Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 451 NHTSA owner-reported complaints for the 2008 Mercury Milan. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–25 of 451 · page 1 of 19
08 merc milan abs did not work and brakes failed almost causing major accidents. I used e brake to stop. Brakes went to floor. Been calling for and dealerships for recalls I find out now about abs malfunctioning noone will fix or get back to me. Leaking brake fluid all around abs module now. Dealerships saying they not fixing abs even on recalls. Ford dealership in East rutherford nj.
There is a problem with my tourqe converter with 100k miles. My car won't accelerate.
P205/60R16
The ABS brake function checked out during the recall window on Nov. 2 of 2021. The Ford dealer mechanics purged the brake system with fresh fluid and tested the function. Tested OK. The car was used without issue until recently and now the brake pedal goes down nearly to the floor before the brakes engage. It is shocking at first and once used to that the driver will pump the pedal twice for a firm pedal. A recent visit to a Ford dealer to diagnose the issue revealed that the recall is closed and that there is nothing they can do unless I pay the approximately $1000 to replace the ABS Hydraulic module. My complaint is that Ford customer service wants me to pay for this and then submit the invoice to them for review. Wow, I'm not going to do that, since there is no guarantee of reimbursement. This is a KNOWN SAFETY problem that is not being addressed appropriately. I'm a mechanic. They could send me the part free of charge for a sane resolution. I'd eat the labor charge.
Brakes are failing even after they have been serviced. Unsafe car to drive
The gas pedal gets stuck at the top when I go to press down on it allowing the car to keep driving when I am trying to stop the car.
Was not able to drive my car because you had to press the breaks all the way to the ground in order for the vehicle to attempt to stop. A recall was issued for the hydraulic breaks in 2019 and no parts were available for almost a year. Car has been at the dealership being repaired since August 12, but now they are telling us that the hydraulic breaks issues has caused the break master cylinder to fail - leaving the car unsafe and undrivable but they are expecting us to pay for the replacement of the master cylinder when the dealership openly admitted this was directly caused because of the recall
In March 2021 I received important safety recall from Ford advising me that the Airbag inflator might explode in the event of a crash and may cause injury or death to the driver or passengers. My daughter still drives this car, why have they not followed up and replaced this part?
The contact owns a 2008 Mercury Milan. The contact stated while driving 25-30 MPH, the brake pedal was depressed but went all the way to the floorboard and failed to respond. The contact was unsure whether there was a warning light illuminated. The contact stated that she coasted the vehicle on a hill and turned off the vehicle. There was no warning light illuminated. The vehicle was towed to three different independent mechanics who diagnosed that the braking system had failed. However, the failure was unrepairable. The contact became aware of NHTSA Campaign Number: 19V904000 (Service Brakes, Hydraulic) which she associated with the failure. The dealer was notified of the failure and informed the contact that the remedy was not available. The vehicle was not repaired. The manufacturer was notified of the failure and confirmed that the remedy was not yet available. The failure mileage was approximately 97,000.
I took the vehicle in earlier this year for the recall on the Brake system. They bled the brakes and said it was fine but now the brakes are just like they were before taking it in. I would assume that the HCU is bad but they did not want to change it out when they had it.
RE: NHTSA Campaign Number: 19V904000 Manufacturer Ford Motor Company Components SERVICE BRAKES, HYDRAULIC Vehicle regarding complaint: 2008 Mercury Milan Vehicle Vin: [XXX] Good day, In September of 2021 I took the above mentioned vehicle in for the above stated recall regarding the Hydraulic control unit. The vehicle was taken to Westlie Motor Company 500 S Broadway Minot, ND 58701 (701) 852-1354. The vehicle was tested and did in fact fail the test and I was informed the replacement part would be ordered promptly. After two months of no calls from the dealership I stopped in and was told they had no idea about the part. I was assured it would be looked in to. The first week of December I was called and requested the vehicle be brought in for the recall service. I took the vehicle in December 6th and after two hours was notified service was finished. Upon driving home I immediately noticed the problem had not been fixed. I returned to the dealership upon inspecting the vehicle having noticed the NO obvious repairs had been done. Demanding explanation I was told that it was a miscommunication and recall work had not been done. Only a brake flush and cap replacement. I was then again told that they were not sure where the part was or when it would arrive. I then escalated a complaint to Ford motor company ( 1-866-631-3788) Case # [XXX]. I was assure Ford would call the company and inform me intermediately as to the situation and a solution. I received no call back and I again phoned in January with the same result. I was told they would look into it and call me back. I again called today Feb 1st and spoke with Ford and was told the same thing with no solution given. I have been dealing with this recall for nearly 6 months. As per your website states, a company or manufacturer must fix or offer a solution in a reasonable time period. I feel 6 months is long enough to find a part. Please help. I want my car safe for my family. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S
For several years, my vehicle has had an issue with "extended brake pedal travel," making it more difficult to come to a stop with a reasonable effort, and increasing the likelihood of an accident. My vehicle has already been repaired for a prior recall regarding "extended brake pedal travel" (this "repair" did not fix this problem; in fact, it apparently passed the Ford-developed test, thus warranting no significant repair. My father is a Ford automotive technician and he was also surprised by this result. I suspect the Ford-developed "test" to determine whether there is indeed a problem was developed in Ford's favor and does not ensure the safety of the customer/driver.
The contact owns a 2008 Mercury Milan. The contact stated that he had initially received a recall notice for NHTSA Campaign Number: 17V024000 (Air Bags) and had the vehicle serviced at a dealer. Despite the recall repair, the passenger’s and driver’s side air bag warning lights illuminated. The contact also stated that the ABS warning light was also illuminated on the instrument panel. The contact had yet to experience a brake failure despite the warning light. The contact received notification of NHTSA Campaign Number: 21V158000 (Air Bags) and 19V904000 (Service Brakes, Hydraulic) however, the parts for the recall repairs were unavailable. The manufacturer had been notified of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was approximately 139,000. VIN tool confirms parts not available.
The contact owns a 2008 Mercury Milan. The contact stated the vehicle was repaired under NHTSA Campaign Number: 19V904000 (Service Brakes, Hydraulic) however, while she was driving 10 MPH, the brake pedal was depressed but felt soft and remained on the floorboard. The contact stated she continued to pump the brake pedal until it became firm. There were no warning lights illuminated. The vehicle was taken to the dealer who diagnosed that the parts used for the recall repair had failed. The manufacturer was notified of the failure and informed the contact that she would be responsible for the cost of the repair. The vehicle was not repaired. The approximate failure mileage was 68,000.
The contact's mother owns a 2008 Mercury Milan. The contact stated that while depressing the brake pedal, the pedal depressed to the floorboard without warning. The contact had initially taken the vehicle to an independent mechanic who informed her that the vehicle was included in NHTSA Campaign Number: 19V904000 (Service Brakes, Hydraulic). The contact had taken the vehicle to a dealer where the recall repair was performed. Upon return of the vehicle, the contact stated that the brake pedal again depressed to the floorboard without warning. The contact immediately took the vehicle back to the independent mechanic where he inspected the vehicle; however, the vehicle had yet to be repaired. The manufacturer was notified of the failure and they informed her to take the vehicle back to the dealer. The vehicle had yet to be repaired. The failure mileage was approximately 53,000.
The contact owns a 2008 Mercury Milan. The contact stated that the speedometer would intermittently fluctuate while driving at various speeds without warning. Despite the speedometer failure, the vehicle would resume normal driving operation. Recently, the contact stated that the failure would occur each time while operating the vehicle. The contact had taken the vehicle to an independent mechanic who stated that the failure could be related to the speed sensor or the computer. The contact then took the vehicle to a dealer who informed him that the failure could be related to a module inside the instrument cluster. The contact had also taken the vehicle to FleetSide Ford, LLC. (1120 Jeffreys Dr, Osceola, IA 50213) where they informed him that they had never heard of such failure. The manufacturer was notified of the failure and informed him that they had never heard of such a failure. No further assistance was provided. The vehicle had yet to be repaired. The failure mileage was 163,188
The contact owns a 2008 Mercury Milan. The contact received notification of NHTSA Campaign Number: 19V904000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and informed the contact that parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Vin tool confirms parts not available.
The contact owns a 2008 Mercury Milan. The contact stated while driving 15 mph and approaching a traffic light, when depressing the brake pedal to the floor but failed to stop. The contact stated no warning light was illuminated. The contact stated he crashed into the curb and bent the front passenger side rim which blew out the tire causing the vehicle to be able to come to a stop. The contact stated the vehicle came to a stop. The air bags did not deploy. The contact stated he sustained injuries on both knees and his chest. The contact did not seek medical attention. A police report was not filed. The vehicle was not drivable. The contacts uncle towed the vehicle to the uncle's residence. The contact was able to replace both front driver and passenger tires, the front passenger side rim, and the motor mount. A dealer was not contacted. The vehicle was not diagnosed. The contact, later on, received notification of NHTSA Campaign Numbers: 19V904000 (SERVICE BRAKES, HYDRAULIC) and 21V158000 (AIR BAGS), however, the part to the recall was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 169,000. VIN tool confirms part not available. Consumer stated vehicle has not been repaired. * (RECALL RELATED INCIDENT) TS
NHTSA Recall Number19V904 Recall StatusRecall Incomplete, remedy not yet available Summary ON My VEHICLE, A VALVE IN THE HYDRAULIC CONTROL UNIT OF THE ANTI-LOCK BRAKING SYSTEM MAY BE STUCK OPEN. Took it to the North Park Lincoln dealer on 23 Apr 2021 and they don't have the part for this recall. Said my inspection for this recall failed and they notified Ford. It's been over 60 days and I am still waiting on this part. My car is not safe to drive as my brakes are very low and its taking longer to slow the car down So my car is basically not being used for fear that the brakes might go out. No one seems to be able to gove me an answer as to when this recalled part will be in. I received the recall letter from Ford telliing me about this recall but letter also said the parts were available and that is why I took it to the dealer. Now Im being told still on backorder no idea when part will be received. This causes a problem for me if I can't really use this car because of the Safety Risk THIS MAY RESULT IN EXTENDED BRAKE PEDAL TRAVEL REQUIRED TO STOP THE VEHICLE, INCREASING THE RISK OF A CRASH. There are no warning lights yet displayed.
Frame Rail corrosion, noticed by dealer while having other recall service performed, they took photos since they hadn't seen this on a Milan, Fusion, or MKZ. I am now concerned with the car's safety.
2008 Mercury Milan. Consumer writes in regard to NHTSA Safety Recall 19V-904. THE CONSUMER REQUESTED TO BE REIMBURSED FOR REPAIRS MADETO THE VEHICLES.
I have been notified by Ford Motor Company several times about the recalls on my vehicle. One recall is for airbags. I went to the closest dealership new my small town and thought they issued the fix, only to learn later that they just disconnect the airbag light. The second recall is for the brakes, I have been calling since January of 2021 to request a service date only to be told they have no knowledge of the recall. On march 30,2021 I finally got a service date and express to the representative on the phone to assure that she knew it was for the break recall 19S54, she assured me the knew. I took off work that morning for by service appointment only to be told that they did not have the equipment to fix the issue. I was told to call other dealerships and turned away. I called 4 surrounding dealerships with in a 50 mile radius only to be told no one can perform the procedure. I then called ford Customer Relationship Center for assistance. She called one other dealership that said they could not fix the issue as well. April 2020 I receive a letter from Ford Motor Company saying Parts are now available to repair you vehicle. Called dealership 5/17/2021 they still cannot fix issue nor have any information on who can. HELP! Ford Motor Company, How can I get the recalls fix if none of your dealerships in my area are capable of repairing them?
TL* THE CONTACT OWNS A 2008 MERCURY MILAN. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 19V904000 (SERVICE BRAKES, HYDRAULIC) AND 21V158000 (AIR BAGS) HOWEVER, THE PARTS TO DO THE RECALL REPAIRS WERE UNAVAILABLE. KELLER FORD INC., LOCATED AT 3385 ALPINE AVE NW, GRAND RAPIDS, MI 49544 AND THE MANUFACTURER WERE CONTACT AND CONFIRMED THAT THE PARTS WERE NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
TL* THE CONTACT OWNS A 2008 MERCURY MILAN. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V904000 (SERVICE BRAKES, HYDRAULIC) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. STEVEN'S 112 FORD (507 NY-112, EAST PATCHOGUE, NY 11772) WAS CONTACTED AND IT WAS CONFIRMED THAT THE PART WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND REFERRED THE CONTACT TO A LOCAL DEALER. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
THE RECALL 19V904 HAS BEEN UNRESOLVED NOW FOR 16 MONTHS. MY BRAKE PEDAL MUST BE PUSHED ALL THE WAY TO THE FLOOR TO STOP THE VEHICLE. MY TAGS HAVE BEEN EXPIRED FOR 11 MONTHS BECAUSE I CAN'T PASS AN INSPECTION. I HAVE NO OTHER OPTION BUT TO DRIVE THE VEHICLE TO WORK AND NOW I'M PAYING TICKETS FOR EXPIRED TAGS. FORD IS WORTHLESS TO SPEAK TO ABOUT IT.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .