2004 Mercedes-Benz Sl Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2004 Mercedes-Benz Sl, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Fuel system133.3%
- Steering133.3%
- Suspension133.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
A POUNDING NOISE (LIKE A HAMMER HITTING A 2X4) OCCURRED REPEATEDLY WHENEVER I STARTED OR STOPPED. IT TURNED OUT TO BE A FAILURE OF THE BAFFLES INSIDE THE GAS TANK AND REQUIRED A REPLACEMENT OF THE GAS TANK AT A COST OF OVER $2000. THIS IS CLEARLY A DEFECT IN MATERIALS OR WORKMANSHIP AND SHOULD BE THE SUBJECT OF A RECALL. THE BAFFLES SLIDING AROUND THE TANK WOULD ULTIMATELY CAUSE IT TO LEAK IF THE TANK WERE NOT REPLACED. THE DEALER WOULD NOT PAY FOR THE REPLACEMENT. IT HAS APPARENTLY OCCURRED ON MANY MERCEDES CARS ACCORDING TO THE INTERNET REPORTS. *JS
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
WHILE DRIVING 30MPH, SUDDENLY THE CAR STARTED ROCKING FROM SIDE TO SIDE. I HELD THE STEERING WHEEL FIRMLY, BUT THE CAR STARTED MOVING TO THE RIGHT, SO I STOPPED THE CAR AND TURNED OFF THE ENGINE. IT APPEARED TO BE A SUSPENSION PROBLEM. WHEN I RESTARTED THE CAR, IT WAS OKAY. WITHIN A WEEK OR SO, THE SAME THING HAPPENED, AGAIN. LUCKILY, BOTH TIMES, I WAS DRIVING LOCALLY AT A LOW SPEED, RATHER THAN AT A HIGH SPEED ON THE FREEWAY, WHERE THE SPEED LIMIT IS 65MPH. *JS
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
WHILE DRIVING 30MPH, SUDDENLY THE CAR STARTED ROCKING FROM SIDE TO SIDE. I HELD THE STEERING WHEEL FIRMLY, BUT THE CAR STARTED MOVING TO THE RIGHT, SO I STOPPED THE CAR AND TURNED OFF THE ENGINE. IT APPEARED TO BE A SUSPENSION PROBLEM. WHEN I RESTARTED THE CAR, IT WAS OKAY. WITHIN A WEEK OR SO, THE SAME THING HAPPENED, AGAIN. LUCKILY, BOTH TIMES, I WAS DRIVING LOCALLY AT A LOW SPEED, RATHER THAN AT A HIGH SPEED ON THE FREEWAY, WHERE THE SPEED LIMIT IS 65MPH. *JS
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .