2002 Mercedes-Benz ML320 Engine Problems

TL* THE CONTACT OWNS A 2002 MERCEDES-BENZ ML320. THE CONTACT STATED THAT THE AIR CONDITIONER FAILED TO TURN OFF WHEN THE ENGINE WAS TURNED OFF. THE CONTACT ALSO STATED THAT THE VEHICLE WAS DIFFICULT TO START. THE CONTACT PURCHASED AND INSTALLED A NEW ALTERNATOR; HOWEVER, THE VEHICLE FAILED TO START. THE BATTERY WAS ALSO REPLACED, BUT THE ENGINE STILL TOOK SEVERAL ATTEMPTS TO START. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT SCHEDULED AN APPOINTMENT WITH PRIME TIME NISSAN OF SCHERERVILLE (1301 INDIANAPOLIS BLVD, SCHERERVILLE, IN 46375) FOR DIAGNOSTIC TESTING AND REPAIRS. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ID

11102413

Incident

Jun 12, 2018

I WAS PULLING AWAY FROM THE CURB, STEERING WHEEL STARTED MAKING WHINING NOISES AND HARDER TO TURN. I CONTINUED ON CITY STREETS THEN TO A FREEWAY WHERE MY CAR BEGAN TO OVERHEAT. I PULLED OVER AT A GAS STATION OPENED THE HOOD AND COULD SEE FLUID ALL OVER RIGHT LOWER DRIVER SIDE. IT SEEMED TO BE COMING FROM A HOSE BY THE POWER STEERING CAP AND THE RIGHT SIDE OF THE RADIATOR. UNDER THE CAR SAME SPOT RIGHT PASSENGER SIDE I COULD SEE POWER STEERING AND RADIATOR COOLANT LEAKING FROM THAT AREA.

NHTSA ID

10966233

Incident

Mar 10, 2017

Mileage

200,000 mi

TL* THE CONTACT OWNS A 2002 MERCEDES-BENZ ML320. THE CONTACT STATED THAT THE VEHICLE WAS RIDING EXTREMELY ROUGH AND FAILED TO ACCELERATE. THE VEHICLE WAS DIAGNOSED BY TWO INDEPENDENT MECHANICS WHO STATED THAT THE CATALYTIC CONVERTER NEEDED TO BE REPLACED. IN ADDITION, THE VEHICLE WAS TAKEN TO A DEALER WHO STATED THAT THE PART WAS NO LONGER IN PRODUCTION AND THAT THE CONTACT MAY REPLACE THE PART WITH AN AFTERMARKET CATALYTIC CONVERTER; HOWEVER, THE VEHICLE MAY NOT PASS AN EMISSIONS INSPECTION. THE CATALYTIC CONVERTER FAILED ON THE FRONT PASSENGER SIDE AND THE CONTACT WAS UNCERTAIN OF WHO WOULD BE ABLE TO REPLACE THE PART WITH AN OEM CATALYTIC CONVERTER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS WAITING FOR THEM TO DETERMINE A SOLUTION TO REPAIR THE VEHICLE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

NHTSA ID

10957858

Incident

Mar 1, 2017

Mileage

150,000 mi

DRIVING HOME ON A LOCAL STREET AT ABOUT 30 MILES PER HOUR, APPROACHING INTERSECTION, TRYING TO TURN, ALL THE SUDDEN, STEERING WHEEL BECAME VERY HARD TO TURN, WITH NO ASSISTING POWER, CAR RUN OVER TO THE OTHER SIDE OF THE ROAD, ALMOST CRASH INTO CURB. IT IS VERY LUCKY, THERE IS NO INCOMING CARS, WOULD HAVE CRASH HEAD ON OTHERWISE. CAR TOWED TO DEALER, FOUND STEERING HOSE FROM RADIATOR TO STEERING RACK BROKEN OFF, STEERING FLUID SPLATTING ALL OVER ENGINE. DEALER STATED NO RECALL FOR STEERING HOSE COMING OUT OF RADIATOR, BUT THERE WAS RECALL ON STEERING HOSE COMING OUT OF PUMP. SO THIS DEFECT WAS NOT COVERED. I URGE NHTSA TO INVESTIGATE THIS DANGEROUS DEFECT IMMEDIATELY, AND ISSUE RECALL TO SAVE LIVES. *TR

NHTSA ID

10509207

Incident

Apr 1, 2013

Mileage

98,224 mi

2002 MERCEDES-BENZ ML320. CONSUMER IS HAVING SOME WARRANTY REPAIR PROBLEMS WITH MERCEDES-BENZ. HE ALSO STATES THAT MERCEDES-BENZ IS REFUSING TO PAY FOR ANY RECALL REPAIRS. *KB THE CONSUMER STATED NOISES AND LACK OF POWER FROM THE VEHICLE WERE REPORTED TO THE DEALER. AN INDEPENDENT REPAIR SHOP FOUND DIRTY SOLID METAL RESIDUE IN THE TRANSMISSION FLUID, THERE WERE MISSING PARTS IN THE PLANETARY GEAR. THE CAUSE OF DAMAGE WAS FAULTY ASSEMBLY OF THE PINS/PLUGS IN THE GEARS, WHICH RESULTED IN THE PARTS BECOMING LOOSE AND BREAKING THE TEETH, WHICH CAUSED EXCESSIVE NOISE AND LOSS OF POWER, ULTIMATELY THE TRANSMISSION WAS REPLACED. THE POWER STEERING WAS LEAKING, THE BRAKE AND ENGINE LIGHTS ILLUMINATED SEVERAL TIMES, THE CATALYTIC CONVERTER WAS REPLACED, THE DOOR LOCKS HAD TO BE REPAIRED, THE BATTERY WAS REPLACED AND THE SWAY BAR LINK BUSHING WERE REPLACED AS WELL. *JB UPDATED 06/01/10.*JB UPDATED 06/04/10.*JB UPDATED 10/18/10*JB UPDATED 10/29/10*JB

NHTSA ID

10323089

Incident

Aug 14, 2006

TL* THE CONTACT OWNS A 2002 MERCEDES BENZ ML320. WHILE DRIVING UP A HILL THE VEHICLE BEGAN TO ACCELERATE VERY SLOWLY. HE PULLED OVER TO THE SIDE OF THE ROAD, OPENED THE HOOD, AND NOTICED SMOKE. WITHIN A FEW SECONDS, THE VEHICLE CAUGHT ON FIRE. HE WILL CONTACT THE MANUFACTURER. THE INSURANCE COMPANY WAS NOTIFIED. THE CURRENT AND FAILURE MILEAGES WERE 76,000. THE VIN WAS NOT AVAILABLE.

NHTSA ID

10297417

Incident

Dec 25, 2009

Mileage

76,000 mi

TL*THE CONTACT OWNS A 2002 MERCEDES BENZ ML320. WHILE DRIVING LESS THAN 70 MPH, THE FRONT PASSENGER SIDE BRAKE LOCKED UP AND CAUSED THE VEHICLE TO SWERVE INTO A MEDIAN. THE ABS WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL AT THE SAME TIME THE BRAKES LOCKED. THE CONTACT NEVER DEPRESSED THE BRAKE PEDAL NOR THE ACCELERATOR PEDAL FOR THE BRAKES TO LOCK. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT THE YAW RATE SENSOR FAILED. THE REPAIRS WERE SCHEDULED UNDER WARRANTY. THE FAILURE AND CURRENT MILEAGES WERE 63,000. UPDATED 02/05/09 *BF THE BAS/ESP LIGHT ILLUMINATED. THE CATALYTIC CONVERTER WAS CRACKED AND THE TRANSMISSION ELECTRICAL CONNECTOR WAS LEAKING.. UPDATED 02/06/09.*JB

NHTSA ID

10254094

Incident

Jan 3, 2009

Mileage

63,000 mi

OIL SENSOR WARNING INDICATOR ILLUMINATED, AND VEHICLE WAS CONSUMING A QUART OF OIL EVERY THREE DAYS. VEHICLE WAS TAKEN TO THE DEALER, WHO DETERMINED THAT ENGINE MUST BE REPLACED. *AK

NHTSA ID

10061714

Mileage

29,000 mi