2025 Mercedes-Benz Sprinter 2500 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2025 Mercedes-Benz Sprinter 2500, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Other / unspecified133.3%
- Powertrain (other)133.3%
- Suspension133.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
Refer to Safety Recall 25V747 and see the attachment which outlines our complaint. RV does not comply with requirements of FMVSS 110 and 49 CFR Part 567. We were the reporting party to the manufacturer and according to NHTSA database, our VIN is not present for the required recall service/extended fuel tank replacement. The RV manufacturer and dealer are not presently responding to requests from us to have the recall service completed. We believe they have not correctly reported additional safety concerns as are described in the attachment. The manufacturer has communicated that since producing RV's in 2021, they have improperly weighed RVs which has resulted in inaccurate OCCC labeling and we believe owners unknowingly operated RV's over GVWR. Our RV's OCCC is 333 lbs. A 174 lb weight savings per Safety Recall 25V747 will not bring our RV into compliance as we have a certified curb weight of 8700 lbs. and believe other same year/models have the same curb weight. Additionally, we are inquiring if Remote Vans is required to provide a cargo carrying allowance in addition to the occupant weight i.e. 600 lbs. for four seat belted passengers per FMVSS 110. We have also filed a complaint/attachment with Oregon Department of Justice Consumer Protection on 11/28/25.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
Subject: Transmission Failure Safety Complaint I am submitting a complaint regarding a serious transmission problem with my vehicle. While driving, the transmission suddenly failed, and the vehicle lost the ability to move properly. The car would not accelerate as expected and had difficulty. In some instances, the vehicle would not move forward or reverse. Warning indicators appeared, and the transmission Fault Stop began showing abnormal behavior such as delayed shifting, jerking, slipping, or sudden loss of power. This created a dangerous safety risk, especially while driving in traffic and at intersections. The vehicle has been maintained regularly, and this issue occurred unexpectedly. I believe this transmission defect may affect other vehicles of the same make and model and should be investigated for consumer safety. The dealership attributed the issue to wrong fuel, but I am concerned the actual issue involves transmission failure. I have a fuel purchase receipt showing the correct fuel was purchased before the incident. Despite this, the dealership suggested wrong fuel as the cause. I respectfully request that this matter be reviewed and appropriate action be taken. Vehicle Information: Make: Mercedes-Benz Model: Mercedes-Benz Sprinter Cargo Van 2500 Year: 2025 Mileage: 71599 VIN [XXX] Date of Incident:03/24/2026 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
Refer to Safety Recall 25V747 and see the attachment which outlines our complaint. RV does not comply with requirements of FMVSS 110 and 49 CFR Part 567. We were the reporting party to the manufacturer and according to NHTSA database, our VIN is not present for the required recall service/extended fuel tank replacement. The RV manufacturer and dealer are not presently responding to requests from us to have the recall service completed. We believe they have not correctly reported additional safety concerns as are described in the attachment. The manufacturer has communicated that since producing RV's in 2021, they have improperly weighed RVs which has resulted in inaccurate OCCC labeling and we believe owners unknowingly operated RV's over GVWR. Our RV's OCCC is 333 lbs. A 174 lb weight savings per Safety Recall 25V747 will not bring our RV into compliance as we have a certified curb weight of 8700 lbs. and believe other same year/models have the same curb weight. Additionally, we are inquiring if Remote Vans is required to provide a cargo carrying allowance in addition to the occupant weight i.e. 600 lbs. for four seat belted passengers per FMVSS 110. We have also filed a complaint/attachment with Oregon Department of Justice Consumer Protection on 11/28/25.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .