2010 Mazda Mazda6 Body & structure Problems

The contact owns a 2010 Mazda Mazda6. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently veered to the left. There was no warning light illuminated. The contact stated that the vehicle became difficult to steer. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the engine cradle had failed and was severely rusted and needed to be replaced. The vehicle was not repaired. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 114,000.

NHTSA ID

11649768

Incident

Mar 21, 2025

Mileage

114,000 mi

The contact owns a 2010 Mazda Mazda6. The contact stated while driving 40–45 MPH, there was an abnormal sound coming from the vehicle. The TPMS warning light was illuminated. The vehicle was taken to an independent mechanic, who informed the contact that the rear main sub frame was completely rusted. There was a crack detected in the middle of the sub frame. The vehicle was taken to the local dealer, where it was diagnosed that the rear sub frame was rusted and needed to be replaced. The vehicle was not repaired. The manufacturer informed the contact that it was normal wear and tear, but no assistance was provided. The failure mileage was approximately 130,000.

NHTSA ID

11572146

Incident

Feb 11, 2024

Mileage

130,000 mi

The contact owns a 2010 Mazda Mazda6. The contact stated that while driving at an undisclosed speed, the rear frame detached from the vehicle. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 18V631000 (Suspension, Structure) and the contact related the failure to the recall. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 160,000.

NHTSA ID

11538412

Incident

Aug 14, 2023

Mileage

160,000 mi

The contact owns a 2010 Mazda Mazda6 . The contact stated while driving approximately 25 mph and drove over a bump and lost control of the vehicle and crashed into another vehicle. The contact stated the disc off warning light was illuminated. The contact stated no one was injured nor sought medical attention. A police report was not filed. The vehicle was not drivable. The contact was towed to her residence and then to a local dealer, where it was diagnosed with the rear structure was corroded and needed to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 180,000. The contact stated that the dealership deemed the vehicle unsafe to bring to the shop and therefore did not perform the necessary repairs in the recall. The dealer notified the contact about that as well as the manufacturer. The contact must arrange a way to tow the vehicle off of their lot.

NHTSA ID

11515224

Incident

Feb 7, 2023

Mileage

180,000 mi

The contact owns a 2010 Mazda Mazda6. The contact stated that while driving at an undisclosed speed, the vehicle made abnormally loud sounds. The vehicle was taken to the dealer where it was diagnosed that the rear cross members and brakes needed to be replaced. The dealer advised the contact to not drive the vehicle until the repairs were performed. The vehicle was then taken to an independent mechanic who replaced the brakes; however, the rear cross members were not replaced. The manufacturer was not made aware of the failure. The failure mileage was approximately 186,000.

NHTSA ID

11471554

Incident

Jun 29, 2022

Mileage

186,000 mi

The contact owns a 2010 Mazda Mazda6. The contact stated that the vehicle had previously been serviced at the dealer under NHTSA Campaign Number: 18V631000 (Suspension, Structure). The contact stated that while driving at an undisclosed speed, she lost control of the vehicle. The failure caused the passenger's side rear tire to rub on the fender while driving. The vehicle was taken to an independent mechanic who diagnosed that the passenger's side rear subframe was severely corroded and had fractured in half. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 82,000.

NHTSA ID

11469128

Incident

Jun 14, 2022

Mileage

82,000 mi

The contact owns a 2010 Mazda Mazda6. The contact stated that the steering wheel was pulling without warning. There was rust on the frame. The vehicle was taken to an independent mechanic and the contact was informed that the vehicle was not safe to drive. The local dealer was contacted. The vehicle was diagnosed and repaired. Mechanic noted that Mazda’s recall repair only served to keep the car from splitting apart, but it in no way resolved the control arm issue. As a result my car was unexpectedly swerving all over the road and was difficult to control. It was with the control arm still somewhat attached, though extremely loose. The contact stated that the vehicle was previously repaired under NHTSA Campaign number 18V631000 (Suspension, structure). The manufacturer was not contacted. The failure mileage was 151,000. Consumer stated there is significant rust on on side, where control arm attaches to steering. Vehicle has been repaired.

NHTSA ID

11426631

Incident

Jul 27, 2021

Mileage

151,000 mi

TL* THE CONTACT OWNS A 2010 MAZDA MAZDA6. THE CONTACT STATED WHILE DRIVING 10 MPH, THE VEHICLE MADE AN ABNORMALLY LOUD SOUND BY THE PASSENGER'S SIDE ENGINE COMPARTMENT. THE STEERING THEN BECAME DIFFICULT TO TURN. THE CONTACT STATED THAT THERE WAS NO WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER BILL GATTON OF JOHNSON CITY MAZDA (2909 N. ROAN ST, JOHNSON CITY, TN 37601, (423) 418-6152) WHERE IT WAS DIAGNOSED WITH NEEDING THE SUBFRAME TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. UPON INVESTIGATION, THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 18V631000 (SUSPENSION, STRUCTURE) HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS INFORMED OF FAILURE AND THE CONTACT WAS REFERRED TO NHTSA FOR ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 150,000.

NHTSA ID

11390230

Incident

Jan 18, 2021

Mileage

150,000 mi

PASSENGER SIDE DASH STARTED MELTING ABOUT A YEAR AGO AND HAS GOTTEN SO BAD THE DASH IS ALMOST LIQUID. SUNLIGHT REFLECTS OFF THE SHINY MELTED DASH AND BLINDS THE DRIVER. I WAS IN AN ACCIDENT BECAUSE I COULDN'T SEE DUE TO LIGHT REFLECTING OFF MELTED DASH. DASH IS SO STICKY THAT YOU CANNOT TOUCH OR IT WILL STICK TO HANDS/ CLOTHING. I HAVE RUINED MULTIPLE ITEMS OF CLOTHING DUE TO THIS MESS.

NHTSA ID

11386507

Incident

Dec 31, 2019

Mileage

90,000 mi

TL* THE CONTACT OWNS A 2010 MAZDA MAZDA6. THE CONTACT STATED THAT THEIR VEHICLE'S DASHBOARD WAS STICKY AND HAD AN EXCESSIVE AMOUNT OF GLARE FROM SUNLIGHT. THE CONTACT STATED THAT THE GLARE MADE IT DIFFICULT TO SEE WHEN DRIVING. THE CONTACT STATED THAT THE DASHBOARD WAS FRACTURED ON THE PASSENGER'S SIDE OF THE VEHICLE. THE CONTACT CONTACTED THE DEALER FITZGERALD MAZDA OF ANNAPOLIS (1930 WEST ST, ANNAPOLIS, MD 21401, (410) 266-5700) WHO INFORMED THE CONTACT THE DASHBOARD NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 57,000.

NHTSA ID

11348413

Incident

Aug 1, 2018

Mileage

57,000 mi

I STARTED NOTICING CRACKS ON THE DASHBOARD ON THE PASSENGER SIDE WHERE THE AIRBAG DEPLOYS. MY VEHICLE WAS STATIONARY WHEN I NOTICED THTHE CRACKS THE FOLLOWING MORNING. I AM CONCERNED THAT THE AIRBAG MIGHT ACCIDENTALLY GO OFF WITH THE SLIGHTEST VIBRATIONS OR CLOSING OF THE VEHICLE DOORS.

NHTSA ID

11312073

Incident

Feb 17, 2020

Mileage

137,000 mi

PAINT IS CHIPPING AWAY ON THE REAR OF THE CAR.

NHTSA ID

11309089

Incident

Feb 13, 2020

Mileage

137,000 mi

THE PASSENGER LOWER CONTROL ARM BROKE WHILE DRIVING, AND I LOST CONTROL OF THE VEHICLE. I ALMOST HIT A CAR COMING TOWARDS, BUT THANKFULLY I WAS ABLE TO STOP SINCE I WAS ONLY DOING 35 MPH. I DON'T KNOW WHAT WOULD HAVE HAPPENED IF I WAS ON THE HIGHWAY. THE MECHANIC SAID THE SUB-FRAME WAS COMPLETELY ROTTED OUT AND IT WAS NOT SAFE TO DRIVE THE VEHICLE ANYMORE. APPARENTLY, THE A/C IS DRAINING RIGHT ONTO THE CONTROL ARM AREA, WHICH MAY OR MAY NOT HAVE AFFECTED THE SITUATION.

NHTSA ID

11255782

Incident

Sep 14, 2019

Mileage

88,000 mi

TL* THE CONTACT OWNS A 2010 MAZDA 6. THE CONTACT STATED THAT THERE WAS EXTENSIVE RUST AND CORROSION ON THE VEHICLE. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 18V631000 (SUSPENSION, STRUCTURE). THE VEHICLE WAS TAKEN TO MCDONALD MAZDA (10345 W COLFAX AVE, LAKEWOOD, CO 80215, (720) 449-9900) WHERE THE CROSS MEMBER WAS INSPECTED, BUT THEY REFUSED TO INSTALL A SIDE MEMBER (FOR REINFORCEMENT). THE DEALER ALSO HAD NOT REPLACED THE AIR CONDITIONER DRAIN HOSE AND NO RUST PROOFING WAS APPLIED TO THE CROSS MEMBER. THE VEHICLE WAS NOT REPAIRED DUE TO NON-COMPLIANCE OF THE DEALER AND THE MANUFACTURER. THE VEHICLE WAS NOT BEING DRIVEN. THE APPROXIMATE FAILURE MILEAGE WAS 103,981. *BF CONSUMER STATED UPON SEEING THE UNDERSIDE OF THE VEHICLE I IMMEDIATEDLY NOTICED CORROSION COVERING LARGE PORTIONS OF THE CROSS MEMBER. THERE WERE SEVERAL CORRODED MOUNTING HOLES AND LARGE WELDS THAT HAD SIGNS OF ADVANCED DECAY. THE DAMAGE WAS OBVIOUS AND I TOOK SEVERAL PICTURES AND RECORDED A VIDEO SHOWING THE WIDESPEAD CORROSION. 'PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'*JB

NHTSA ID

11209494

Incident

Nov 1, 2018

Mileage

103,981 mi

I HAVE THE OPEN AND DANGEROUS RECALL ( # 2818I ) STILL PENDING AT THIS TIME. IT WAS HARD ENOUGH JUST TO GET THE DEALERSHIP, IN ORDER TO INSPECT THE CAR FOR CORROSION IN THE CONCERNING AREAS. I DON'T FEEL THAT THE CAR IS SAFE TO DRIVE AT THIS TIME AND PREFER THAT NO ONE RIDES WITH ME WHEN DRIVING IT, JUST FOR THE SAFETY OF OTHERS. I'M VERY CONCERNED THAT THIS FIX WILL NOT COME SOON ENOUGH AND THE PROBLEM KEEP MESSING UP MY CARS ALIGNMENT. CAUSING ALL SORTS OF PROBLEMS DRIVING IT, ESPECIALLY AT HIGH SPEEDS. THAT'S WHEN A WHEEL WOBBLE STARTS TO HAPPEN IN THE AFFECTED AREAS OF THE FRONT PASSENGER SIDE OF THE CAR. PLEASE HELP!

NHTSA ID

11180511

Incident

Jan 23, 2019

Mileage

128,592 mi

LETTER FROM CONSUMER RE: FAIR AND EQUITABLE REIMBURSEMENT CUSTOMER TREATMENT ON 2010 MAZDA 6 RECALL REPAIR (DEFECT) NOT TOTALLY PAID FOR BY MAZDA WARRANTY DEPARTMENT. *AS *TR

NHTSA ID

11180791

Incident

Feb 7, 2019

TL* THE CONTACT OWNS A 2010 MAZDA 6. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 18V631000 (SUSPENSION, STRUCTURE). THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. BROWN'S FAIRFAX MAZDA (10570 FAIRFAX BOULEVARD, FAIRFAX, VA 22030, (703) 385-8170) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ID

11179800

Incident

Feb 1, 2019

TL* TAKATA RECALL. THE CONTACT OWNS A 2010 MAZDA 6. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 18V717000 (AIR BAGS) AND 18V631000 (SUSPENSION, STRUCTURE). THE CONTACT CALLED SENTRY WEST MAZDA AT 508-281-8171 (LOCATED AT 940 BOSTON TURNPIKE, SHREWSBURY, MA 01545) AND WAS INFORMED THAT THE PARTS WERE NOT AVAILABLE. WHILE DRIVING APPROXIMATELY 20 MPH, A LOUD NOISE WAS HEARD AND THE STEERING LOST POWER WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE SAME DEALER WHERE IT WAS STATED THAT THE RECALL REPAIRS NEEDED TO BE PERFORMED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 60,000. PARTS DISTRIBUTION DISCONNECT FOR NHTSA CAMPAIGN NUMBER: 18V717000 (AIR BAGS) AND VIN TOOL CONFIRMS PARTS NOT AVAILABLE FOR NHTSA CAMPAIGN NUMBER: 18V631000 (SUSPENSION, STRUCTURE).

NHTSA ID

11166558

Incident

Jan 3, 2019

Mileage

60,000 mi

THE CAR IS ONLY 8 YEARS OLD AND THE SUB FRAME HAS COMPLETELY RUSTED OUT, DEEMING THE CAR UNFIT TO DRIVE. THIS WAS ONLY CAUGHT AS I TOOK THE CAR IN FOR ESTIMATE ON BRAKES. I HAVE 2 YOUNG CHILDREN WHO RIDE IN THIS CAR DAILY, SO LUCKILY NO ACCIDENT. I'VE NOTICED SEVERAL COMPLAINTS REGARDING THIS ON THE 2009 AND 2010 MODELS. ALTHOUGH I HAVEN'T BEEN IN ACCIDENT (YET), I'M NOW FORCED TO PAY $2000 IN REPAIRS, OR JUST REPLACE THE VEHICLE.

NHTSA ID

11142929

Incident

Oct 26, 2018

Mileage

147,000 mi

WHILE PERFORMING MAINTENANCE ON 2010 MAZDA 6 IT WAS OBSERVED THERE WAS EXTENSIVE CORROSION TO THE FRONT SUBFRAME. IT IS VERY NEAR STEERING AND SUSPENSION COMPONENTS AND HAD THE FRAME FAILED WHILE DRIVING IT LIKELY WOULD HAVE RESULTED IN LACK OF CONTROL OF THE VEHICLE. PICTURE IS ATTACHED.

NHTSA ID

11129185

Incident

Sep 12, 2018

Mileage

92,000 mi

TL* THE CONTACT OWNS A 2010 MAZDA 6. WHILE DRIVING APPROXIMATELY 30 MPH, THE STEERING WHEEL STARTED TO PULL TO THE RIGHT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DETERMINED THAT THE PASSENGER SIDE SUBFRAME WAS SEVERELY CORRODED AND FLAKY. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200,00. THE VIN WAS UNAVAILABLE.

NHTSA ID

11128774

Incident

Sep 10, 2018

Mileage

200,000 mi

AS I WAS DRIVING DOWN THE INTERSTATE MY STEERING WHEEL ROTATED CLOCKWISE AND WAS AT AN ANGLE AND MY CAR CONTINUED TO GO STRAIGHT DOWN THE ROAD. IT FELT AS IF I WERE DRIVING ON ICE AND WAS VERY HARD TO CONTROL THE VEHICLE. WHILE MAKING A TURN MY FRONT TIRES BEGAN TO SQUEAL. IT WAS VERY HARD TO TURN. WHEN BRAKING THE CAR SHOOK DRAMATICALLY. I TOOK IT TO A LOCAL AUTO MECHANIC BECAUSE I THOUGHT IT WAS POSSIBLY SOMETHING WITH THE STEERING. THE MECHANIC CALLED BACK AND WAS SHOCKED TO TELL ME THE SUB FRAME WAS COMPLETELY ROTTEN AND HAD BROKEN. IT WAS HARD FOR HIM TO BELIEVE THAT A CAR THAT WAS ONLY 8 YEARS OLD WOULD HAVE THAT MUCH CORROSION ON THE FRAME. I PURCHASED THE CAR BRAND NEW AND HAVE HAD THE CAR FOR THE ENTIRE 8 YEARS WITH NO ACCIDENTS AT ALL.

NHTSA ID

11124647

Incident

Sep 5, 2018

Mileage

162,000 mi

I WAS DRIVING HOME FROM WORK, WHEN I NOTICED THAT MY STEERING WAS NOT WORKING RIGHT. EVERY TIME I HIT A BUMP IN THE ROAD IT BECAME HARD TO CONTROL. TO STAY STRAIGHT, MY STEERING WHEEL HAD TO BE TURN ALMOST COMPLETELY LEFT. I FIGURED I WAS JUST BADLY OUT OF ALIGNMENT. I TOOK IT TO THE SHOP TO GET MY ALIGNMENT DONE, AND THEY TOLD ME THE SUB FRAME WAS ROTTED OUT. THE CAR IS ONLY 8 YEARS OLD AND WELL MAINTAINED. HE WAS NOT ABLE TO EXPLAIN WHY IT WAS ROTTED OUT, BUT THE REST OF THE UNDERNEATH LOOKED GOOD.

NHTSA ID

11115303

Incident

Jul 28, 2018

Mileage

80,000 mi

MY WIFE WAS DRIVING ON THE INTERSTATE AT 70 MPH WHEN ALL OF THE SUDDEN THE CAR VEERED TO THE RIGHT CAUSING HER TO GO INTO THE RIGHT LANE AS SHE WAS IN THE LEFT LANE. THANKFULLY NO ONE WAS BESIDE HER AND SHE WAS ABLE TO KEEP THE CAR UNDER CONTROL. SHE STOPPED AND CALLED ME AS I WAS AT WORK TO EXPLAIN WHAT HAD HAPPENED. SHE WAS JUST A FEW MILES AWAY FROM THE EXIT IN WHICH WE LIVE JUST OFF THE INTERSTATE SO SHE WAS ABLE TO LIMP THE CAR HOME. LATER THAT EVENING WHEN I WENT TO LOOK AT IT I NOTICED IMMEDIATELY THAT THE PASSENGER TIRE WAS POINTING OUTWARD A LITTLE BIT. I JACKED THE CAR UP LOOKING TO SEE IF A TIE ROD OR CONTROL ARM HAD BROKE ONLY TO FIND THAT NEITHER HAD BROKE. I LOOKED AT THE FRAME AND SEEN HOW BADLY IT WAS RUSTED AND NOTICED IT ACTUALLY HAD BROKEN APART AND WAS SHIFTED. THIS AREA OF THE SUBFRAME IS DIRECTLY UNDER THE A/C UNIT WHICH DRIPS STRAIGHT DOWN ONTO THE FRAME AREA THAT IS ROTTED. WHICH IS OBVIOUSLY THE REASON THE THE FRAME RUSTED AND BROKE AND SHIFTED CAUSING THE TIRE TO POINT OUTWARD. CALLED MAZDA AND THEY SENT A TOW TRUCK TO RETRIEVE THE CAR. CURRENTLY WAITING ON THEIR INSPECTION AND A CALL FROM MAZDA CORP TO SEE IF THEY WILL BE COVERING THE REPAIR. AFTER READING EVERYONE ELSE'S ISSUES WITH THIS VERY SAME PROBLEM I'M ASSUMING MAZDA WILL TELL ME IT'S OUR PROBLEM. THE CAR IS ONLY 8 YEARS OLD AND I'VE SEEN OTHER'S WHO'S CAR ARE EVEN NEWER AND MAZDA IS TELLING EVERYONE IT'S NOT DEFECTIVE. I STRONGLY DISAGREE WITH IT NOT BEING A MANUFACTURED DEFECT WHEN CLEARING THE WATER FROM THE A/C DRIPPING DOWN IS CAUSING ALL THESE SUBFRAMES TO RUST MUCH FASTER THAN ANY OTHER PART OF THE FRAME. WE'LL SEE WHAT THEY SAY BUT I'M NOT HOLDING MY BREATH.... SEEMS AS THOUGH WE THE PEOPLE NEED TO BAND TOGETHER IN A CLASS ACTION AGAINST MAZDA BECAUSE THIS CLEARLY IS A PROBLEM FOR A LOT OF CONSUMERS. PRAY NO ONE EVER GETS KILLED DO TO LOSS OF CONTROL WHEN THE FRAMES DO BRK.

NHTSA ID

11114939

Incident

Jul 30, 2018

Mileage

100,000 mi

THE FRAME ON MY VEHICLE SPECIALLY THE 'CRADLE' ON THE PASSENGER SIDE FAILED WHILE BRAKING. SPECIFICALLY THE ''CRADLE' IS RUSTED AND SPLIT ALMOST ALL THE WAY THROUGH. THE VEHICLE IS NOW UNDRIVABLE. IT IS A SEVERE SAFETY RISK

NHTSA ID

11113461

Incident

Jul 19, 2018

Mileage

198,000 mi