correct themselves and stay on. This happens on trips after 1 hour or more. Has never occurred on shorter trips under 1 hour. Very dangerous and scary when it is so dark you can't see to pull over off the highway and also worried about vehicles approaching from behind not being able to see you in time. I replaced the headlight switch last week thinking that was the problem, but it happened again last night on my trip back from N.Y.

NHTSA ID

11487465

Incident

Sep 2, 2022

The contact owns a 1997 Lincoln Town Car. The contact stated while driving at 40 MPH, another vehicle crashed into the front passenger side of the vehicle. The vehicle that crashed into the contact was driving at approximately 55 MPH. The air bags failed to deploy. There were no injuries reported. The vehicle was not diagnosed or repaired. A dealer was not contacted. The contact had a second accident, and the air bags did not deploy during that incident. The dealer stated that the air bags could not be replaced because the vehicle was an older model, and the VIN was not under a recall. The manufacturer was not notified of the failure. The failure mileage was 154,000.

NHTSA ID

11472824

Incident

Aug 7, 2015

Mileage

154,000 mi

TL* THE CONTACT OWNS A 1997 LINCOLN TOWN CAR. WHILE DRIVING APPROXIMATELY 60 MPH, THE STEERING ABILITY BECAME LOOSE AND THE CONTACT LOST CONTROL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DETERMINED THAT THE STEERING COLUMN FAILED AND NEEDED REPLACEMENT. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 300,000.

NHTSA ID

11209325

Incident

May 11, 2019

Mileage

300,000 mi

TL* THE CONTACT OWNS A 1997 LINCOLN TOWN CAR. THE CONTACT STATED THAT WHILE THE DRIVER WAS DRIVING AT 30 MPH, STEAM EMITTED FROM THE FRONT END OF THE VEHICLE WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE CONTACTS RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED HOWEVER, THE CONTACT STATED THAT AN AFTER MARKET INTAKE MANIFOLD WAS REPLACED BY AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.

NHTSA ID

10864179

Incident

Jun 15, 2013

Mileage

100,000 mi

TL* THE CONTACT OWNS A 1997 LINCOLN TOWN CAR. THE CONTACT STATED THAT WHILE DRIVING AT 25 MPH, THE VEHICLE STALLED AS THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS RESTARTED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE INTAKE MANIFOLD NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED BY THE DEALER HOWEVER, THE CONTACT STATED THAT HE REPAIRED THE VEHICLE INDEPENDENTLY WITH AFTERMARKET PARTS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 80,000.

NHTSA ID

10864176

Incident

Jul 13, 2013

Mileage

80,000 mi

BRAKE LIGHTS WOULD NOT WORK. BULBS OK. REPLACING THE TURN SIGNAL SWITCH FIXED PROBLEM.

NHTSA ID

10817189

Incident

Aug 25, 2014

Mileage

220,000 mi

TL* THE CONTACT OWNS A 1997 LINCOLN TOWN CAR. THE CONTACT STATED THAT WHEN THE BRAKE PEDAL WAS APPLIED, IT TRAVELED TO THE FLOORBOARD. THE CONTACT NOTICED THAT THERE WAS PREMATURE RUST AND CORROSION ON THE BRAKE LINES CAUSING THEM TO FRACTURE. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 98I001000 (SERVICE BRAKES, HYDRAULIC). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 44,000. UPDATED 12/10/15*LJ *CN

NHTSA ID

10763468

Incident

Sep 12, 2015

Mileage

44,000 mi

TL* THE CONTACT OWNS A 1997 LINCOLN TOWN CAR. THE CONTACT STATED THAT WHILE TRAVELING AN UNKNOWN RATE OF SPEED, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT STATED THAT UPON FURTHER INSPECTION OF THE VEHICLE, IT WAS NOTICED THAT THE PLASTIC PIECE ASSOCIATED WITH THE INTAKE MANIFOLD FRACTURED. ALSO, THE CONTACT MENTIONED THAT THE TEMPERATURE READER AND ADDITIONAL COMPONENTS MAY HAVE BEEN DAMAGED DUE TO THE FAILURE. THE VEHICLE WAS TOWED TO THE CONTACTS RESIDENCE AND WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 10V638000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 98,000.

NHTSA ID

10678294

Incident

Jan 21, 2015

Mileage

98,000 mi

MY 1997 LINCOLN TOWN CAR SIGNATURE SERIES CAUGHT FIRE WHILE PARKED IN THE GARAGE. THE CAR HAD NOT BEEN DRIVEN FOR APPROXIMATELY 48 HOURS PRIOR TO THE FIRE. ABOUT 02:00 HRS ON THE MORNING OF THE 29TH DECEMBER 2014 I WAS WAKENED BY A LOUD POPPING SOUND. WHEN I INVESTIGATED I FOUND MY GARAGE TOTALLY ENGULFED BY FIRE. IT TOOK THE FIRE DEPARTMENT OVER TWO HOURS TO EXTINGUISH THE FIRE; FOR IT HAD SPREAD TO THE OTHER VEHICLE PARKED IN THE GARAGE - 2013 JEEP MOAB AND TO ALL OF THE TOOLS AND MATERIALS STORED IN THE GARAGE. THE FIRE MARSHALL AND THE ARSON INVESTIGATOR STATED THAT THE IGNITION POINT FOR THE FIRE WAS UNDER THE HOOD IN THE LINCOLN, ON THE DRIVERS SIDE AND CLOSE TO THE FIRE WALL. IT RESULTED IN THE TOTAL LOSS OF BOTH CARS, THE GARAGE STRUCTURE AND ALL CONTENTS OF SAID STRUCTURE. *TR

NHTSA ID

10669915

Incident

Dec 29, 2014

Mileage

189,000 mi

BALL JOINT SEPARATED FROM CONTROL ARM CAUSING CONTROL ARM TO DROP TO THE GROUND. THE SAME AS YOUR RECALL98V322000 BUT CALLING LINCOLN THEY SAID THAT MY CAR WAS NOT PART OF THE RECALL. EVEN THOUGH IT DID EXACTLY WHAT THE RECALL SAID. *TR

NHTSA ID

10626547

Incident

Aug 15, 2014

Mileage

113,000 mi

I WAS TRAVELING AT 9:30 PM WHEN THE HEADLIGHTS WENT OUT FOR ABOUT 45 SECONDS AND THEN CAME BACK ON. TRAVELED ABOUT A MILE, WHEN THEY WENT OUT AGAIN, CAN ON, THEN STARTED RAPIDLY FLASHING. I PULLED OVER AND IT ABOUT A MINUTE BEFORE THEY RETURNED TO NORMAL. THIS HAPPENED THREE TIMES THAT NIGHT BEFORE I ARRIVED HOME. THESE HEADLIGHT PROBLEM HAS HAPPENED FIVE TIMES SINCE THE FIRST OCCURRENCE. I RARELY DRIVE AT NIGHT. ..UPDATED 06/26/14 *BF

NHTSA ID

10605275

Incident

Jul 18, 2013

Mileage

57,400 mi

TL* THE CONTACT OWNS A 1997 LINCOLN TOWN CAR. THE CONTACT STATED THAT BRAKE FLUID WAS LEAKING FROM THE VEHICLE IN ADDITION TO THE BRAKE PEDAL FEELING ABNORMALLY LOOSE. THE CONTACT LATER INSPECTED THE VEHICLE AND DISCOVERED THAT THE BRAKE LINE WAS RUSTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.

NHTSA ID

10572865

Incident

Mar 17, 2014

Mileage

90,000 mi

BEGINNING ON A COLD MORNING THE STEERING FELT OFF, LIKE IT NEEDED MORE EFFORT TO TURN AT TIMES. THE STEERING ALSO FAILED TO RETURN TO CENTER ON ITS OWN, INDICATING A POSSIBLE SEIZED UP UNIVERSAL JOINT IN THE STEERING SHAFT. I REMOVED THE STEERING SHAFT AND FOUND THE UNIVERSAL JOINT SEIZED AND VERY DIFFICULT TO MOVE WHICH CAUSED MY DIFFICULT STEERING. THERE IS A RECALL FOR THIS SAME ISSUE ON NEWER TOWN CARS, WHY DOES THIS NOT COVER MINE? *TR

NHTSA ID

10561486

Incident

Jan 23, 2014

Mileage

145,000 mi

TL* THE CONTACT OWNS A 1997 LINCOLN TOWN CAR. THE CONTACT STATED THAT WHILE AT A DEALER FOR ROUTINE MAINTENANCE, THE TECHNICIAN STATED THAT ENGINE COOLANT WAS LEAKING FROM THE INTAKE MANIFOLD. THE TECHNICIAN STATED THAT THE INTAKE MANIFOLD WOULD HAVE TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 88,000.

NHTSA ID

10548448

Incident

Apr 15, 2013

Mileage

88,000 mi

TL* THE CONTACT OWNS A 1997 LINCOLN TOWN CAR. THE CONTACT STATED THAT WHILE AT A DEALER FOR ROUTINE MAINTENANCE, THE TECHNICIAN STATED THAT ENGINE COOLANT WAS LEAKING FROM THE INTAKE MANIFOLD, WHICH WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 102,000.

NHTSA ID

10548446

Incident

Apr 15, 2013

Mileage

102,000 mi

TL* THE CONTACT OWNS A 1997 LINCOLN TOWN CAR. THE CONTACT STATED THAT THE HORN AND CRUISE CONTROL WERE INOPERATIVE. A LOCAL MECHANIC DIAGNOSED THAT THE HORN WOULD NEED TO BE REPLACED. NEITHER THE DEALER NOR THE MANUFACTURER WERE NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 58,000 AND THE CURRENT MILEAGE WAS 60,000.

NHTSA ID

10445472

Incident

Jan 1, 2011

Mileage

58,000 mi

SON WAS OPERATING THE VEHICLE. AS HE MADE A LEFT TURN, HE HEARD A LOUD CLUNKING SOUND AND THE RIGHT SIDE OF THE VEHICLE CRASHED TO THE GROUND. HAD THE CAR TOWED HOME AND SUBSEQUENTLY TOWED TO THE REPAIR SHOP THE NEXT DAY. WAS TOLD THAT THE LOWER RIGHT BALL JOINT HAD FAILED, SUBSEQUENTLY SNAPPING THE STABILIZER LINK. THIS HAPPENED IN AUGUST 2010. NOVEMBER 15, 2011, I WAS DRIVING HOME. STOPPED TO AIR UP MY RIGHT REAR TIRE. UPON RE-ENTERING THE VEHICLE AND BACKING OUT, THE RIGHT FRONT SIDE FELL TO THE GROUND. AGAIN, THE RIGHT FRONT LOWER BALL JOINT FAILED. THIS TIME, I HAD TO ALSO REPLACE THE RIGHT FRONT LOWER CONTROL ARM, RIGHT FRONT STABILIZER LINK, RIGHT FRONT SHOCK AND RIGHT FRONT BALL JOINT. THERE IS A SERIOUS PROBLEM WITH THE 1997 LINCOLN TOWNCAR'S FRONT END. WHEN THE MECHANIC WENT TO INSTALL THE RIGHT LOWER BALL JOINT (WHICH IS A PRESSED FIT) THE BALL JOINT WENT RIGHT IN BY HAND, WHICH INDICATED THAT THE RIGHT FRONT LOWER CONTROL ARM WAS FAULTY. I NOW HAVE A RATTLING SOUND COMING FROM THE LEFT FRONT SIDE. I'M REALLY SCARED TO DRIVE THIS CAR. *KB

NHTSA ID

10441917

Incident

Aug 9, 2010

Mileage

90,000 mi

THE OIL PAN RUSTED THROUGH AND CAUSED ALL THE OIL TO LEAK OUT ONTO THE GROUND. THE CRUISE CONTROL COMPUTER KEEPS CAUSING THE CAR TO TAKE OFF OR NOT EVEN WORK AT ALL WHEN U SET IT, WHEN THE CAR TAKES OFF AFTER SETTING IT THE GAS PEDDLE GOES ALL THE WAY TO THE FLOOR AND IT WILL NOT DEACTIVATE UNLESS YOU SHUT THE CAR OFF WHILE DRIVING. *TR

NHTSA ID

10440817

Incident

Sep 21, 2011

THE CAR WAS SITTING IN THE DRIVEWAY UNATTENDED WITH NO KEY IN THE IGNITION WHEN THE FIRE STARTED. IT HAD BEEN DRIVEN ABOUT 3 HOURS BEFORE WITH NO PROBLEMS. THE FIRE INSPECTOR SAID THE FIRE STARTED UNDER THE HOOD ON THE LEFT SIDE BUT HE WAS UNABLE TO SAY EXACTLY WHAT CAUSED THE FIRE. AFTER CHECKING ON LINE IT WAS DISCOVERED THE CAR WAS ON A RECALL LIST FOR THE SPEED CONTROL SWITCH WHICH IS LOCATED ON THE LEFT SIDE.

NHTSA ID

10422108

Incident

Aug 23, 2011

Mileage

139,000 mi

TL* THE CONTACT OWNS A 1997 LINCOLN TOWN CAR. WHILE DRIVING APPROXIMATELY 20 MPH, THE ENGINE BEGAN TO MISFIRE. THE CHECK ENGINE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL UNTIL THE ENGINE WAS TURNED OFF. THE FAILURE RECURRED WHENEVER THE VEHICLE WAS IN OPERATION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY INFORMED THAT THE ENGINE MANIFOLD WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED. ALSO, ON A SEPARATE OCCASION THE FRONT LOWER CONTROL ARM FRACTURED AND COLLAPSED ONTO THE FRONT DRIVER SIDE WHEEL. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 137,000.

NHTSA ID

10392454

Incident

Feb 10, 2010

Mileage

137,000 mi

TL*THE CONTACT OWNS A 1997 LINCOLN TOWN CAR. THE CONTACT STATED THAT WHEN DRIVING AT LOW SPEEDS, THE VEHICLE SUDDENLY STALLED. THE CONTACT SHIFTED INTO NEUTRAL AND RESTARTED THE VEHICLE. THE FAILURE OCCURRED SEVERAL TIMES. THE CONTACT INFORMED THE DEALER OF THE FAILURE WAS TOLD THERE WERE NO RELATED RECALLS. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 65,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 77,000.

NHTSA ID

10362817

Incident

Oct 22, 2009

Mileage

65,000 mi

OUR 1997 LINCOLN TOWN CAR THAT WAS PART OF THE DEACTIVATION SWITCH RECALL BEGAN HONKING AS THE ALARM TRIGGERED ON THE EVENING OF AUGUST 24, 2010 IN OUR GARAGE. AFTER CLEARING THE ALARM SEVERAL TIMES, I INVESTIGATED THE BATTERY VOLTAGE AND ALL WAS WELL. THE ALARM TRIGGERED AGAIN AND I CLEARED IT. AS I CLOSED THE HOOD SMOKE BEGAN TO ESCAPE NEAR THE REAR DRIVERS SIDE CORNER OF THE HOOD. I OPENED THE HOOD AS THE SMOKE SLOWED DOWN. THE CONNECTOR TO THE DEACTIVATION SWITCH WAS VERY WARM AND THE SWITCH HAD BRAKE FLUID ON IT. THE RECALL INSTALLED 20 AMP FUSE HAD NOT OPENED. UPON INVESTIGATION I FOUND THAT THE FUSE IN THE RECALL INSTALLED HARNESS WAS IN THE CIRCUIT BETWEEN THE SWITCH AND THE CRUISE CONTROL INSTEAD OF BETWEEN THE BATTERY AND THE SWITCH. HENCE THE FUSE PROVIDED NO PROTECTION AGAINST THE POTENTIAL FIRE. THANKFULLY I WAS STANDING THERE WHEN IT HAPPENED AND COULD DISCONNECT THE CABLE FROM THE SWITCH. OTHERWISE WE WERE AT RISK OF FIRE THAT COULD HAVE SPREAD TO OUR HOUSE. *TR

NHTSA ID

10351880

Incident

Aug 24, 2010

Mileage

106,586 mi

1997 LINCOLN TOWN CAR. 120,000 MILES. SEAT BELT DOES NOT STAY BUCKLED. AND COMES UNDONE WITH SLIGHTEST OF MOVEMENT. *TR

NHTSA ID

10350784

Incident

Jun 15, 2010

Mileage

120,000 mi

I WAS DRIVING AS USUAL AND THE INTAKE MANIFOLD CRACKED OR HAD BEEN CRACKING OVER TIME. THE ENGINE MADE A PING NOISE AND THE COOLANT WAS LEAKING DOWN INTO THE ENGINE. THE ENGINE LIGHT CAME ON IMMEDIATELY. THE MANIFOLD, THERMOSTAT, AND GASKETS HAD TO BE REPAIRED. THE COST FOR THIS REPAIR WAS OVER $1,200.00. *TR

NHTSA ID

10348082

Incident

Aug 7, 2010

Mileage

118,000 mi

FORD LINCOLN -- TOWN CAR, YEAR MODEL 1997. BRAKE LINE (TUBING) BETWEEN POINT OF DISTRIBUTION FROM MASTER CYLINDER/BOOSTER TO REAR AXLE. ALSO BRAKE LINE BETWEEN REAR WHEELS (FASTENED TO OUTSIDE OF REAR AXLE HOUSING). THIS BRAKE LINE TUBING IS OF INFERIOR METAL COMPOSITION PRONE TO RUSTING IN NORTHERN CLIMATES WHERE WINTER SALT IS SPREAD ON ROAD SURFACES. CASE IN POINT: WHEN THE CAR WAS PARKED ON THE PARKING LOT, EVERYTHING WAS FINE. WHEN CAR WAS RESTARTED AFTER A SHORT DURATION OF BEING PARKED, UPON PRESSING THE BRAKE PEDAL, ALL BRAKE FLUID SQUIRTED ONTO PAVEMENT. ROOT CAUSE: THE CORRODED BRAKE LINE BURST SOMEWHERE, APPROXIMATELY, UNDER THE DRIVER'S SEAT ON THE ROADSIDE (BOTTOM SIDE) OF THE FLOOR BOARD. THIS NECESSITATES THE REPLACEMENT OF THE ENTIRE BRAKE LINE TUBING STRETCH (AS PER DESIGN) IN EXCESS OF $1,200, PARTS AND LABOR INCLUDED. THIS BURST OF FLUID COULD HAVE OCCURRED ANYWHERE. SINCE THE INCIDENT OCCURRED AT A TIME AND A PLACE FROM WHERE IT WAS POSSIBLE TO DRIVE THE CAR A SHORT DISTANCE TO ITS HOME PARKING POSITION USING ONLY THE EMERGENCY BRAKE, WHERE NEEDED, AT A SPEED OF NO HIGHER THAN 10 -15 MPH. A PRIVATE RESEARCH INDICATED THAT THIS PROBLEM IS SOMEWHAT 'COMMON.' SUBSEQUENT INQUIRIES AT DEALERSHIPS VERIFIED THE FACT THAT THERE IS A GOODLY NUMBER OF BRAKE LINE REPLACEMENTS. LABOR TIME EXPENDED IS ABOUT A FULL DAY (A FULL SHIFT). TO THE WRITER OF THIS NOTE IT IS NOT KNOWN HOW MANY SERIOUS ACCIDENTS MIGHT HAVE BEEN ALREADY CAUSED BY THIS INFERIOR QUALITY BRAKE LINE. A SHORT LENGTH OF THE SUBJECT BRAKE LINE COVERED WITH A PLASTIC COATING -- WHEN UNCOVERED TO EXPOSE THE METAL TUBING -- SHOWED THAT TUBING AS IF BRAND NEW, UNAFFECTED BY THE ROAD SALT. THIS IS A VERY SERIOUS PROBLEM, AND IT MERITS A THOROUGH INVESTIGATION INCLUDING A RECALL. THE WRITER OF THIS NOTE IS NOT AWARE OF ANY LATER MODELS HAVING THE SAME TYPE OF PROBLEM. THAT IS UP TO THE INVESTIGATORS TO FIND OUT. *TR

NHTSA ID

10343582

Incident

May 8, 2010