2009 Mercury Mariner Steering Problems

My vehicle was returned to me following a torque sensor replacement on 4/9/2026 in poor condition (locked steering and a catastrophic gash in the driver-side tire) rendering it undrivable and unsafe. Crossroads Ford of Prince George shop's inspection report claims the tire damage was pre-existing, I have conclusive evidence to the contrary: Virginia State Inspection: My vehicle passed a Virginia state safety inspection on 2/27/2026. Per state law, any tire with a gash or sidewall crack is an automatic failure. This legally certifies the tire was intact immediately prior to their service. Recent Tire Service: I replaced my rear tires at OK Tire and Auto on 3/30/2026. At that time, a full tread and sidewall inspection of my front tires confirmed they were in good condition. The timing of the dealership's communication confirms the damage occurred while in their care: I arrived for my 9:30a appointment around 9:25a. No damage was noted during the initial intake. I was in their facility when I watched a mechanic drive to the other side of the service parking lot without being informed of a "catastrophic" safety issue. I was only notified of the gash at the end of the day when the vehicle was scheduled for return. Their staff now deems the vehicle "unsafe to drive" for their own employees. If this gash were present at 9:30am, it would have been told to me before I left the dealership. The locked steering is a direct result of an improper torque sensor installation (which is the reason why I was dropping my car off to be serviced). My car was in driving condition as I drove it to the dealership for my appointment with no issues. I received a call from advisor Sade Gregory at 11:03 informing me that I would need a steering column now that is on backorder. At 11:13am I received a confirmation for car delivery to me then at 1:06pm confirmation that my car will arrive at my house at 1:15. At 1:20 Sade Gregory says my car can't be delivered now because its unsafe for them.

NHTSA ID

11730562

Incident

Apr 9, 2026

The contact owns a 2009 Mercury Mariner. The contact stated that while driving at undisclosed speeds on several occasions, the steering wheel started shaking abnormally. The contact added that on several occasions while driving at undisclosed speeds, the vehicle lost power steering functionality, but the vehicle regained power steering functionality shortly afterwards. The "Power Steering Assist Fault" message was displayed on one occasion. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 117,900.

NHTSA ID

11721530

Incident

Feb 15, 2026

Mileage

117,900 mi

My steering has been locking while I am driving and causing loss of steering and control of car. I have contacted crossroads dealer and I have not gotten a response as I am now aware there has been a safety recall on this vehicle.

NHTSA ID

11719580

Incident

Dec 5, 2025

The power steering stopped working. A note did appear to let me know it wasn’t working. I took it in to the mechanic and he confirmed the power steering wasn’t working.

NHTSA ID

11714546

Incident

Jan 22, 2026

Vehicle notification stating Power Steering Assist Fault. Power steering locked up on highway going 60 mph while a child was in vehicle and vehicle was extremely hard to get off the highway. Parkway Ford of Pampa, Tx would not honor recall as VIN was not pulling up a recall. But a different auto mechanic repair shop did verify it was a recall.

NHTSA ID

11668925

Incident

Jun 23, 2025

Power steering failure on may 26th and 27th upon start up. Had to disconnect battery terminal to reset torque sensor

NHTSA ID

11663096

Incident

May 26, 2025

The contact owns a 2009 Mercury Mariner. The contact stated that while driving at an undisclosed speed, the contact became aware that the electronic power steering was not functioning properly, requiring an increased effort to maneuver the vehicle. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 14V284000 (Steering); but the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was unknown.

NHTSA ID

11646320

Incident

Mar 2, 2025

The contact owns a 2009 Mercury Mariner. The contact stated while attempting to drive out of the driveway, the vehicle stalled and lost power. The contact stated that several unknown warning lights were illuminated. The vehicle was then driven to an independent mechanic to be diagnosed. The vehicle was diagnosed with electric power steering failure. The local dealer was contacted; however, the vehicle was not repaired. The contact stated that the failure persisted. The manufacturer was made aware of the failure. The failure mileage was approximately 233,812.

NHTSA ID

11634365

Incident

Feb 5, 2022

Mileage

233,812 mi

Unknown

NHTSA ID

11628708

Incident

Dec 3, 2024

Power steering stopped working completely.... was taking a turn and the steering became stiff and shook a little and went back to normal. Parked the car. started the car 2 hours later and steering completely stiff... no power steering. a quick google search of this common issue will tell you : Ford owners forum groups with the same issue, complain that Ford apparently only did reprogramming and did not replace the actual part causing the issue, when checking the codes, it did not show the failure yet, so they reprogrammed the unit to check the box Ford completed the safety recall. Recall 14V284000: Loss Of Power Steering Assist NHTSA Campaign ID Number: 14V284000 "STEERING:ELECTRIC POWER ASSIST SYSTEM" (5/28/2014) Summary: Ford Motor Company (Ford) is recalling certain model year 2008-2011 Ford Escape and Mercury Mariner vehicles manufactured August 18, 2006, through September 11, 2010. The affected vehicles have a steering torque sensor that may not be able to properly detect driver steering input. As a result, the system could remove the Electric Power Steering (EPS) assist. Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash. Remedy: Ford will notify owners, and dealers will update the software for the power steering control module (PSCM) and the instrument cluster module, free of charge. If a vehicle shows a history of a loss of the torque sensor signal or fault codes relating to the PSCM when the vehicle is brought in for the recall remedy, the affected components will be replaced, free of charge. The recall began on July 18, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford’s number for this recall is 14S05. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11627895

Incident

Nov 28, 2024

This is an update to the complaint from June- Because I have to compensate manually for the electric power steering, I’ve aggravated upper back injuries and strained hip muscles I incurred from work. I have to attend physical therapy for those injuries now, but it’s useless if my only mode of transportation prolongs my recovery.—— My 2009 Mercury Mariner’s steering wheel started locking up 3 months ago, and it’s hard to get the steering wheel and the tires to agree on one direction. I looked up the make and model to see if there was a safety recall for it and there was, but my VIN wasn’t included in the recall campaign, even though it fits the criteria exactly. ///Ford Motor Company (Ford) is recalling certain model year 2008-2011 Ford Escape and Mercury Mariner vehicles manufactured August 18, 2006, through September 11, 2010. The affected vehicles have a steering torque sensor that may not be able to properly detect driver steering input. As a result, the system could remove the Electric Power Steering (EPS) assist.

NHTSA ID

11626078

Incident

Nov 1, 2024

The contact owns a 2009 Mercury Mariner. The contact stated that while her son was driving at various speeds, the vehicle intermittently experienced a loss of power steering assist. No warning light was illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact related the failure to NHTSA Campaign Number: 14V284000 (Steering); however, the VIN was not included in the recall. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 170,000.

NHTSA ID

11618098

Incident

Oct 3, 2024

Mileage

170,000 mi

The power steering on my vehicle has failed and the repair shop stated there is an expired recall for the steering on this vehicle from 2014. I bought my vehicle (2009 Mercury Mariner) 1 year ago. VIN: [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11617716

Incident

Sep 3, 2024

The contact owns a 2009 Mercury Mariner. The contact stated while driving 30-35 MPH, the vehicle lost power steering functionality. The contact was able to pull to the side of the road. The contact turned off and restarted the vehicle after 15-20 minutes, and the power steering became functional. The contact was able to continue driving. The contact stated that the failure recurred several times while driving. The dealer was contacted and charged a fee for diagnostic testing. The vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 14V284000 (Steering); however, the VIN was not included. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 131,000.

NHTSA ID

11612252

Incident

Aug 20, 2024

Mileage

131,000 mi

The contact's fiancée owns a 2009 Mercury Mariner. The contact stated that the vehicle was previously serviced under NHTSA Campaign Number: 14V284000 (Steering); however, a month after the recall repair, the vehicle lost power steering functionality while driving at an undisclosed speed. The dealer was notified of the failure and informed the contact that a fee would be charged for a diagnostic test. The vehicle was not diagnosed. The dealer later informed that the software for the power steering control module (PSCM) was previously updated under the recall; however, the manufacturer informed the contact that there was no record of the recall repair in the vehicle repair history. The manufacturer referred the contact to the NHTSA Hotline for assistance. The vehicle was not diagnosed or repaired. The failure mileage was unknown.

NHTSA ID

11594154

Incident

Jun 13, 2017

My 2009 Mercury Mariner’s steering wheel started locking up 3 months ago, making it impossible to drive. I looked up the make and model to see if there was a safety recall on it, and there was, but my VIN wasn’t included in the recall campaign, even though it fits the criteria exactly. ///////////Ford Motor Company (Ford) is recalling certain model year 2008-2011 Ford Escape and Mercury Mariner vehicles manufactured August 18, 2006, through September 11, 2010. The affected vehicles have a steering torque sensor that may not be able to properly detect driver steering input. As a result, the system could remove the Electric Power Steering (EPS) assist.////

NHTSA ID

11592974

Incident

Mar 21, 2024

Months back there were times the power steering would go out, it would be for short amount of times and always came back. As of 40+ days ago the power steering has totally gone out and has not once come back. The dash says "power steering assist fault" The other issue is the wrench on the dash. It's normally after driving for quite some time. Even if there has been a break on the car while grocery shopping etc. when it comes on the car goes into limp mode. VERY DANGEROUS as we cannot tell when it'll happen. There has been multiple times the light turns green we take off, get to about 15-20MPH and she just stops. The dash reads to safetly pull over and I believe it says to shut off the car. This has been happening for 5+ months. There is also random over heating when that happens. This is based on how I remember it. Because of the safety issues I have not driven the vehicle. My husband drives it because he can handle no power steering better then me... Not that it's better for anyone to use..

NHTSA ID

11585642

Incident

Mar 1, 2024

The contact owns a 2009 Mercury Mariner. The contact stated while starting the vehicle, the vehicle lost power steering functionality. The contact stated that the steering wheel was locked. The message "Power Steering Assist Fault" was displayed. The dealer was notified of the failure and referred the contact to the manufacturer for assistance. The vehicle was not diagnosed or repaired. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 14V284000 (Steering) however, the failure persisted. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 150,000.

NHTSA ID

11564411

Incident

Jan 9, 2024

Mileage

150,000 mi

The contact owns a 2009 Mercury Mariner. The contact stated while driving around a traffic circle and making a left turn at approximately 20 MPH, the power steering failed to function as intended. The contact stated there was no warning light illuminated. The contact stopped the vehicle and turned off and restarted the vehicle however, the vehicle failed to regain power steering functionality. The contact drove the vehicle to the residence. The vehicle had not been diagnosed by the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was informed of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 14V284000 (Steering). The failure mileage was approximately 175,000.

NHTSA ID

11564164

Incident

Nov 8, 2023

Mileage

175,000 mi

My SUV was part of a recall due to the electronic power steering failing. My SUV was allegedly repaired by the cheapest of the three available options (computer reset or some such process). I bought my SUV in 2020. The electronic power steering slowly started going out intermittently and then more frequently over time, but is now completely out. The dealer tested my SUV and stated that the entire steering column needs to be replaced. They claim that the problem has nothing to do with the recall, but I don't believe them. My issue is the exact same issue that prompted the recall in the first place. I should not have to pay for a failed recall repair. I think it's possible that the original dealership faked the repair, or simply chose the cheapest (but not proper) option to save themselves time and money. My shoulder is now damaged due to driving without power steering for so long. I need an honest evaluation of my vehicle and an investigation into whether or not the original dealer performed the proper repair. I would assume that the issue wouldn't come back if it had been repaired properly the first time.

NHTSA ID

11563540

Incident

Mar 1, 2020

The contact owns a 2009 Mercury Mariner. The contact stated that while at a complete stop, the steering wheel was jerking independently. There was no warning light illuminated. The contact stated that upon starting the vehicle, the power steering assist failed to operate as needed. The contact stated that the power steering warning light was illuminated. The dealer and the manufacturer were notified of the failure and informed the contact that the vehicle was not included in NHTSA Campaign Number: 14V284000 (Steering). The vehicle was not repaired. The failure mileage was approximately 150,000.

NHTSA ID

11560107

Incident

Nov 23, 2023

Mileage

150,000 mi

The electronic power steering is not working and have already replaced the torque sensor twice. I need a ECM and steering column to fix it.

NHTSA ID

11552540

Incident

Aug 1, 2022

Purchased used car in what appeared to be very good condition. Within a few months, Power Steering Failure. Very difficult and dangerous to drive without power steering. Need car for work.

NHTSA ID

11542465

Incident

Aug 1, 2023

About 3 months ago, my power steering started to fail. After researching to find out the problem, we learned that my car does not have a power steering pump, as it is electronic. I learned that my car had a recall from Ford pertaining to the power steering failing. I called Ford and they told me that my car was part of the recall and was "fixed" in 2015. A month ago I took it to a Ford dealership to have them do a diagnostic on my car and they informed me that it was my power steering torque sensor, which I already knew this by researching the issue. The issue now lies in the fact that the part is on back order and there is no available date. I believe that Ford should have replaced the parts needed instead of doing a "bandaid fix" by doing a software update, which they knew would not be the fix to the problem. Ford got away with not fixing something that is very dangerous to those who drive the Mercury Mariners. Mine is an 2009 and it is now dangerous on the highways to drive. I would like to add that while driving my car now with this issue, my battery light comes on, which is also a known issue to Ford.

NHTSA ID

11538597

Incident

Jun 8, 2023

The PCM shorts out and fails when sparkplug and Coil packs replaced this cause the steering system to fail speedometer to quit and no transmission connection

NHTSA ID

11521608

Incident

May 11, 2023