1991 Mazda Protege Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1991 Mazda Protege, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Seat belts2747.4%
- Body & structure712.3%
- Electrical47.0%
- Brakes35.3%
- Transmission35.3%
- Engine23.5%
- Interior & seats23.5%
- Suspension23.5%
- Driver assistance23.5%
- Exterior lighting11.8%
- Airbags11.8%
- Other / unspecified11.8%
- Powertrain (other)11.8%
- Tires & wheels11.8%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Seat belts
Reports naming seat belts, buckles, retractors and pretensioners.
From owner reports, verbatim
TL* THE CONTACT OWNS A 1991 MAZDA PROTEGE. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 45 MPH DURING RAIN WEATHER CONDITIONS, THE VEHICLE WENT OVER A POTHOLE CAUSING THE CONTACT TO LOSE CONTROL OF THE VEHICLE AND STOPPING ON THE SHOULDER OF THE ROAD. THE CONTACT THEN ATTEMPTED TO DRIVE AND THE VEHICLE SPUN CRASHING THE FRONT OF THE VEHICLE INTO A TREE. THE SEAT BELT DETACHED AND THE CONTACT WAS RELEASED FROM THE REAR WINDOW. THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS TOWED AND DEEMED DESTROYED. THE CONTACT RECEIVED KNEE, HEAD, AND BACK INJURIES WHICH REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000. UPDATED 03/15/16*LJ *TR
THE AUTOMATIC SHOULDER BELT WOULD RETRACT SLOWER AND SLOWER UNTIL IT FINALLY STOPPED RETRACTING. THE CONSEQUENCES WERE: ON APRIL 18, 2005 I WAS GIVEN A FIX-IT TICKET FOR NOT WEARING MY SHOULDER HARNESS.*AK THE AUTOMATIC HARNESS NO LONGER FULLY RETRACTS, SO IT IS USELESS.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
REAR STRUT TOWERS RUST RIGHT THROUGH. *TR
WHILE DRIVING, THE VEHICLE'S HOOD DETACHED RESULTING IN THE HOOD HITTING THE WINDSHIELD.*MR *CB *JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
TL* THE CONTACT OWNED A 1991 MAZDA PROTEGE. WHILE DRIVING VARIOUS SPEEDS, SMOKE APPEARED UNDER THE HOOD. THERE WERE NO FLAMES VISIBLE AND NO INJURIES. THE VEHICLE WAS DESTROYED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V674000 (ELECTRICAL SYSTEM). THE FAILURE MILEAGE WAS UNKNOWN.
THE HORN GOES OFF RANDOMLY WITHOUT APPLYING IT DUE TO A SHORT CIRCUIT IN THE STEERING COLUMN. DEALER HAS NOT SEEN VEHICLE. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
THE BRAKE PEDAL STINKS, DEALER HAS BLED THEM AND REPLACED THE MASTER CYLINDER. NLM
BRAKES SQUEAK. *DSH
Too few reports in this category for a page of its own — they appear in the full complaint list.
Transmission
Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.
From owner reports, verbatim
TRANSMITION LOCKED UP GOING 65 MPH. *AK
WHILE DRIVING VEHICLE SHIFT LEVER FELL DOWN (3) OR (4) INCHES, LEAVING DRIVER SHIFTLESS, STUCK IN NEUTRAL POSITION.*AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
VEHICLE CAUGHT FIRE.
WHILE STOPPED IN DRIVE GEAR WITH FOOT ON BRAKE, VEHICLES FRONT SUSPENSION VIBRATES, DEALER HAS REPLACED MOTOR MOUNTS, BUT PROBLEM PERSISTS. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Interior & seats
Reports naming seats, latches, locks, linkages and interior fittings.
From owner reports, verbatim
ON THREE OCCASIONS WHILE DRIVING THE REAR SEAT BELT FELL APART WHILE MAKING A TURN. REPLACMENT COULD NOT BE DONE DUE TO NO WARRANTY. *YC
REAR DOORS WILL NOT UNLOCK.THIS HAPPENS WHEN THE CAR IS ON OR OFF ,AND THESE ARE MANUAL DOORS.DEALER HAS YET TO BE CONTACTED. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
REAR SWAY BAR MAKES A LOUD NOISE AND BROKE. IN FOR REPAIR. WILL PROVIDE REPAIR BILL. *AK
THE SEAT BELT WARNING LIGHT KEEP COMING ON DEALER CHECK IT OUT CAN'T FIND PROBLEM. TT
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
WENT TO STOP AT STOP LIGHT, ENGINE CONTINUED TO ACCELERATE, UNABLE TO STOP. REARENDED STATIONARY VEHICLE AT LIGHT. OUR VEHICLE TOTALED. DRIVER SUSTAINED INJURIES. *AK
WHEN ACCELERATING ABOVE 30MPH, ACCELERATOR STICKS, RESULTING IN LOW IDLING. TT
Too few reports in this category for a page of its own — they appear in the full complaint list.
Exterior lighting
Reports naming headlights, tail lights, turn signals and other exterior lighting.
From owner reports, verbatim
DATES ARE APPROXIMATE. HEADLIGHTS: BOTH LENS'S WERE FOGGED/YELLOWING LATER WHEN I WENT TO DEALER IN LEESBURG, VA (PATEROS); SERVICE MANAGE TRIED TO CLEAN.. MADE WORSE. THEN I REALIZED THAT LENS'S WERE PLASTIC! -- HIS CLEANING SOLUTION MELTED THAT PART OF THE LENS. I BELIEVE THAT THE HEADLIGHTS SHOULD LAST THE DURATION OF THE CAR'S LIFE. --THAT I SHOULD GET REPLACEMENTS AS THEY ARE A SAFETY FEATURE. ENGINE: A YEAR AND A HALF AGO ENGINE WILL EMIT BLACK SMOKE WHEN ON TREADMILL FOR EMISSIONS INSPECTION AND SMOKES WHITE WHEN I SIT FOR LENGTH OF TIME IDLING. THREE VALVES NEEDED TO BE REPLACED UNDER WARRANTY YEARS AGO -- I THINK THE ENGINE SHOULD NOT BE DOING THIS AT THIS POINT AND EITHER THE NOW DEFUNCT SERVICE DEPT DID IMPROPER JOB OR HAVE A DEFECTIVE ENGINE. I HAVE FOLLOWED REGULAR SCHEDULE FOR OIL CHANGES. PASSENGER SEAT: THE SPRINGS HAVE FALLEN APART COMPLETELY, I THOUGHT PERHAPS ONE OF MY KIDS DID IT YEARS AGO BUT WENT TO SEE ABOUT REPAIR AND WAS POINTED OUT THAT THE WHOLE SEAT FRAME/SPRINGS IS FALLING APART!
Too few reports in this category for a page of its own — they appear in the full complaint list.
Airbags
Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights.
From owner reports, verbatim
TL* THE CONTACT OWNS A 1991 MAZDA PROTEGE. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 45 MPH DURING RAIN WEATHER CONDITIONS, THE VEHICLE WENT OVER A POTHOLE CAUSING THE CONTACT TO LOSE CONTROL OF THE VEHICLE AND STOPPING ON THE SHOULDER OF THE ROAD. THE CONTACT THEN ATTEMPTED TO DRIVE AND THE VEHICLE SPUN CRASHING THE FRONT OF THE VEHICLE INTO A TREE. THE SEAT BELT DETACHED AND THE CONTACT WAS RELEASED FROM THE REAR WINDOW. THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS TOWED AND DEEMED DESTROYED. THE CONTACT RECEIVED KNEE, HEAD, AND BACK INJURIES WHICH REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000. UPDATED 03/15/16*LJ *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
REAR WHEELS INTERMITTENTLY LOCKS UP WHILE DRIVING; BURNING LIKE SMELL AFTER WHEELS LOCK UP. TT
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
VEHICLE SUDDENLY SHIFTED INTO FIRST GEAR WHILE GOING 65 MPH, 1ST GEAR MELTED ONTO THE SHAFT CAUSING GEAR TO STICK.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
THIRD TIRE OF SET OF 4 THAT TREAD HAD SEPARATED - THIS ONE TOTALED THE CAR AND INJURED ONE PERSON. TIRE HAD 18,000 MILES WEAR. *AK (TIRESIZE: P185/60R14)( DOT NUMBER: TIRE SIZE: P185/60R14 )
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .