2006 Lincoln Town Car Seat belts Problems

Want to report similar problem others seem to be reporting. When starting the car you hear 5 chimes/beeps repeating five times. The airbag light remains lit the entire time. On extended trips the chimes/beeps comes on again roughly every thirty minutes. Being directly linked to the airbag I’m surprised to find that this has yet to be recalled especially since many other towncar owners are reporting the exact same problem. I discovered that others were having similar issues when I was looking for a replacement seat belt because ours is sluggish to retract, you have to help it back to starting position.

NHTSA ID

11445382

Incident

Dec 29, 2021

SEATBELT SENSOR ON OUR 06 LINCOLN TOWN CAR FAILED AND REPLACEMENT COST TO REPLACE THE SENSOR IS VERY PROHIBITIVE. I READ MANY COMPLAINTS WITH THIS SAME ISSUE, SO I BELIEVE FORD/LINCOLN SHOULD BE REQUIRED TO RECALL AND REPLACE SAID EQUIPMENT.

NHTSA ID

11240631

Incident

Jul 26, 2019

Mileage

97,000 mi

AIRBAG AND SEATBELT ORANGE COLORED LIGHT HAS COME ON DASHBOARD; 5 CHIMES X 5 TIMES STARTING CAR AND EVERY HALF HOUR THEREAFTER; CAR TO GARAGE, ON DIAGNOSTIC COMPUTER, FRONT DRIVER'S SEAT REMOVED; SEAT BELT PRETENSIONER BAD; UNKNOWN WITH AIRBAG; DEALERSHIP STATES CAR IS OUT OF WARRANTY; MILEAGE IS 57209.3; SEAT BELT LAP AND SHOULDER HARNESS HAVE LOCKED INTO PLACE AFTER ADJUSTMENT SINCE CAR PURCHASED IN AUGUST OF 2006; SHOULD NOT LOCK PER MY MECHANIC; DEALERSHIP AND LINCOLN UNWILLING TO PAY TO REPLACE PRETENSIONER AND SEAT BELT; CAN'T DETERMINE IF AIRBAG IS DEFECTIVE UNTIL PRETENSIONER AND SEAT BELT REPLACED; LINCOLN COULD OFFER TO COMP DEALERSHIP THE COSTS OF THE PRETENSIONER AND SEAT BELT REPLACEMENT AND AIRBAG IF AIRBAG IS FOUND TO BE DEFECTIVE; HAVE NO IDEA IF SEAT BELT WOULD WORK LET ALONE AIRBAG NOW; VERY CONCERNED DRIVING THIS CAR GOING FORWARD; CURRENT AND POTENTIAL COSTS ARE HIGH FOR ME NOW; FEEL LINCOLN SHOULD PAY AS THIS HAD TO BE A KNOWN DEFECT TO ANYONE WHO DROVE THIS CAR AT THE DEALERSHIP ONCE IT WAS DELIVERED FROM THE FACTORY.

NHTSA ID

11052280

Incident

Dec 1, 2017

Mileage

57,209 mi

I STARTED THE CAR AS USUAL AND IMMEDIATELY THE AIRBAG LIGHT BEGAN FLASHING. AFTER A COUPLE MINUTES, THE AIRBAG LIGHT WENT FROM FLASHING TO SOLID AND THE CAR BEGAN A SERIES OF 5 BEEPS AND REPEATED THIS SERIES OF BEEPS 5 TIMES. A LOCAL AUTO SHOP DIAGNOSED THE PROBLEM AS THE DRIVER SIDE SEATBELT PRE-TENSIONER AND SAID IT WOULD BE AROUND $1,000 TO REPLACE, GIVE OR TAKE A COUPLE HUNDRED. THE SHOP ADVISED IF THE REPAIR WAS NOT COMPLETED, THE AIRBAGS WOULDN'T DEPLOY IN THE EVENT OF AN ACCIDENT. AFTER RESEARCHING ONLINE, THIS SAFETY ISSUE APPEARS TO BE A COMMON OCCURRENCE AND HAS NOT YET BEEN RECALLED. THIS ISSUE OCCURS IMMEDIATELY WHEN STARTING THE CAR AND THE AIRBAG LIGHT STAYS ILLUMINATED FOR THE ENTIRE TRIP (THE SERIES OF BEEPING SEEMS TO STOP AFTER REPEATING THE SERIES 5 TIMES).

NHTSA ID

10992869

Incident

May 24, 2017

Mileage

90,800 mi

CHIMES 5 TIMES AND REPEATS 5 TIMES. THIS OCCURS EVERY 30 MINUTES ONCE CAR IS STARTED AND SEAT BELT/AIBAG LIGHT CONTINUOUSLY ON. DIAGNOSED BY FORD DEALER AS DRIVER'S SEAT BELT RETRACROR. REPLACED AND CHIME AND LIGHT WILL NOT GO OFF. HAPPENS WHILE STATIONARY AND WHILE CAR IS IN MOTION. HAVEN'T ATTEMPTED TO REPAIR AGAIN DUE TO COST AND HAVE READ THAT THIS DOESN'T NECESSARILY FIX THE PROBLEM.

NHTSA ID

10983928

Incident

May 10, 2016

Mileage

45,000 mi

SEATBELT / AIRBAG WARNING LIGHT INDICATOR IS WARNING ABOUT EITHER FAULTY SENSOR OR FAULTY BELT TENSIONER. BEGAN WHILE IN PARKED POISON AND CONTINUES PERIODICALLY WHEN IN MOTION, REGARDLESS OF SPEED. COST TO REPAIR IS EXORBITANT, NEARLY HALF THE VALUE OF THE CAR AND IS NOT GUARANTEED TO WORK IS LAST. THE AIRBAGS WILL LIKELY NOT WORTH IN THE EVENT OF ACCIDENT BUT NO WAY TO TELL UNLESS THERE IS AN ACCIDENT. SERIOUS FAULT REGARDING REQUIRED SAFETY EQUIPMENT WITH THIS MAKE/MODEL YEAR. MILEAGE IS 170,100. ALSO, THE PASSENGER SIDE FLOORBOARD, ESPECIAL IN BACKSEAT BECOME SATURATED WHEN IT RAINS. FLOOR PLUGS ARE INTACT, THE WATER IS ENTERING FROM POOR DESIGN FEATURE WHERE THE WINDSHIELD/ENGINE MEET AND SUPPOSEDLY SLOW FOR WATER TO BE CHANNELED AWAY FROM ENGINE TO GROUND BUT IS ACTUALLY CHANNELLING ALONG THE SIDE INTO THE PASSENGER CABIN FOOTWELL. AGAIN, THIS DESIGN FLAW IS A KNOWN ISSUE FROM MANUFACTURER. THIS IS A HEALTH AND SAFETY ISSUE, ESPECIALLY IN WARM CLIMATES DUE TO MOLD GROWING AS A RESULT OF WATER POOLING IN CABIN. AS THIS CAR WAS GARAGED KEPT AND NOT USED OFTEN UNTIL THE PAST 6 MONTHS, THE WATER ISSUE WASNT KNOWN UNTIL FIRST RAIN THIS SPRING, 2016. CAR WAS IN OPEN AIR, UNCOVERED DRIVEWAY AND NOT IN USE FOR 2 WEEKS AFTER SAID RAIN. WHEN OWNER OPENED CAR DOOR, SHE WAS HIT WITH OVERWHELMING STENCH OF MOLD. SHE LOCATED THE SOURCE AND WATER HAD VISIBLY SATURATED FLOOR, RUG AND PADDING UNDERNEATH. BLACK AND GREEN MOLD HAD GROWN EXTENSIVELY IN BACKSEAT PASSENGER FLOORBOARD AND UNDER FRONT PASSENGER SEAT.

NHTSA ID

10903533

Incident

May 1, 2016

Mileage

170,190 mi

TL* THE CONTACT OWNS A 2006 LINCOLN TOWN CAR. THE CONTACT STATED THAT THE AIR BAGS AND SEAT BELT WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO A MECHANIC FOR FURTHER INSPECTION AND DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA ID

10903364

Incident

Aug 29, 2016

TL* THE CONTACT OWNS A 2006 LINCOLN TOWN CAR. WHILE DRIVING 35 MPH, THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FRONT SEAT BELT RETRACTION SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 52,000.

NHTSA ID

10838483

Incident

Feb 21, 2016

Mileage

52,000 mi

PERMANENT FAILURE OF THE DRIVER PRETENSIONER. OPEN CIRCUIT. 72000 MILES.

NHTSA ID

10787545

Incident

Oct 31, 2015

Mileage

72,000 mi

TL* THE CONTACT OWNS A 2006 LINCOLN TOWN CAR. WHILE PARKED, THE SEAT BELT AND AIR BAG WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE DRIVER SIDE SEAT BELT SENSOR WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED ON THE PASSENGER SIDE SEAT BELT SENSOR. THE FAILURE MILEAGE WAS 46,300. UPDATED 8/10/15*CN

NHTSA ID

10723975

Incident

Jun 18, 2014

Mileage

46,300 mi

I TOOK CAR IN FOR INSPECTION, AIR BAG LIGHT ON. DEALER INFORMED FAULTY SENSOR IN PASSENGER SEAT BELT RETACTOR COST TO REPAIR 1080.00 YEAH! THEY SAID WARRANTY GONE SO SORRY. ON A SEAT BELT? *TR

NHTSA ID

10700834

Incident

Mar 12, 2015

Mileage

53,000 mi

SEAT BELT/AIR BAG LIGHT CAME ON. VEHICLE PURCHASED NEW, ORIGINAL DEALER DIAGNOSED BAD SEAT BELT PRE TENSIONER INTERNALLY FAULTED ON DRIVERS SIDE. OUT OF WARRANTY, AND VEHICLE WAS REPAIRED AT A COST OF $354 PARTS AND $305 LABOR. SEAT BELT/AIR BAG LIGHT CAME ON AGAIN JAN 8, 2015. ORIGINAL DEALER DIAGNOSED BAD SEAT BELT PRE TENSIONER ON THE PASSENGER SIDE. PARTS ON ORDER AND TO BE REPAIRED FEB 26, 2015. PARTS COST $507 AND $305 LABOR. THIS IS A DEFINITE SAFETY ITEM THAT HAS A HISTORY WITH THIS VEHICLE YEAR AND MODEL. COST TO CUSTOMER IS EXCESSIVE AND UNACCEPTABLE CONSIDERING THIS ITEM MUST BE REPAIRED TO INSURE A FUNCTIONAL SEAT BELT AND AIR BAG IN THE EVENT OF AN ACCIDENT. THE EXCESSIVE COSTS APPEARS TO BE DISCOURAGING SOME OWNERS FROM REPAIRING THIS SAFETY ITEM ACCORDING TO OTHER COMPLAINTS TO NHTSA. FORD MOTOR COMPANY HAS NOT FULFILLED REASONABLE MANUFACTURERS RESPONSIBILITY ON A SAFETY ITEM THAT COULD CAUSE SEVERE INJURY OR DEATH AS A RESULT OF THE MALFUNCTION OF KNOWN DEFECT IN A REQUIRED PIECE OF SAFETY EQUIPMENT. *TR

NHTSA ID

10679050

Incident

May 29, 2013

Mileage

13,093 mi

TL* THE CONTACT OWNS A 2006 LINCOLN TOWN CAR. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 60 MPH, THE AIR BAG WARNING LIGHT ILLUMINATED AS A CHIME SOUNDED. THE FAILURE RECURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE PRETENSIONER ON THE DRIVER'S SIDE SEAT FOR THE SEAT BELTS FAILED. AS A RESULT, A DRIVERS SIDE SEAT BELT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 95,000. UPDATED 02/18/15*LJ UPDATED 10/2/2015*JS

NHTSA ID

10669367

Incident

Nov 3, 2014

Mileage

95,000 mi

TL* THE CONTACT OWNS A 2006 LINCOLN TOWN CAR. THE CONTACT STATED THAT THE AIR BAG LIGHT ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE CONTACT WAS ADVISED THAT THE SEAT BELT SENSOR AND THE SEAT BELT ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 42,000.

NHTSA ID

10661660

Incident

Nov 3, 2014

Mileage

42,000 mi

WITHIN A MILE OF LEAVING HOME, THE SEAT BELT LIGHT CAME ON & STARTED BEEPING. DRIVER GLANCED DOWN TO CHECK SEATBELT ONLY TO FIND THAT IT WAS COMING UNLATCHED. IN THE BRIEF SECONDS THAT IT TOOK TO GLANCE DOWN & BACK UP, DRIVER WAS ALREADY LEAVING THE ROAD AND IN A PANIC, ACCIDENTALLY HIT GAS INSTEAD OF BRAKE. CAR WAS TOTALLED. THE ONLY AIRBAG THAT DEPLOYED WAS THE STEERING WHEEL. DRIVER SUSTAINED SERIOUS TRAUMA INJURIES TO HEAD, RIBS, PELVIS, FEMUR AS WELL AS EXTENSIVE HEMATOMAS. DRIVER IS ALSO SUFFERING FROM STRESS RELATED TO ACCIDENT. DRIVER IS NOW RECOVERING WITH THE AID OF PHYSICAL THERAPY AND OTHER DEVICES FOR MOBILITY (WALKER, WHEELCHAIR, CANE, ETC.). DRIVER IS SON OF OWNER OF VEHICLE. *TR

NHTSA ID

10653722

Incident

Oct 18, 2014

Mileage

85,000 mi

LIGHT FOR SEAT BELT CAME ON AND THERE WAS A BEEPING SONG, TOOK TO DEALERSHIP, SAID THAT WAS A SHORTAGE AND THE PRE-TENSIONERS SEAT BELT RETRACTOR HAD TO BE REPLACE, IF NOT REPLACE IF I GOT INTO AN ACCIDENT THE AIRBAG WOULD NOT DEPLOY. PAID 719.00 TO HAVE REPLACE. FAST FORWARD TO TODAY OCT. 22, 2014. SAME THING HAPPEN AGAIN TOOK IT TO DEALER SAID THAT THIS TIME IT IS THE DRIVER SIDE THAT NEEDS TO BE REPLACED. SPOKE WITH SOME OTHER LINCOLN OWNER OF 2006 LINCOLN, IT SEEMS AS THOUGH QUITE A FEW PEOPLE ARE HAVING THE SAME PROBLEM. *TR

NHTSA ID

10649289

Incident

Mar 18, 2014

Mileage

36,112 mi

TL* THE CONTACT OWNS A 2006 LINCOLN TOWN CAR. THE CONTACT STATED THE AIR BAG WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN DIAGNOSED THAT THE SEAT BELT PRETENSIONER NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 68,000.

NHTSA ID

10648359

Incident

Sep 12, 2014

Mileage

68,000 mi

TL* THE CONTACT OWNS A 2006 LINCOLN TOWN CAR. WHILE STARTING THE VEHICLE, THE AIR BAG WARNING INDICATOR REMAINED ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FRONT PASSENGER SIDE SEAT BELT ASSEMBLY NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

NHTSA ID

10641102

Incident

Jan 13, 2014

Mileage

120,000 mi

THIS WELL-MAINTAINED CAR IS KEPT IN A PRIVATE GARAGE. I CRANKED CAR IN THE MORNING AND AIR BAG LIGHT CAME ON. DROVE TO DEALER WITHOUT PROTECTION OF AN OPERATIONAL AIR BAG SYSTEM. DEALER IDENTIFIED PROBLEM AS PASSENGER SIDE, FRONT SEATBELT PRETENSIONER BUT THERE HAD BEEN NO PASSENGER IN CAR EITHER THE LAST TIME IT WAS DRIVEN OR AS THE CAR WAS CRANKED AND AIR BAG LIGHT CAME ON INDICATING A PROBLEM EXISTED. *TR

NHTSA ID

10627150

Incident

Aug 15, 2014

Mileage

48,867 mi

MY CAR IS MAKING A BEEPING NOISE AND THE AIR BAG SIGN IS SHOWING ON THE DASH. *TR

NHTSA ID

10622012

Incident

Jan 1, 2014

TL* THE CONTACT OWNS A 2006 LINCOLN TOWN CAR. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE SEAT BELT FAILED TO RETRACT IN ORDER TO FIT SNUGLY ACROSS THE OCCUPANT. THE DEALER STATED THAT THE SEAT BELT PRE-TENSIONER NEEDED TO BE REPLACED. THE CONTACT STATED THAT THE DRIVER SIDE SEAT BELT PRE-TENSIONER WAS PREVIOUSLY REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 87,896. JCC UPDATED 8/22/14*CN THE VEHICLE REPAIRED. UPDATED 09/11/14

NHTSA ID

10619253

Incident

Sep 20, 2013

Mileage

87,896 mi

SAFETY ISSUE WITH AIR BAG/SEAT BELT. HAVE HAD BOTH DRIVER'S AND PASSENGER'S SEAT BELTS REPLACED DUE TO AIR BAG LIGHTS COMING ON. BETWEEN THE TWO REPAIRS HAVE SPENT OVER $1,200. SHOULD BE A RECALL ON THIS PROBLEM SINCE THE AIR BAGS WON'T DEPLOY IN CASE OF AN ACCIDENT. *TR

NHTSA ID

10616155

Incident

Apr 19, 2013

Mileage

71,800 mi

WARNING LIGHT CAME ON BEEPED 5X IN A ROW SEVERAL TIMES STOPPED THEN REPEATED OVER AND OVER AS LONG AS WE WERE DRIVING. COST OVER 450.00 TO REPLACE SEAT BELT. THERE SEEM TO BE MANY OF THIS SAME PROBLEM LISTED. I HAVE HAD 7 TOWN CARS IN THE LAST 20 YEARS, NEVER HAD A PROBLEM. I HAVE ALREADY HAD A RECALL REPAIR ON THE STEERING COLUMN. BUT, STILL LOVE THAT CAR!!! *TR

NHTSA ID

10616046

Incident

May 21, 2014

Mileage

110,000 mi

AIR BAG DASH LIGHT ON, THERE ARE 5 BEEPS FIVE TIMES EVERY HALF HOUR. REPAIR SHOP/LINCOLN DEALER SAYS IT'S A SEAT BELT SENSOR FAILURE. SEAT BELT MAKER WENT OUT OF BUSINESS. LINCOLN WILL NOT GUARANTEE THAT A REPLACEMENT BELT FROM THEIR STOCK WILL WORK. COST TO REPLACE SEAT BELT PARTS AND LABOR $700.00. PER MANY BLOG SITES THIS IS A PROBLEM THAT FORD/LINCOLN HAS NOT ADDRESSED. WHEN QUESTIONED LINCOLN DEALER WILL NOT CONFIRM THAT THE AIR BAGS WILL DEPLOY IN THE EVENT OF AN ACCIDENT. *TR

NHTSA ID

10609824

Incident

May 12, 2014

Mileage

106,500 mi

SEAT BELT ALARM STARTED GOING OFF. FORD SERVICE DEPARTMENT SAID THEY KNEW OF THE CONDITION. THE SEAT BELT IS NOT WORKING CORRECTLY AND IN CASE OF AN ACCIDENT THE AIR BAG/S WILL NOT ENGAGE. THIS IS A SAFETY HAZARD THAT THE FORD COMPANY HAS KNOWN ABOUT AND REFUSES TO FIX AT THEIR COST. IT IS ABOUT $1,000.00 AND I DO NOT HAVE THAT KIND OF MONEY.. THIS TO ME DOESN'T SEEM ANY DIFFERENT THEN GM KNOWING THERE IS A SAFETY PROBLEM BUT REFUSES TO DO A RECALL. FORD SERVICE DEPARTMENT CLAIMS THERE HASN'T BEEN ENOUGH REPORTS OF THE PROBLEM TO DO A RECALL. SO NOT HAVING THE MONEY TO FIX THIS, I'M RISKING MY LIFE AND ANYONE RIDING IN THE FRONT SEAT WITH ME EACH AND EVERY TIME I DRIVE THE CAR. I WOULD APPRECIATE ANY AND ALL HELP ON THIS MATTER. *TR

NHTSA ID

10592665

Incident

Nov 14, 2012