2020 Mercedes-Benz GLE 450 Problems

My vehicle was in for a normal service to have the spark plugs replaced. However I was told that the engine wiring harness had become brittle (apparently a common and reoccurring problem with my vehicle) and would likely cause misfiring after changing spark plugs. This did indeed happen and if I didn’t elect to have the harness replaced, it would have put myself and my son in danger. It was a very costly repair (over $4000) for something that the vehicle manufacturer is at fault for.

Engine compartment heat causes wiring harness insulation to melt and Electrical shorting while driving. Engine has lack of power and acceleration due to heat damage to the engine harness. Check Engine light came on. This is a potential fire risk and should be address by MBUSA. This is a know issue with this model. Car has only 36,000 miles

The contact owns a 2020 Mercedes-Benz GLE450. The contact stated while reversing, the rearview camera was inoperable. The message "Active parking Assist and Parktronic inoperative - See Operator's Manual" was displayed. The vehicle was taken to the dealer, where an unknown software update was performed; however, the failure persisted. The vehicle was taken back to the dealer, where it was diagnosed that an unknown wiring harness had experienced an electrical short due to water entry underneath the floorboard. The dealer informed the contact that the parts were not available for the repair. The vehicle was not repaired. The manufacturer was notified of the failure and confirmed that parts were not available. The failure mileage was 26,994.

This is a known issue with GLE 450 48v batteries over heating and causing loss of power and all function to control the vehicle. , For an unknown reason my vehicle was not part of a recent recall and probably should have been. I experienced the issue today and escaped tragedy. My battery light came on, then off, then a bright red battery light came on across the dashboard…then all of a sudden, my car lost all power with no warning. All while driving on the freeway 394! Luckily traffic was light and I was able to coast halfway up an off ramp. Then I got an overheating message. Reports show all cars were recalled, however mine wasn’t part of the recall!! I would like an investigation to include all cars in the years and models not just some of them.

My vehicle was in for a normal service to have the spark plugs replaced. However I was told that the engine wiring harness had become brittle (apparently a common and reoccurring problem with my vehicle) and would likely cause misfiring after changing spark plugs. This did indeed happen and if I didn’t elect to have the harness replaced, it would have put myself and my son in danger. It was a very costly repair (over $4000) for something that the vehicle manufacturer is at fault for.

Engine compartment heat causes wiring harness insulation to melt and Electrical shorting while driving. Engine has lack of power and acceleration due to heat damage to the engine harness. Check Engine light came on. This is a potential fire risk and should be address by MBUSA. This is a know issue with this model. Car has only 36,000 miles

I receive a passenger airbag warning message every time I start the vehicle. Took to Mercedes dealer 2/10/2023 and they diagnosed the airbag problem as being caused due to the failure of the weight sensor in the passenger seat. NO ETA on a part to fix the weight sensor in the seat and was given the vehicle back to drive as normal, despite the passenger airbag being disabled (vehicle is still under factory warranty period). Have returned the vehicle to the dealer again on 4/20/2023 and 5/30/3023 to try and expedite a fix but both times was told there was no ETA on a part to fix the weight sensor in the seat and was given the vehicle back to drive as normal, despite the passenger airbag being disabled. I opened an escalation with Mercedes Benz USA (ERM - Executive Referral Management team) on 7/7/2023 and they called the Mercedes dealer to confirm the airbag issue and tie to the bad weight sensor in the seat. The dealer re-confirmed with Mercedes Benz USA that they do not have an ETA to fix the passenger seat weight sensor, hence no way to fix the airbag malfunction. As I submit this on 8/14/2023 I still do not have a functioning passenger airbag and no ETA to get this issue resolved, despite trying for over 6 months. This has and continues to pose an incredible safety concern for passengers that ride in this vehicle as the airbag won't deploy if in an accident. Another unintended consequence is that the chime/ding to remind passengers to fasten their seat belt is disabled as it's also tied to the malfunctioning weight sensor in the seat. This is my only vehicle and I don't have any alternatives given I cannot sell this vehicle without a working airbag.

THE CAR IS EQUIPPED WITH POWER SEATS ON THE SECOND ROW. MY 2 YEAR OLD SON FIGURED OUT HOW TO USE HIS RIGHT FOOT TO MOVE THE SEAT FORWARD AND BACKWARD WHILE TRAVELING 65 MPH ON I-95. THIS CAUSED HIS TETHERED CAR SEAT TO SLIGHTLY PIVOT BECAUSE THE RIGHT SEAT RUBBED AGAINST THE MIDDLE SEAT. I CALLED MB USA IN GEORGIA TO REPORT. THEY SAID THERE WAS NO POSSIBLE WAY TO LOCK THE CONTROL SO KIDS CAN'T MOVE THE SEATS. THEY TOLD ME MY ONLY OPTION WAS TO MOVE CHILD TO MIDDLE SEAT, WHICH WON'T WORK WHEN MULTIPLE YOUNG CHILDREN ARE IN THE CAR. THIS IS DANGEROUS AND AN ACCIDENT WAITING TO HAPPEN. IF RECOMMENDED I CAN ALSO POST ON SOCIAL MEDIA SO THAT PARENTS WITH YOUNG CHILDREN ARE AWARE. I ASKED MB TO BUY BACK THE CAR SINCE THIS IS A SAFETY HAZARD BUT THEY DECLINED.

The rear shock absorbers have failed on my vehicle. The vehicle makes sounds when going over bumps in the road. There is an active recall on other GLE 2020 450 models but not my specific VIN. The vehicle has less then 30,000 miles on it before the shock absorbers went out.

The tire tread on the Cooper 275/50R20 tires was worn down almost completely after 16,000 miles. The tires are the original tires that the vehicle was purchased with and are rated to 50,000 miles. When the dealer serviced the vehicle, they noted that the tires were not safe to drive on due to there being almost no tread left at just 16,000 miles. They also stated that they had seen multiple cars with the same Cooper tires that lasted only 10,000-16,000 miles despite being rated to 50,000 miles. They also indicated that Cooper has taken 6+ months to respond to requests for replacement tires under the warranty and vehicle owners have had to go out of pocket to buy replacement tires themselves since the worn out tires are unsafe to drive on and they can't wait 6+ months for a response from the manufacturer with replacement tires. Additionally, they flagged that the tires are dangerous since most vehicle owners don't check their tires after only 10,000-16,000 miles and have no idea that they are driving on tires with little to no tread that could fail at any time. The tires have been saved by the dealership and are available for inspection. Additionally, there is a video documenting the tires while still on the vehicle. These tires should be recalled for defective wear and Cooper held accountable for failing to acknowledge and fix this huge safety issue.

The contact leased a 2020 Mercedes-Benz GLE450. The contact stated that while driving at various speeds and yielding to make a right turn, the vehicle would shut off with several warning lights illuminated. The contact also stated that the “Active blind spot assist inoperable" and "Inoperable - See Owner’s Manual" appeared on the instrument panel. The contact had taken the vehicle to the dealer on several occasions however, the dealer was unable to duplicate the failure. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 5,000

I receive a passenger airbag warning message every time I start the vehicle. Took to Mercedes dealer 2/10/2023 and they diagnosed the airbag problem as being caused due to the failure of the weight sensor in the passenger seat. NO ETA on a part to fix the weight sensor in the seat and was given the vehicle back to drive as normal, despite the passenger airbag being disabled (vehicle is still under factory warranty period). Have returned the vehicle to the dealer again on 4/20/2023 and 5/30/3023 to try and expedite a fix but both times was told there was no ETA on a part to fix the weight sensor in the seat and was given the vehicle back to drive as normal, despite the passenger airbag being disabled. I opened an escalation with Mercedes Benz USA (ERM - Executive Referral Management team) on 7/7/2023 and they called the Mercedes dealer to confirm the airbag issue and tie to the bad weight sensor in the seat. The dealer re-confirmed with Mercedes Benz USA that they do not have an ETA to fix the passenger seat weight sensor, hence no way to fix the airbag malfunction. As I submit this on 8/14/2023 I still do not have a functioning passenger airbag and no ETA to get this issue resolved, despite trying for over 6 months. This has and continues to pose an incredible safety concern for passengers that ride in this vehicle as the airbag won't deploy if in an accident. Another unintended consequence is that the chime/ding to remind passengers to fasten their seat belt is disabled as it's also tied to the malfunctioning weight sensor in the seat. This is my only vehicle and I don't have any alternatives given I cannot sell this vehicle without a working airbag.

The air conditioning in my 2020 Mercedes-Benz GLE SUV has failed due to a refrigerant (freon) leak, leaving the system unable to cool and properly defrost the windshield. This is not an isolated issue—many other GLE owners have reported the same failure on forums and blogs, suggesting a widespread defect. NHTSA has already issued Recall No. 23V177000 (March 2023) for improperly installed A/C drain hoses in 2020–2021 GLE/GLS models, which created water intrusion, electrical shorts, fire risk, and failures of critical systems (eCall, unlocking, limp mode). In addition, a Mercedes-Benz Technical Bulletin dated August 5, 2024 (NHTSA MC-11000597-0001) specifically identifies evaporator refrigerant leaks as a frequent cause of A/C failure. Safety Concerns Loss of cabin cooling in hot weather poses risk of driver fatigue or heat-related illness. Defogging/defrosting may fail in humid conditions, creating visibility hazards. Prior related A/C defects have been tied to short circuits and electrical risks. Consumer Impact This defect has created significant hardship. The A/C failure occurred far earlier than expected for a premium vehicle, leaving me with high out-of-pocket repair estimates. The lack of cooling makes the car unsafe and uncomfortable to drive in hot weather, and the inability to properly defog/defrost windows compromises visibility. I purchased a Mercedes-Benz with the expectation of reliability and safety, and this known defect has undermined that trust. Requested Action Mercedes-Benz should cover the repair costs for affected vehicles, and NHTSA should investigate whether an expanded recall is necessary to include A/C evaporator refrigerant leaks as part of the broader HVAC system defect.

The contact owns a 2020 Mercedes-Benz GLE450. The contact stated that while the vehicle was idling in traffic, the check engine and battery warning lights illuminated along with the message to "Do not Drive Vehicle". The vehicle was towed to the local dealer who diagnosed and determined that the fuel tank and fuel delivery module was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 19V572000 (Fuel System, Gasoline). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 29,201.

Both left and right headlamp/turn signal/marker light assemblies and control modules have been replaced. One under warranty in 2023, the second in 2025. Infotainment system displays error messages Messages may increase as assembly/control module becomes increasingly dysfunctional.

THE VEHICLE HAS A FAILED REAR SEATBELT - DEALERSHIP ADVISED THAT NO PARTS ARE AVAILABLE TILL MID JUNE 2021. IN THE MEANTIME DAIMLER ON THEIR Q1 FOR INVESTORS ADVISED THAT THEY DID RECORD NEW SALES AND PRODUCTION NUMBERS, SO LACK OF PARTS IS NOT BECAUSE OF NOT ENOUGH PARTS BUY BECAUSE OF OVER PRODUCTION