2003 Mercedes-Benz SL500 Problems

The contact owns a 2003 Mercedes-Benz SL500. The contact stated while driving at various speeds, the ABC warning light illuminated. Additionally, the message "Drive Carefully" was displayed. The vehicle was taken to an independent mechanic, where it was diagnosed that the ABC tandem pump, struts, and hoses needed to be replaced. The dealer was notified of the failure and informed the contact that they did not provide service for older vehicles. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 88,000.

ABC (Active Body Control) light keeps coming on and body goes up and down when I drove car. Light says do not drive. Mercedes would not take responsibility for this in spite there are so many complaints about this. Really irresponsible by Mercedes.

The 2003 SL500 with seemingly no instigating incident or event had the gas tank baffle come apart due to the poor and faulty design of this component. This baffle now is loose and floats on the gas in the gas tank, banging around when there is acceleration or deceleration, even turning sometimes causes it to bang around. Speed bumps are another source of loud banging from the baffle bumping into the sides of the tank. The issue with 2003 SL500's is ubiquitous, it is not a question of what percentage of them will experience as it appears it will happen to this vehicle at some point due to the poor design and implementation of the baffle. This wouldn't be such a big problem if this was a minor repair and was a reasonable price to have a shop perform or for the more mechanically inclined owner to perform themselves, but it is a ridiculously complex and time-consuming job just to get to the gas tank and take it off. My mechanic told me it is akin to taking the transmission or engine out and as such labor is outstandingly and outrageously expensive with this job requiring approximately $2000-$2500 to perform according to my mechanic and other SL500 owners who have also had to deal with this issue. This is an issue that you may not experience if you don't own one of these vehicles for long enough, but the vehicle will have this problem during it's lifetime and Mercedes should be responsible for allowing such a design to make it into production.

HEARING CLANGING, THUMP NOISE BETWEEN SEATS AND TRUCK, TOOK IT TO A REPAIR SHOP AND WAS ADVISED IT IS A COMMON ISSUE WITH THIS MODEL - PROBLEM WITH BAFFLE IN THE TANK AND MIGHT HAVE COME OFF, SEARCHED ON-LINE AND FOUND HUNDREDS OF COMPLAINTS FOR THE SAME ISSUE, WAS THIS EVER ADDRESSED BY MB AND RECALLED?

The contact owns a 2003 Mercedes-Benz SL500. The contact stated while driving 40 MPH, the brake pedal was depressed however, the vehicle failed to respond as needed. The contact depressed the brake pedal firmly however, the vehicle failed to respond. The parking brake was activated however, the vehicle failed to respond as designed. The contact was however able to pull over and eventually the vehicle came to a complete stop. The vehicle was towed. The dealer and the manufacturer were contacted and stated that the VIN was not included in NHTSA Campaign Number: 05V133000 (Service Brakes, Hydraulic). The failure mileage was 126,000. The consumer stated the part put on the vehicle for the recall was a defective part and not installed correctly.

WHILE DRIVING MY MERCEDES BENZ 2003 SL500 THE BRAKES BECAME DISABLED WITHOUT WARNING. IT WAS A TERRIFYING EXPERIENCE. THE FIRST MERCEDES DEALER I PHONED TOLD ME THAT THERE WAS NO KNOWN SAFETY RECALLS FOR THE BRAKES. THE SECOND MERCEDES DEALER THAT I CONTACTED INFORMED ME ABOUT 2 RECALLS IN 2004 AND 2005. I PHONED THE MERCEDES BENZ USA HEADQUARTERS AND SPOKE TO A CASE MANAGER WHO TOLD ME THAT MERCEDES' RESPONSIBILITY WITH THIS SAFETY ISSUE EXPIRED IN 2012. HOW CAN A SAFETY ISSUE SUCH AS HAVING NO BRAKES WHILE DRIVING EXPIRE? HOW CAN A CORPORATION BE ALLOWED TO WALK AWAY FROM THIS TYPE OF POTENTIALLY DEADLY SAFETY ISSUE? THIS IS A WELL DOCUMENTED SAFETY ISSUE WITH THIS CAR.

To who may this concerned, I have a 2003 Mercedes SL500 and recently found my battery control module caught on fire and burnt a section of my car. I have tried reaching out to Mercedes directly first and they said the car is 20 years ago and it could have not be a manufactured defect. Please I need help this problem could’ve burn down my house or while I was driving. Mercedes requested I send them a letter in writing if I have to get the car inspected. Please setup and date so I can write them this is 100% liability on their brand as there is no schedule maintenance for a battery control module.

I am concerned with the battery control module. I have noticed there has been a lot of incidents out there where the battery control module in the SL 500s have caught fire! I am concerned for my safety due to this defect!

TL* THE CONTACT OWNS A 2003 MERCEDES-BENZ SL500. WHILE DRIVING INTO THE GARAGE, THE ABC PUMP WARNING INDICATOR ILLUMINATED AND THE CONTACT NOTICED SMOKE INSIDE THE VEHICLE. IN ADDITION, THE CONTACT NOTICED A LARGE AMOUNT OF HYDRAULIC FLUID ON THE GARAGE FLOOR. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FRONT AND REAR AXLE VALVE LOCK, AND PRESSURE RESERVOIR FOR THE ABC SYSTEM NEEDED TO BE REPAIRED AND FLUSHED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V263000 (SUSPENSION, ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 55,620. *TR

TL* THE CONTACT OWNS A 2003 MERCEDES BENZ SL500. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, SHE SMELLED SMOKE COMING FROM THE ENGINE. THE CONTACT STATED THAT THE ABC AND STOP VEHICLE TOO LOW WARNING LIGHTS ILLUMINATED. THE CONTACT MENTIONED THAT WHILE DRIVING, THE FRONT END OF THE VEHICLE STARTED TO SCRAPE THE GROUND. THE CONTACT WAS ABLE TO PULL THE VEHICLE OVER AND NOTICED THAT IT WAS LEAKING FLUID. THE VEHICLE WAS TOWED TO THE DEALER. IT WAS UNKNOWN IF THE VEHICLE WAS DIAGNOSED BUT THE VEHICLE HAS NOT BEEN REPAIRED. THE CONTACT STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V263000 (ENGINE AND ENGINE COOLING, SUSPENSION). THE DEALER INFORMED THE CONTACT THAT THE VEHICLE ALSO SHOWED FAILURE SIGNS OF NHTSA CAMPAIGN: 05V133000 (SERVICE BRAKES, HYDRAULIC). THE FAILURE MILEAGE WAS 86,998.

It has been nearly two years I have stopped driving my 2003 Mercedes SL500, although I only have about 80,000 miles on the car. This is due to ABC warning light(red display: please drive carefully)comes on intermittently and the car drives very bouncy and it feels the car has no shocks, definitely feeling it would be unsafe to drive. The diagnostic message comes up saying "visit workshop". This is the third time this ABC pump issue is stopping me from driving the car, since it first appeared when I had 29,000 miles on the car which was under manufacturer warranty (50,000 miles or four years) and the dealership replaced the ABC pump and also replaced the engine mounts. The ABC red light appeared again when I had about 51,000 miles on the car. It happened also the engine mounts were in need of replacement again. As the Warranty was only for 50,000 miles, Mercedes refused to repair the ABC pump and the engine mounts under warranty and finally I agreed to a 50% cost to me to have repairs done. I expressed my opinion that the ABC pump and the engine mounts had engineering and manufacturing defect and they should have 50,000 miles warranty as the original warranty, from the time of replacement. Regrettably, same ABC malfunction and engine mounts became an issue at 78,000 miles and now the dealer and Mercedes refuse to replace the ABC pump and engine mounts under warranty and have given an estimate of $7336.36 for the necessary replacement of parts, including labor, but excluding taxes. To divert attention from ABC pump, the dealer is now referring to the problem as "power Steering pump"I have extensively researched the issues and it appears the mentioned problems with my car are prevailing issues with other Mercedes 2003 SL 500, and there are 100's of owners who feel Mercedes is not taking responsibility for replacement and repair of these defective parts under warranty. My car is unsafe to drive. There should be a recall by Mercedes to fix these dangerous to drive cars.

TL* THE CONTACT OWNS A 2003 MERCEDES BENZ SL500. THE CONTACT STATED WHILE DRIVING 45 MPH, THE ACTIVE BODY CONTROL (ABC) WARNING LIGHT ILLUMINATED AND THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT PARKED THE VEHICLE ON THE SIDE OF THE ROAD. THE VEHICLE WAS NOT DRIVABLE. THE VEHICLE WAS TOWED TO AN UNKNOWN MERCEDES-BENZ DEALER TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE ACTIVE BODY CONTROL (ABC) NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE PERSISTED. THE MANUFACTURER WAS NOT INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 95,000. THE VIN WAS NOT AVAILABLE.

MERCEDES BENZ 2003 SL 500. IN 2011 WITH 34,000 MILES ON ENGINE, WHILE DRIVING ON HIGHWAY HEARD LOUD NOISE HAD TO PULL OVER QUICKLY BECAUSE FRONT OF CAR DROPPED RUBBING ON TIRES WHICH RESULTED IN ONE BLOWN OUT TIRE AND HAD CAR TOWED TO NEAREST DEALERSHIP, THANK GOD CUZ INNOCENT PEOPLE OR MYSELF COULD HAVE BEEN HURT SERIOUSLY, THIS WAS A $5,000 JOB . 2014 WITH 45,000 MILES ON ENGINE WHILE DRIVING ON HIGHWAY I HEARD AGAIN THAT DISTINCTIVE LOUD SOUND WHICH RESULTED IN LEFT SIDE OF CAR DROPPED RUBBING ON TIRES, FENDER AND TIRE WAS DAMAGED HAD CAR TOWED TO NEAREST MB DEALERSHIP. HYDRAULIC FLUID PROBLEMS HAS PLAGUE THIS QUALITY SERIES CAR . THIS UNFORTUNATE EVENT COST ME $9,800.00 BECAUSE I ALSO HAD TO REPAIR THE ROOF AS IT IS A CONVERTIBLE AND HYDRAULICS PLAYS AN IMPORTANT ROLE IN THE OPERATIONS OF THE ROOF . 2018 WITH 60,000 MILES ON ENGINE, WHILE DRIVING IN THE CITY, I HEARD LOUD THUD UNDER CAR I QUICKLY SWERVE OFF ROAD TO SAFE SPOT CUZ I KNEW THERE WAS A PROBLEM AGAIN, THE RIGHT SIDE OF CAR DROPPED WITH FLUID SPRAYING OUT , CAR THEN STARTED RESTING ON FRONT AND REAR TIRES WITH HYDRAULIC FLUID SPRAYED EVERY WHERE ,HAD THIS PROBLEM FIXED COST WAS $2,000 . FEW MONTHS AFTER THE SAME PROBLEM OCCURRED AGAIN . THIS CAR THAT I LOVE SO MUCH HAS BEEN SITTING IN MY GARAGE BECAUSE CAR CANT BE DRIVEN AND THE FRONT END / BODY OF CAR IS RESTING ON BOTH TIRES LEFT AND RIGHT SIDE . I AM MENTALLY AND PHYSICALLY DRAINED AND ALSO MY POCKETS . MERCEDES BENZ CORP. IS FULLY AWARE OF THIS PROBLEM BECAUSE OF THOUSANDS OF COMPLAINTS FROM OWNERS JUST LIKE MYSELF . AS A MULTI MILLION DOLLAR COMPANY THEY SHOULD HAVE TAKEN THE RESPONSIBILITY OF A RECALL IN GOOD FAITH TO ASSIST US , AFTER ALL THEY WOULD NOT BE WHERE THEY ARE TODAY WITHOUT US CUSTOMERS . MERCEDES BENZ CORP. WILLFULLY AND INTENTIONALLY IS KEEPING A BLIND EYE TO THIS BIG PROBLEM WHILE WE THE CUSTOMERS ARE BEING TAKEN ADVANTAGE OFF

ABC AND CONVERTIBLE ARE NOT FUNCTIONING AS ITS SUPPOSED, WHILE THE CAR NOT BENN DRING NOR USING THE FEATURES. THE KEYLESS REMOTE KEY ENTRY IS NOT WORKING!

ABC AND CONVERTIBLE ARE NOT FUNCTIONING AS ITS SUPPOSED, WHILE THE CAR NOT BENN DRING NOR USING THE FEATURES. THE KEYLESS REMOTE KEY ENTRY IS NOT WORKING!

SUSPENSION DROPS OVERNIGHT AND HAS DROPPED WHILE IN MOTION ON THE EXPRESSWAY. RED WARNING TO LIMIT SPEED CONSTANTLY COMES ON ESPECIALLY IF LOW ON FLUID AND ON BUMPS. THE DEALER CANNOT ISOLATE THE CAUSE OF PRESSURE OR EXCESSIVE HYDRAULIC FLUID LEAKS. FRONT BUMPER DAMAGED AS A RESULT. OVER $8000.00 SPENT AND PROBLEM NOT RESOLVED. NO CONFIDENCE IN THE CAR UNLESS THE SUPPLY OF FLUID IS CARRIED IN THE CAR AT ALL TIMES. DEALER WANTED $16,000.00 TO DIAGNOSE AND POSSIBLY REPAIR BUT OFFERED NO WARRANTY FOR WORK.

It has been nearly two years I have stopped driving my 2003 Mercedes SL500, although I only have about 80,000 miles on the car. This is due to ABC warning light(red display: please drive carefully)comes on intermittently and the car drives very bouncy and it feels the car has no shocks, definitely feeling it would be unsafe to drive. The diagnostic message comes up saying "visit workshop". This is the third time this ABC pump issue is stopping me from driving the car, since it first appeared when I had 29,000 miles on the car which was under manufacturer warranty (50,000 miles or four years) and the dealership replaced the ABC pump and also replaced the engine mounts. The ABC red light appeared again when I had about 51,000 miles on the car. It happened also the engine mounts were in need of replacement again. As the Warranty was only for 50,000 miles, Mercedes refused to repair the ABC pump and the engine mounts under warranty and finally I agreed to a 50% cost to me to have repairs done. I expressed my opinion that the ABC pump and the engine mounts had engineering and manufacturing defect and they should have 50,000 miles warranty as the original warranty, from the time of replacement. Regrettably, same ABC malfunction and engine mounts became an issue at 78,000 miles and now the dealer and Mercedes refuse to replace the ABC pump and engine mounts under warranty and have given an estimate of $7336.36 for the necessary replacement of parts, including labor, but excluding taxes. To divert attention from ABC pump, the dealer is now referring to the problem as "power Steering pump"I have extensively researched the issues and it appears the mentioned problems with my car are prevailing issues with other Mercedes 2003 SL 500, and there are 100's of owners who feel Mercedes is not taking responsibility for replacement and repair of these defective parts under warranty. My car is unsafe to drive. There should be a recall by Mercedes to fix these dangerous to drive cars.

ABC SYSTEM FAILURE. *TR

MERCEDES BENZ 2003 SL 500. IN 2011 WITH 34,000 MILES ON ENGINE, WHILE DRIVING ON HIGHWAY HEARD LOUD NOISE HAD TO PULL OVER QUICKLY BECAUSE FRONT OF CAR DROPPED RUBBING ON TIRES WHICH RESULTED IN ONE BLOWN OUT TIRE AND HAD CAR TOWED TO NEAREST DEALERSHIP, THANK GOD CUZ INNOCENT PEOPLE OR MYSELF COULD HAVE BEEN HURT SERIOUSLY, THIS WAS A $5,000 JOB . 2014 WITH 45,000 MILES ON ENGINE WHILE DRIVING ON HIGHWAY I HEARD AGAIN THAT DISTINCTIVE LOUD SOUND WHICH RESULTED IN LEFT SIDE OF CAR DROPPED RUBBING ON TIRES, FENDER AND TIRE WAS DAMAGED HAD CAR TOWED TO NEAREST MB DEALERSHIP. HYDRAULIC FLUID PROBLEMS HAS PLAGUE THIS QUALITY SERIES CAR . THIS UNFORTUNATE EVENT COST ME $9,800.00 BECAUSE I ALSO HAD TO REPAIR THE ROOF AS IT IS A CONVERTIBLE AND HYDRAULICS PLAYS AN IMPORTANT ROLE IN THE OPERATIONS OF THE ROOF . 2018 WITH 60,000 MILES ON ENGINE, WHILE DRIVING IN THE CITY, I HEARD LOUD THUD UNDER CAR I QUICKLY SWERVE OFF ROAD TO SAFE SPOT CUZ I KNEW THERE WAS A PROBLEM AGAIN, THE RIGHT SIDE OF CAR DROPPED WITH FLUID SPRAYING OUT , CAR THEN STARTED RESTING ON FRONT AND REAR TIRES WITH HYDRAULIC FLUID SPRAYED EVERY WHERE ,HAD THIS PROBLEM FIXED COST WAS $2,000 . FEW MONTHS AFTER THE SAME PROBLEM OCCURRED AGAIN . THIS CAR THAT I LOVE SO MUCH HAS BEEN SITTING IN MY GARAGE BECAUSE CAR CANT BE DRIVEN AND THE FRONT END / BODY OF CAR IS RESTING ON BOTH TIRES LEFT AND RIGHT SIDE . I AM MENTALLY AND PHYSICALLY DRAINED AND ALSO MY POCKETS . MERCEDES BENZ CORP. IS FULLY AWARE OF THIS PROBLEM BECAUSE OF THOUSANDS OF COMPLAINTS FROM OWNERS JUST LIKE MYSELF . AS A MULTI MILLION DOLLAR COMPANY THEY SHOULD HAVE TAKEN THE RESPONSIBILITY OF A RECALL IN GOOD FAITH TO ASSIST US , AFTER ALL THEY WOULD NOT BE WHERE THEY ARE TODAY WITHOUT US CUSTOMERS . MERCEDES BENZ CORP. WILLFULLY AND INTENTIONALLY IS KEEPING A BLIND EYE TO THIS BIG PROBLEM WHILE WE THE CUSTOMERS ARE BEING TAKEN ADVANTAGE OFF

I OWN A 2003 MERCEDES BENZ SL500. LIKE MOST OWNERS OF THIS VEHICLE, THE BAFFLE MOVES FREELY WITHIN THE GAS TANK WHICH CAUSES A NOISE AND IS POTENTIAL DANGEROUS IF A SPARK IS CREATED FROM THE BAFFLE HITTING THE INSIDE WALLS OF THE GAS TANK. FROM MY RESEARCH IT IS A MANUFACTURE ISSUE WITH THE WELDING OF THE BAFFLE TO THE INTERNAL WALL OF THE GAS TANK. THERE IS A TREMENDOUS AMOUNT OF COMPLAINTS AND THREADS ON MERCEDES FORUMS. PLEASE FOLLOW LINK TO SEE ALL COMPLAINTS. IT IS POOR CUSTOMER SERVICE AND ACCOUNTABILITY FROM MERCEDES BENZ USA TO NOT RECALL THE ISSUE. THERE IS OVER 20 PAGES OF COMPLAINTS REGARDING THIS ISSUE AT THIS LINK: HTTP://WWW.BENZWORLD.ORG/FORUMS/R230-SL-CLASS/1295215-SL500-NOISE-REAR-INTERIOR-WALL-GAS.HTML. *TR

TL* THE CONTACT OWNS A 2003 MERCEDES-BENZ SL500. THE CONTACT STATED THAT WHILE THE VEHICLE WAS BEING INSPECTED BY THE DEALER, IT WAS FOUND THAT THE SRS WAS NOT OPERATING PROPERLY AND NEEDED TO BE REPLACED. THE VEHICLE WAS BEING REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 59,000.

2003 SL500 MERCEDED SRS CONTROL UNIT MALFUNCTION AND FAILURE PREVENTING USE OF SAFTEY EQUIPMENT. *TR