2007 Mercury Mariner Hybrid Problems

TL* THE CONTACT OWNS A 2007 MERCURY MARINER HYBRID. WHILE DRIVING APPROXIMATELY 60 MPH, THE ENGINE STALLED AND THE INSTRUMENT PANEL DISPLAYED A TRIANGLE WITH AN EXCLAMATION POINT. THE PANEL DISPLAYED THAT THE DRIVER NEEDED TO PULL OVER IMMEDIATELY. THE CONTACT PULLED OVER AND THE IGNITION HAD TO BE TURNED TO THE OFF POSITION FOR A FEW MINUTES IN ORDER FOR THE VEHICLE TO RESTART. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE MOTOR ELECTRONIC COOLANT PUMP FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VEHICLE WAS NO LONGER INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V526000 (ELECTRICAL SYSTEM). THE FAILURE MILEAGE WAS APPROXIMATELY 70,000.

TL* THE CONTACT OWNS A 2007 MERCURY MARINER HYBRID. THE CONTACT STATED THAT WHILE WAITING AT A TRAFFIC LIGHT, THE ENGINE STALLED AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE CONTACT RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN NUMBER 14V526000 (HYBRID PROPULSION SYSTEM). HOWEVER, THE PART NEEDED TO REMEDY THE VEHICLE WAS UNAVAILABLE. THE CONTACT BELIEVED THE FAILURE WAS RELATED TO THE RECALL. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 72,000.

TL* THE CONTACT OWNS A 2007 MERCURY MARINER HYBRID. WHILE DRIVING APPROXIMATELY 60 MPH, THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD BEFORE THE VEHICLE STOPPED. THE ANTI-LOCK BRAKE SYSTEM AND THE BRAKE INDICATORS ILLUMINATED. THE CONTACT STATED THAT THE FAILURE OCCURRED FIVE OTHER TIMES INTERMITTENTLY. ONCE THE VEHICLE WAS TURNED OFF AND RESTARTED, THE FAILURE WOULD STOP. THE VEHICLE WAS TAKEN TO THE DEALER (ED WHITTMEIER FORD IN CHICO, CALIFORNIA) FOR DIAGNOSTIC TESTING, BUT THE FAILURE COULD NOT BE DUPLICATED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 84,000. *TT CONSUMER STATED BRAKES FAIL INTERMITTENTLY WHEN THEY FAIL THE ABS AND BRAKE LIGHT ON THE DASH ARE LIT UP. UPDATED 7/31/18*JB

THE BRAKE SYSTEM'S HYDRAULIC CONTROL UNIT ("HCU"). ON SEVERAL OCCASIONS WHILE DRIVING, THE BRAKE PEDAL WILL TRAVEL TO THE FLOOR WHILE TRYING TO BRAKE RESULTING IN NO BRAKING ACTION (IE., VEHICLE NOT SLOWING). THIS MIGHT HAPPEN FOR ONE OR TWO PEDAL DEPRESSIONS BEFORE THERE IS ANY SLOWING OF THE VEHICLE. THIS PROBLEM HAS PLACED ME IN SITUATIONS WHERE I HAVE TO TAKE EVASIVE ACTION TO NOT HIT A VEHICLE IN FRONT OF ME, OR TRAVELING INTO A CONTROLLED (WITH STOP SIGNS) INTERSECTION. BELOW THERE IS A SPACE TO SPECIFY 'WHEN DID THIS HAPPEN.' I AM INPUTTING THE MOST RECENT DATE OF THIS PROBLEM, BUT IT HAS HAPPENED AT LEAST TEN TIMES BEFORE THIS.

The contact owns a 2007 Mercury Mariner. The contact stated while driving 50 MPH, the engine started to overheat, after which the vehicle lost motive power. The contact was able to pull to the shoulder of the roadway to let the engine cool down. After restarting the vehicle, the vehicle returned to normal functionality; however, the failure had since become a regular occurrence. The engine overheated warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 14V526000 (Hybrid Propulsion System) but the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 247,000.

TL* THE CONTACT OWNS A 2007 MERCURY MARINER HYBRID. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE STALLED AND THE CHECK FOUR BY FOUR, SERVICE BRAKES, AND PULL OVER SAFELY WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT MENTIONED THAT WHEN THE BRAKE PEDAL WAS DEPRESSED, THE VEHICLE JERKED FORWARD AND THE TRACTION CONTROL WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE FAILURE WAS UNABLE TO BE DIAGNOSED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 65,000.

TL* THE CONTACT OWNS A 2007 MERCURY MARINER HYBRID. THE CONTACT STATED THAT THE ALARM SYSTEM SOUNDED INDEPENDENTLY. THE VEHICLE WAS NOT DIAGNOSED AND THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

TL*THE CONTACT OWNS A 2007 MERCURY MARINER HYBRID. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V526000 (HYBRID PROPULSION SYSTEM) HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2007 MERCURY MARINER HYBRID. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE STALLED AND THE CHECK FOUR BY FOUR, SERVICE BRAKES, AND PULL OVER SAFELY WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT MENTIONED THAT WHEN THE BRAKE PEDAL WAS DEPRESSED, THE VEHICLE JERKED FORWARD AND THE TRACTION CONTROL WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE FAILURE WAS UNABLE TO BE DIAGNOSED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 65,000.

I WAS DRIVING MY '07 MARINER HYBRID ON THE NJ TURNPIKE AT FREEWAY SPEEDS WHEN THE RED TRIANGLE & MESSAGE "STOP SAFELY NOW" APPEARED ON THE DASH. THE PROPULSION SYSTEM STOPPED AND I WAS ABLE TO NAVIGATE OFF TO THE SHOULDER AND BRING THE VEHICLE TO A SAFE STOP. HAVING AN IMMEDIATE LOSS OF POWER WHILE TRAVELING ON THE TURNPIKE WAS VERY SCARY AND I FELT UNSAFE KNOWING THAT I DIDN'T HAVE ANY OPTIONS BUT TO EXIT THE FREEWAY IMMEDIATELY. THIS COULD HAVE RESULTED IN AN ACCIDENT. AFTER LETTING THE SYSTEM SIT FOR ABOUT 20-MINUTES I STARTED THE VEHICLE AND RESUMED MY TRAVEL. SAME ERROR MESSAGE AND LOSS OF PROPULSION HAPPENED AGAIN, AND THIS TIME I NAVIGATED THE HYBRID TO A FORD DEALER IN NJ. IT'S VERY SCARY TO BE TRAVELING AT HIGHWAY SPEEDS AND THEN A SECOND LATER NOT HAVE ANY PROPULSION. THIS COULD BE HANDLED MUCH BETTER AND I RECOMMEND THE ENGINE CONTINUE TO PERFORM SO THAT I CAN SAFELY EXIT THE FREEWAY WITH MORE TIME. *JS

I WAS DRIVING MY '07 MARINER HYBRID ON THE NJ TURNPIKE AT FREEWAY SPEEDS WHEN THE RED TRIANGLE & MESSAGE "STOP SAFELY NOW" APPEARED ON THE DASH. THE PROPULSION SYSTEM STOPPED AND I WAS ABLE TO NAVIGATE OFF TO THE SHOULDER AND BRING THE VEHICLE TO A SAFE STOP. HAVING AN IMMEDIATE LOSS OF POWER WHILE TRAVELING ON THE TURNPIKE WAS VERY SCARY AND I FELT UNSAFE KNOWING THAT I DIDN'T HAVE ANY OPTIONS BUT TO EXIT THE FREEWAY IMMEDIATELY. THIS COULD HAVE RESULTED IN AN ACCIDENT. AFTER LETTING THE SYSTEM SIT FOR ABOUT 20-MINUTES I STARTED THE VEHICLE AND RESUMED MY TRAVEL. SAME ERROR MESSAGE AND LOSS OF PROPULSION HAPPENED AGAIN, AND THIS TIME I NAVIGATED THE HYBRID TO A FORD DEALER IN NJ. IT'S VERY SCARY TO BE TRAVELING AT HIGHWAY SPEEDS AND THEN A SECOND LATER NOT HAVE ANY PROPULSION. THIS COULD BE HANDLED MUCH BETTER AND I RECOMMEND THE ENGINE CONTINUE TO PERFORM SO THAT I CAN SAFELY EXIT THE FREEWAY WITH MORE TIME. *JS

CAR ENGINE SUDDEN WENT DEAD IN THE MIDDLE OF HIGHWAY AND MESSAGE APPEARED THAT PULL OVER NOW FOR SAFETY. NO POWER TO WHEELS ECT. BARELY FOUND SAFE PLACE TO PULL OVER. DEALERSHIP SAID IT WAS CAUSED BY LEAKY WATER PUMP. VEHICLE WAS REPAIRED AT FOLSOM LAKE FORD. NO NOTE WAS ON THE DISPLAY SAYING WATER PUMP, JUST THE ABOVE MESSAGE. HAD TO WAIT AND RESTART ENGINE. THIS COULD HAVE CAUSED A SERIOUS ACCIDENT IN HIGH SPEED TRAFFIC ON A FREEWAY, ECT. *TR

PASSENGER SIDE REAR INNER FENDER WELL RUSTED COMPLETELY THROUGH ABOVE THE REAR SHOCK CAUSING THE SHOCK TO POTENTIALLY BREAK THROUGH AND DROP THE WHOLE SUSPENSION AND CAUSE AND ACCIDENT OR FLIP OVER IF IT BROKE THROUGH DURING A TURN. THE REST OF THE VEHICLE HARDLY HAS ANY RUST ON IT. THE MARINER SHARES THE SAME INNER SHEET METAL AS THE FORD ESCAPE AND THERE HAVE BEEN MANY COMPLAINTS OF THIS HAPPENING TO ESCAPES. MY VEHICLE WAS STUDIED AT A FORD INVESTIGATION ABOUT 4 YEARS AGO FOR THIS PROBLEM. I WAS TOLD THEY WERE WORKING ON A SOLUTION AND NOTHING EVER HAPPENED. THE EMPLOYEE TOLD ME THAT THE UNDERCOATING THEY USED OF THESE YEARS OF ESCAPE/MARINERS WAS FAULTY AND BROKE DOWN PREMATURELY CAUSING THE INNER FENDER EXPOSED TO THE ELEMENTS. THIS IS ALSO HAPPENING ON THE DRIVER'S SIDE WHERE THE UNDERCOATING IS START TO BREAK DOWN. THIS IS NOT A CASE OF MISUSE BY THE OWNER BUT AN ACTUAL DESIGN FLAW AND A BIG SAFETY ISSUE AS THIS COULD CAUSE A LOT OF HARM. LUCKILY I HEARD THE LOUD KNOCKING FROM THE REAR END AND STOPPED DRIVING IT.

TL* THE CONTACT OWNS A 2007 MERCURY MARINER HYBRID WITH 80,688 MILES. THE CONTACT OWNS A BRITAX BOULEVARD CT REAR FACING CHILD SEAT. THE CHILD SEAT WOULD NOT PROPERLY FIT IN THE VEHICLE UNLESS A NOODLE OR TOWEL WAS BEING USED. THE OWNERS MANUAL STATED THAT NO OBJECT COULD BE USED BETWEEN THE CHILD SEAT AND THE VEHICLE. THE MANUFACTURE WAS CONTACTED IN REGARDS TO THE FAILURE AND THEY INFORMED THE CONTACT THAT THE WHEELBASE OF THE VEHICLE WAS TOO SHORT FOR THE CHILD SEAT TO FIT PROPERLY. THE MANUFACTURER ALSO INFORMED THE CONTACT THAT THE SEAT WAS NOT TESTED TO DETERMINE IF IT WOULD FIT PROPERLY IN THE VEHICLE. THE CONTACT STATED THAT VIN LISTED ON THE DRIVER SIDE DOOR PANEL WAS DIFFERENT FROM THE VIN LISTED UNDER THE FRONT WINDSHIELD. THE VEHICLE WAS NEVER INVOLVED IN A CRASH.

THE POWER STEERING WENT OUT IN MY MOTHER'S 2007 MARINER HYBRID WITH 72,000 MILES DUE TO FAILURE OF THE POWER STEERING CONTROL MODULE. AFTER SEARCHING ONLINE FORUMS, I FOUND THIS TO BE A RATHER COMMON ISSUE ON THE 05-07 MARINER AND ESCAPE HYBRIDS. THE REPAIR WILL COST JUST UNDER A THOUSAND DOLLARS ONCE YOU LOCATE THE PART. AFTER HAVING IT DIAGNOSED AT MY FORD DEALER, I CONTACTED FORD CUSTOMER CARE TO SEE IF THEY COULD RESOLVE THE ISSUE, AND THEY ACTED LIKE IT WAS SOMETHING THEY WERE UNAWARE OF EVEN THOUGH IT DOES NOT TAKE MUCH SEARCHING TO SEE IT'S A COMMON PROBLEM. ALSO IT'S A SAFETY ISSUE. THE SAME PART WAS RECALLED ON THE 08-11 ESCAPE AND MARINER HYBRIDS, AND THE RECALL SHOULD HAVE INCLUDED THE 05-07 AS WELL. FORUMS: HTTP://COMMUNITY.CARTALK.COM/DISCUSSION/2161203/2006-FORD-ESCAPE-HYBRID-POWER-STEERING-FAILURE HTTP://WWW.HYBRIDCARS.COM/FORUMS/SHOWTHREAD.PHP?100317-POWER-STEERING-FAILURE HTTP://WWW.CARCOMPLAINTS.COM/FORD/ESCAPE_HYBRID/2006/STEERING/STEERING.SHTML HTTP://WWW.GREENHYBRID.COM/FORUMS/F26/SERVICE-POWER-STEERING-MODULE-GONE-BAD-20550/INDEX2.HTML HTTP://FORUMS.EDMUNDS.COM/DISCUSSION/6206/FORD/ESCAPE-HYBRID/FORD-ESCAPE-HYBRID-SUSPENSION-STEERING-PROBLEMS. *TR

MY WIFE WAS DRIVING APPROX. 50 MPH. ENTERED A CURVE AND THE POWER STEERING FAILED, MAKING IT VERY DIFFICULT FOR HER TO STEER SAFELY. *TR

PASSENGER SIDE REAR INNER FENDER WELL RUSTED COMPLETELY THROUGH ABOVE THE REAR SHOCK CAUSING THE SHOCK TO POTENTIALLY BREAK THROUGH AND DROP THE WHOLE SUSPENSION AND CAUSE AND ACCIDENT OR FLIP OVER IF IT BROKE THROUGH DURING A TURN. THE REST OF THE VEHICLE HARDLY HAS ANY RUST ON IT. THE MARINER SHARES THE SAME INNER SHEET METAL AS THE FORD ESCAPE AND THERE HAVE BEEN MANY COMPLAINTS OF THIS HAPPENING TO ESCAPES. MY VEHICLE WAS STUDIED AT A FORD INVESTIGATION ABOUT 4 YEARS AGO FOR THIS PROBLEM. I WAS TOLD THEY WERE WORKING ON A SOLUTION AND NOTHING EVER HAPPENED. THE EMPLOYEE TOLD ME THAT THE UNDERCOATING THEY USED OF THESE YEARS OF ESCAPE/MARINERS WAS FAULTY AND BROKE DOWN PREMATURELY CAUSING THE INNER FENDER EXPOSED TO THE ELEMENTS. THIS IS ALSO HAPPENING ON THE DRIVER'S SIDE WHERE THE UNDERCOATING IS START TO BREAK DOWN. THIS IS NOT A CASE OF MISUSE BY THE OWNER BUT AN ACTUAL DESIGN FLAW AND A BIG SAFETY ISSUE AS THIS COULD CAUSE A LOT OF HARM. LUCKILY I HEARD THE LOUD KNOCKING FROM THE REAR END AND STOPPED DRIVING IT.

DRIVING HOME LATE AT NIGHT, FROM BABYSITTING MY GRANDKIDS, WAS HIT IN THE REAR END BY A DRUNK DRIVER (ARRESTED BY THE STATE POLICE), GOING A HIGH RATE OF SPEED. THE DRIVERS SEATBACK BROKE FROM THE IMPACT AND I WAS UNABLE TO MAINTAIN CONTROL. SUV ROLLED 3 TIMES ACROSS THE EXPRESSWAY. SIDE CURTAIN AIRBAGS DEPLOYED. I SUFFERED POST CONCUSSIVE SYNDROME, WHIPLASH, GROIN INJURY, BOTH THUMBS (FROM TRYING TO HOLD MYSELF UP THRU THE ROLL) AND A CLOSED HEAD INJURY. BOTH CARS WERE TOTALED. I'M STILL IN TREATMENT. *TR