2020 Mercedes-Benz GLE 450 Owner Complaints

My vehicle was in for a normal service to have the spark plugs replaced. However I was told that the engine wiring harness had become brittle (apparently a common and reoccurring problem with my vehicle) and would likely cause misfiring after changing spark plugs. This did indeed happen and if I didn’t elect to have the harness replaced, it would have put myself and my son in danger. It was a very costly repair (over $4000) for something that the vehicle manufacturer is at fault for.

NHTSA ID

11732609

Incident

Apr 18, 2026

Engine compartment heat causes wiring harness insulation to melt and Electrical shorting while driving. Engine has lack of power and acceleration due to heat damage to the engine harness. Check Engine light came on. This is a potential fire risk and should be address by MBUSA. This is a know issue with this model. Car has only 36,000 miles

NHTSA ID

11716779

Incident

Jan 19, 2026

The air conditioning in my 2020 Mercedes-Benz GLE SUV has failed due to a refrigerant (freon) leak, leaving the system unable to cool and properly defrost the windshield. This is not an isolated issue—many other GLE owners have reported the same failure on forums and blogs, suggesting a widespread defect. NHTSA has already issued Recall No. 23V177000 (March 2023) for improperly installed A/C drain hoses in 2020–2021 GLE/GLS models, which created water intrusion, electrical shorts, fire risk, and failures of critical systems (eCall, unlocking, limp mode). In addition, a Mercedes-Benz Technical Bulletin dated August 5, 2024 (NHTSA MC-11000597-0001) specifically identifies evaporator refrigerant leaks as a frequent cause of A/C failure. Safety Concerns Loss of cabin cooling in hot weather poses risk of driver fatigue or heat-related illness. Defogging/defrosting may fail in humid conditions, creating visibility hazards. Prior related A/C defects have been tied to short circuits and electrical risks. Consumer Impact This defect has created significant hardship. The A/C failure occurred far earlier than expected for a premium vehicle, leaving me with high out-of-pocket repair estimates. The lack of cooling makes the car unsafe and uncomfortable to drive in hot weather, and the inability to properly defog/defrost windows compromises visibility. I purchased a Mercedes-Benz with the expectation of reliability and safety, and this known defect has undermined that trust. Requested Action Mercedes-Benz should cover the repair costs for affected vehicles, and NHTSA should investigate whether an expanded recall is necessary to include A/C evaporator refrigerant leaks as part of the broader HVAC system defect.

NHTSA ID

11696116

Incident

Jul 15, 2025

Both left and right headlamp/turn signal/marker light assemblies and control modules have been replaced. One under warranty in 2023, the second in 2025. Infotainment system displays error messages Messages may increase as assembly/control module becomes increasingly dysfunctional.

NHTSA ID

11683243

Incident

Apr 30, 2025

The rear shock absorbers have failed on my vehicle. The vehicle makes sounds when going over bumps in the road. There is an active recall on other GLE 2020 450 models but not my specific VIN. The vehicle has less then 30,000 miles on it before the shock absorbers went out.

NHTSA ID

11672426

Incident

Jun 30, 2025

48V battery issue cause the car not able to drive.

NHTSA ID

11650369

Incident

Mar 24, 2025

Water intrusion. It rained, water leaked into driver seat floor. The water then made it to the electrical parts underneath the driver seat. This seems identical to the recall I am seeing online with the number: 23V-177

NHTSA ID

11628758

Incident

Nov 20, 2024

The contact owns a 2020 Mercedes-Benz GLE450. The contact stated while reversing, the rearview camera was inoperable. The message "Active parking Assist and Parktronic inoperative - See Operator's Manual" was displayed. The vehicle was taken to the dealer, where an unknown software update was performed; however, the failure persisted. The vehicle was taken back to the dealer, where it was diagnosed that an unknown wiring harness had experienced an electrical short due to water entry underneath the floorboard. The dealer informed the contact that the parts were not available for the repair. The vehicle was not repaired. The manufacturer was notified of the failure and confirmed that parts were not available. The failure mileage was 26,994.

NHTSA ID

11607283

Incident

Apr 28, 2024

Mileage

26,994 mi

This is a known issue with GLE 450 48v batteries over heating and causing loss of power and all function to control the vehicle. , For an unknown reason my vehicle was not part of a recent recall and probably should have been. I experienced the issue today and escaped tragedy. My battery light came on, then off, then a bright red battery light came on across the dashboard…then all of a sudden, my car lost all power with no warning. All while driving on the freeway 394! Luckily traffic was light and I was able to coast halfway up an off ramp. Then I got an overheating message. Reports show all cars were recalled, however mine wasn’t part of the recall!! I would like an investigation to include all cars in the years and models not just some of them.

NHTSA ID

11603504

Incident

Jul 19, 2024

This past week, I went to the dealer for an intermittent engine light issue. The problem was minor and was fixed (faulty charcoal sensor). I asked to have my spark plugs replaced as well. The service department called me, and said that the engine harness is brittle and if they accessed.. it could break. This was not considered an immediate issue. Quote was $7300 to replace it. This seemed like a defect rather than an standard wear issue (even though I drive a lot, @ 170K highway miles). My car drives like new, and has had no major issues whatsover. In fact, it is only now that I need to have my rotors replaced. Had I not mentioned that I wanted new spark plugs, the issue would not have came up during the service. I hope that you can look into this, as other Mercedes GLE 450 owners make have the same issue as I. Please do not hesitate to reach out to me. [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11583127

Incident

Apr 13, 2024

There were two incidents that had similar symptoms: one before the dealership said they fixed and one afterwards. The issue is that while driving I would get three warning, all at the same time: coolant too hot, 48v battery malfunction, shut the engine off. The first time it happened immediately after I turned on the vehicle and within 5 minutes of leaving a parking lot. The second time it happened after about 3 hours of driving at highway speeds. After the first time it happened dealership said they fixed the issue by upgrading the software (battery software?). Both times it happened on the highway. The first time on the uphill, and vehicle immediately shut off and could not make it up the ramp. The second time in the tunnel on the flat road, could not make it to the exit. Both times created extremely dangerous situation as I had no time to take the exit and vehicle shut off about 30 seconds after warning popped up. The second time in the tunnel was especially dangerous as there was no shoulder and i had to stop in the middle of the right lane as cars were going at 60 mph by me. I was really worried for myself and my family. I have to trust that Mercedes is capable of fixing the issue and providing a reliable vehicle I can depend on and trust for the safety of my family.

NHTSA ID

11575432

Incident

Mar 3, 2024

The contact owns a 2020 Mercedes-Benz GLE450. The contact stated that while the vehicle was idling in traffic, the check engine and battery warning lights illuminated along with the message to "Do not Drive Vehicle". The vehicle was towed to the local dealer who diagnosed and determined that the fuel tank and fuel delivery module was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 19V572000 (Fuel System, Gasoline). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 29,201.

NHTSA ID

11562001

Incident

Dec 15, 2023

Mileage

29,201 mi

I receive a passenger airbag warning message every time I start the vehicle. Took to Mercedes dealer 2/10/2023 and they diagnosed the airbag problem as being caused due to the failure of the weight sensor in the passenger seat. NO ETA on a part to fix the weight sensor in the seat and was given the vehicle back to drive as normal, despite the passenger airbag being disabled (vehicle is still under factory warranty period). Have returned the vehicle to the dealer again on 4/20/2023 and 5/30/3023 to try and expedite a fix but both times was told there was no ETA on a part to fix the weight sensor in the seat and was given the vehicle back to drive as normal, despite the passenger airbag being disabled. I opened an escalation with Mercedes Benz USA (ERM - Executive Referral Management team) on 7/7/2023 and they called the Mercedes dealer to confirm the airbag issue and tie to the bad weight sensor in the seat. The dealer re-confirmed with Mercedes Benz USA that they do not have an ETA to fix the passenger seat weight sensor, hence no way to fix the airbag malfunction. As I submit this on 8/14/2023 I still do not have a functioning passenger airbag and no ETA to get this issue resolved, despite trying for over 6 months. This has and continues to pose an incredible safety concern for passengers that ride in this vehicle as the airbag won't deploy if in an accident. Another unintended consequence is that the chime/ding to remind passengers to fasten their seat belt is disabled as it's also tied to the malfunctioning weight sensor in the seat. This is my only vehicle and I don't have any alternatives given I cannot sell this vehicle without a working airbag.

NHTSA ID

11538406

Incident

Feb 10, 2023

1. After coming to a stop, foot placed on the pedal to accelerate through a neighborhood security gate, the car would not accelerate despite how hard I depressed the gas pedal. After approximately 3-4 seconds the car finally accelerated. 2. When coming to a stop the vehicle has a very hard “clunk” in the transmission to stop. Vehicle was taken to the dealership but they could not replicate the problem at the time so car was given back to me with “non replicable” issues.

NHTSA ID

11488292

Incident

Oct 5, 2022

1. FIRST MESSAGE: 48V BATTERY MALFUNCTION 2. SECOND MESSAGE: STOP THE VEHICLE COOLANT IS NOT WORKING VEHICLE IS OVERHEATING. 3. LOST POWER, I COULD ONLY DRIVE 10 MILES PER HOUR. I PULLED TO THE SIDE OF THE ROAD AND WAS ALMOST REAR ENDED BY A SEMI TRUCK. THERE ARE SEVERAL ONLINE OCCURRENCES REPORTING THESE SAME MESSAGES. IT IS EXTREMELY DANGEROUS WHEN A VEHICLE LOSES ALL POWER WHILE ON A BUSY HIGHWAY. THE VEHICLE WAS INSPECTED. MERCEDES AWARE OF A BULLETIN WITH THIS ISSUE.

NHTSA ID

11476213

Incident

Jul 21, 2022

The tire tread on the Cooper 275/50R20 tires was worn down almost completely after 16,000 miles. The tires are the original tires that the vehicle was purchased with and are rated to 50,000 miles. When the dealer serviced the vehicle, they noted that the tires were not safe to drive on due to there being almost no tread left at just 16,000 miles. They also stated that they had seen multiple cars with the same Cooper tires that lasted only 10,000-16,000 miles despite being rated to 50,000 miles. They also indicated that Cooper has taken 6+ months to respond to requests for replacement tires under the warranty and vehicle owners have had to go out of pocket to buy replacement tires themselves since the worn out tires are unsafe to drive on and they can't wait 6+ months for a response from the manufacturer with replacement tires. Additionally, they flagged that the tires are dangerous since most vehicle owners don't check their tires after only 10,000-16,000 miles and have no idea that they are driving on tires with little to no tread that could fail at any time. The tires have been saved by the dealership and are available for inspection. Additionally, there is a video documenting the tires while still on the vehicle. These tires should be recalled for defective wear and Cooper held accountable for failing to acknowledge and fix this huge safety issue.

NHTSA ID

11468794

Incident

May 13, 2022

The contact owns a 2020 Mercedes-Benz GLE450. The contact received notification of NHTSA Campaign Number: 21V354000 (Back Over Prevention, Electrical System) however, the over-the-air software update was not yet available. The local dealer was contacted and it was confirmed that the software update was not yet available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11451827

Incident

Feb 1, 2022

48 V BATTERY MALFUNCTIONED, I WAS ADVISED THAT IT WAS NOT CHARGING. WHICH LED TO ADDITIONAL MESSAGES INCLUDING THE CAR WAS NOW OVERHEATING, TO PULL THE CAR OVER AND NOT DRIVE IT. AT THAT POINT I LOST ENGINE POWER AND WAS UNABLE TO EVEN DRIVE THE CAR UP A SLIGHT HIM.

NHTSA ID

11449255

Incident

Jan 15, 2022

The contact leased a 2020 Mercedes-Benz GLE450. The contact stated that while driving at various speeds and yielding to make a right turn, the vehicle would shut off with several warning lights illuminated. The contact also stated that the “Active blind spot assist inoperable" and "Inoperable - See Owner’s Manual" appeared on the instrument panel. The contact had taken the vehicle to the dealer on several occasions however, the dealer was unable to duplicate the failure. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 5,000

NHTSA ID

11437650

Incident

Jan 1, 2021

Mileage

5,000 mi

THE VEHICLE HAS A FAILED REAR SEATBELT - DEALERSHIP ADVISED THAT NO PARTS ARE AVAILABLE TILL MID JUNE 2021. IN THE MEANTIME DAIMLER ON THEIR Q1 FOR INVESTORS ADVISED THAT THEY DID RECORD NEW SALES AND PRODUCTION NUMBERS, SO LACK OF PARTS IS NOT BECAUSE OF NOT ENOUGH PARTS BUY BECAUSE OF OVER PRODUCTION

NHTSA ID

11413991

Incident

Apr 20, 2021

Mileage

10,000 mi

THE CAR IS EQUIPPED WITH POWER SEATS ON THE SECOND ROW. MY 2 YEAR OLD SON FIGURED OUT HOW TO USE HIS RIGHT FOOT TO MOVE THE SEAT FORWARD AND BACKWARD WHILE TRAVELING 65 MPH ON I-95. THIS CAUSED HIS TETHERED CAR SEAT TO SLIGHTLY PIVOT BECAUSE THE RIGHT SEAT RUBBED AGAINST THE MIDDLE SEAT. I CALLED MB USA IN GEORGIA TO REPORT. THEY SAID THERE WAS NO POSSIBLE WAY TO LOCK THE CONTROL SO KIDS CAN'T MOVE THE SEATS. THEY TOLD ME MY ONLY OPTION WAS TO MOVE CHILD TO MIDDLE SEAT, WHICH WON'T WORK WHEN MULTIPLE YOUNG CHILDREN ARE IN THE CAR. THIS IS DANGEROUS AND AN ACCIDENT WAITING TO HAPPEN. IF RECOMMENDED I CAN ALSO POST ON SOCIAL MEDIA SO THAT PARENTS WITH YOUNG CHILDREN ARE AWARE. I ASKED MB TO BUY BACK THE CAR SINCE THIS IS A SAFETY HAZARD BUT THEY DECLINED.

NHTSA ID

11390021

Incident

Jan 2, 2021

Mileage

11,000 mi

I WAS TRAVELLING ON HIGHWAY WITH ADAPTIVE CRUISE CONTROL ON. WHEN NEAR THE EXIT, I PRESS THE OFF BUTTON FOR THE CRUISE CONTROL. TO MY SURPRISE, THE CAR DIDN'T SLOW DOWN, AND INSTEAD MAINTAIN THE ENGINE POWER TO KEEP THE CAR IN SET SPEED. I TRIED THE OTHER SETTINGS (OFF, CANCEL, SPEED DOWN) OPTION BUT NOTHING IS RESPONSIVE. SINCE I AM ON THE OFF RAMP ALREADY, I HAVE TO STEP ON THE BRAKE (THIS DOES FINALLY STOP THE CRUISE CONTROL) TO SLOW DOWN THE CAR. AFTER I COME TO A STOP AT THE STOP LIGHT, I NOTICE THAT THE AR VIEW CAMERA HAS A CONDENSATION IN THE CENTER OF THE CAMERA LENS (SEE FIRST PICTURE WITH 11/10 DATE). AT THE SAME TIME, MULTIPLE WARNING MESSAGE APPEAR ON DASH, INCLUDING "ADAPTIVE CRUISE CONTROL INOPERATIVE", "ACTIVE LANE KEEP ASSIST INOPERATIVE", AND A FEW OTHERS. THE CRUISE CONTROL INDICATOR REMAIN ON AND ACTIVE ON THE DASH (BUT SYSTEM ISN'T WORKING) UNTIL I GOT TO A SAFE LOCATION TO RESTART THE CAR. ALL ERROR MESSAGE WAS CLEARED AFTERWARD. A FEW DAYS LATER (11/16), I HAD THE CAR AT THE DEALER FOR INSPECTION. I MENTIONED THE ISSUE BUT THEY SAID THEY ARE UNABLE TO FIND ANYTHING WRONG AND CAMERA LENS WAS CLEARED AT THAT TIME. AFTER I GOT HOME, I NOTICE THERE ARE CONDENSATION AGAIN ON THE CAMERA LENS (SEE SECTION PICTURE WITH 11/16 DATE).

NHTSA ID

11376864

Incident

Nov 10, 2020

Mileage

5,300 mi

WARNING LIGHT "COOLANT TOO HOT SHUT ENGINE OFF" COMES ON REPEATEDLY AND THIS IS UNABLE TO BE FIXED. LIGHT COMES ON WHILE VEHICLE IS IN MOTION. WAS TOLD BY MERCEDES THIS WAS A FAULTY WARNING LIGHT. YESTERDAY THIS CAME ON AND MY ENGINE SHUT ITSELF OFF WHILE THE VEHICLE WAS IN MOTION ON A BUSY STREET. I WAS ALMOST HIT BY ANOTHER VEHICLE AS I LOST POWER TO THE CAR ON A MAIN ROAD. I BARELY ROLLED INTO A PARKING LOT. COULD HAVE BEEN A HORRIBLE (FATAL) DISASTER HAD I BEEN ON THE FREEWAY. "MALFUNCTION" "SEE OPERATOR'S MANUAL" AND "48V BATTERY SEE OPERATORS MANUAL" ALL CAME ON WITHIN RAPID SUCCESSION BEFORE THE ENGINE SHUT OFF ON ME.

NHTSA ID

11365446

Incident

Oct 19, 2020

Mileage

6,600 mi

SUDDEN ACCELERATION - ELECTRICAL SYSTEM FAILURES- 1) 03/21/20 COMPLETE ELECTRICAL FAILURE - ALL WARNING LIGHTS, EXTERIOR LIGHTS & BRAKE LIGHTS STUCK ON, THEN WOULD NOT START AFTER LOCAL SHOPPING TRIP-ODOMETER 754 MILES - VEHICLE TOWED TO DEALER - 'REPROGRAMMED'. 2) 06/18/20 ACTIVE SPEED CONTROL-CRUISE CONTROL (WHICH READS SPEED LIMIT SIGNS AND ADJUSTS SPEED) WAS SET AT 50 MPH - SUDDENLY BEGAN TO ACCELERATE TO 80 MPH. ODOMETER 1641 MILES. 3) ACTIVE SPEED LIMIT CONTROL OFTEN READS FRONTAGE ROAD SPEED LIMIT SIGNS WHILE ON MAIN HIGHWAY, INITIATING BRAKING. 4) ACTIVE SPEED CONTROL WHEN ON CRUISE CONTROL WILL APPLY BRAKES WHEN USING TURN SIGNAL FOR LANE CHANGES. 08/31/20-09/04/2020 RETURNED TO DEALER- ODOMETER 2361-'REPROGRAMMED'. 5) 09/19/20 ACTIVE SPEED LIMIT CONTROL SET AT 15 MPH SUDDENLY BEGAN TO ACCELERATE TO 80 MPH. ODOMETER 2512. WAS ABLE TO REGAIN CONTROL BY BRAKE APPLICATION TO RELEASE CRUISE CONTROL AFTER VEHICLE INITIATED HARD ACCELERATION WITHOUT ANY DRIVER INPUT AND HAD REACHED 30-35 MPH. SAME AS 06/18/20 SIMILAR INCIDENT. DEALER WAS ADVISED AND 'UPDATED SOFTWARE' MERCEDES BENZ-GRAPEVINE, TX INVOICE 511097. MERCEDES GLE 450 DATE OF MFG. 10JAN2020 - LEASED 25JAN 2020.

NHTSA ID

11360596

Incident

Sep 19, 2020

Mileage

2,512 mi

DRIVING DOWN THE HIGHWAY AT 70 MPH AND '48V BATTERY MALFUNCTION' WARNING GOES OFF, ALONG WITH A YELLOW CHECK ENGINE LIGHT. A FEW SECONDS LATER A 'COOLANT' ERROR MESSAGE POPS UP AND A RED CHECK ENGINE LIGHT COMES ON. CAR LOOSES POWER COMPLETELY AND I'M UNABLE TO ACCELERATE AT ALL. CALL FLASHES A MESSAGE OF 'PULL OVER AND TURN THE ENGINE OFF'. FORTUNATELY NO ONE WAS BEHIND ME AND I WAS ABLE TO COAST SAFELY TO THE SIDE OF THE HIGHWAY BEFORE THE CAR STALLED COMPLETELY. FOUND OUT THROUGH SEVERAL BLOG POSTS MULTIPLE OTHER 2020 GLE OWNERS ARE HAVING THE SAME SAFETY ISSUE AND THERE HAS BEEN NO RECALL BY MERCEDES-BENZ AND NO RESOLUTION FOR THE ISSUE. VEHICLES ARE SPENDING MONTHS IN THE SHOP AND EVENTUALLY BEING BOUGHT BACK BY THE MANUFACTURER OR DEALERSHIP. THIS IS AN INCREDIBLY DANGEROUS ISSUE TO LOSE ALL POWER AND CONTROL OF THE VEHICLES SPEED. I'M LUCKY NO ONE WAS ON THE ROAD NEAR ME WHEN THIS HAPPENED, OTHERWISE AN ACCIDENT ALMOST SURELY WOULD HAVE OCCURRED. MERCEDES SHOULD BE FORCED TO ADDRESS THIS SAFETY ISSUE IMMEDIATELY.

NHTSA ID

11352040

Incident

Aug 29, 2020

Mileage

4,900 mi