2008 MINI Cooper S Clubman

In a January 10, 2012 letter to NHTSA, BMW of North America, LLC. (BMW) submitted a Defect Information Report (DIR) identifying a defect in the electric auxiliary water pump in approximately 88,911 model year (MY) 2007-2011 Mini Cooper vehicles manufactured from November 14, 2006 through January 18, 2011 (Recall 12V-008).According to BMW, the auxiliary water pump on vehicles equipped with 4-cylinder turbocharged engines may overheat.Electro-migration can cause the pump electronic circuit board to overheat resulting in smoldering of the water pump. If smoldering occurs, it may lead to an engine compartment or vehicle fire.The pump supplier, Pierburg Pump Technology GmbH, redesigned the pump to address factors that may contribute to circuit board overheating.The redesigned pumps were completely implemented in production vehicles by January 2011.Recall 12V-008 was the third recall initiated by BMW to address electric auxiliary water pump fires in vehicles equipped with Pierburg pumps.In two October 20, 2011 letters to NHTSA, BMW submitted DIRs for similar auxiliary water pump defect conditions in approximately 32,084 MY 2008-2011 BMW 5-Series, 7-Series, X5 and X6 models equipped with 8- and 12-cylinder engines and manufactured from May 2008 through December 2010 (Recall 11V-521); and for approximately 589 MY 2010 Rolls-Royce Ghost vehicles manufactured from September 2009 through September 2010 (Recall 11V-522).In three separate April 5, 2012 letters to NHTSA, BMW submitted amendments to Recalls 11V-521, 11V-522 and 12V-008.The amendments all described a common defect condition related to a manufacturing process deviation in a certain production range of the redesigned Pierburg water pumps that could result in cracks in the pump housing, which may allow coolant to enter and contact the pump?s circuit board.BMW indicated that further analysis identified a specific machine process error at the sub-supplier that manufactures the water pump housing.Pump housing cracks may cause the circuit board to overheat and lead to smoldering of the water pump.Recall 12V-008 was, thus, amended to include approximately 1,457 MY 2011 Mini Cooper vehicles manufactured from March 31, 2011 through April 22, 2011, when pumps manufactured with the suspect manufacturing process may have been used in vehicle assembly.The amendment to Recall 11V-521 was assigned a new recall number, Recall 12V-161, and covered approximately 2,846 MY 2011-2012 BMW 5-Series, 6-Series, 7-Series, X5, and X6 vehicles manufactured from April 1, 2011 through August 1, 2011.The amendment to Recall 11V-522 was assigned a new recall number, Recall 12V-166, and covered approximately 69 MY 2011 Rolls-Royce Ghost vehicles manufactured from April 7, 2011 through June 2, 2011.The Office of Defects Investigation (ODI) analyzed complaint data provided by BMW as well as complaints submitted to ODI from consumers. In total, there were 30 unique Mini Cooper reports indicating engine fire.In addition, BMW provided warranty data showing 493 claims for replacement of the subject component on Mini Cooper vehicles.Owners of the recalled vehicles are notified to take their vehicle to a BMW dealer, who will replace the auxiliary water pump to prevent any incidents related to this issue.This preliminary evaluation is closed.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers (ODI Nos.):10286597, 10286663, 10289793, 10310677, 10314796, 10342365, 10394808, 10394192, 10403982, 10418325, 10422646, 10429003.

AIR BAG LIGHT HAS BEEN LIT SINCE AROUND 2014. FOR SOME REASON MY 2008 MINI VIN IS NOT PART OF THE 2005-2008 MINI AIRBAG RECALL. WHAT SHOULD I DO, AS THIS ISSUE SHOULD BE PART OF THE RECALL.

NHTSA ID

11708471

Incident

Jan 1, 2026

THE AIR BAG WARNING LIGHT HAS BEEN SET OFF FOR MANY YEARS AND COMES BACK EVEN AFTER A COMPUTER REPLACEMENT. THIS IS THE LIGHT FOR THE PASSENGER BAG. THERE WAS A RECALL OF 2005 TO 2008 MINI FOR THIS EXACT ISSUE. FOR SOME REASON MY VIN IS NOT INCLUDED IN THIS RECALL. WHAT SHOULD I DO? THE AIRBAG OR SENSOR WAS NEVER "FIXED".

NHTSA ID

11708468

Incident

Jan 1, 2026

I WAS HEARING A LOUD RATTLE AND BROUGHT MY MINI IN TO GET SERVICED RIGHT AWAY. IT WAS MISDIAGNOSED AND NOW I FEAR IT HAS CAUSED SIGNIFICANT DAMAGE TO THE ENGINE DUE TO A TIMING CHAIN TENSIONER ISSUE. THE CAR WILL LOSE POWER OUT OF NOWHERE. I HAVE READ THAT THIS IS NOT BEING CONSIDERED A SAFETY ISSUE BUT WHEN YOU LIVE IN MINNESOTA AND ARE TRYING TO GO THROUGH A BUSY INTERSECTION DURING A BLIZZARD AND THE CAR LOSES ALL POWER AND YOU ALMOST GET T-BONED BY A TRUCK I WOULD TEND TO DISAGREE. *TR

NHTSA ID

10664266

Incident

Oct 1, 2014

Mileage

146,000 mi

WHILE DRIVING HOME ON SECONDARY ROAD, A LOUD ENGINE NOISE STARTED AND THE ENGINE LIGHT CAME ON BLINKING. I PULLED OVER AND HAD CAR TOWED TO MY GARAGE. THE DIAGNOSIS WAS THAT THE TIMING CHAIN TENSIONER BROKE AND HAD TO BE REPAIRD. THIS WAS DONE FOR A COST OF $567.97. IN RESEARCHING INFORMATION ABOUT THIS, IT APPEARS MANY OWNERS HAVE HAD THE SAME PROBLEM. I AM FILING THIS COMPLAINT IN HOPES THAT BMW REIMBURSES THIS EXPENSE FOR AN ISSUE THEY SEEM TO BE AWARE OF BUT ARE NOT TAKING RECALL ACTION WITH. *TR

NHTSA ID

10648667

Incident

Oct 1, 2014

Mileage

88,512 mi

AIR BAG LIGHT GOES OFF WITH CODE 93B1 PASSENGER HEAD AIRBAG NOT PRESENT. MINI KNOWS THIS IS AN ISSUE AS IT HAS ISSUED A TECHNICAL SERVICE BULLETIN FOR THIS ISSUE. THE TSB NUMBER IS SI-M-65-10-08. THIS IS A SERIOUS ISSUE AND SHOULD BE RECALLED. *TR

NHTSA ID

10520269

Incident

Jun 9, 2013

Mileage

28,000 mi

ENGINE TIMING CHAIN BROKE WHILE DRIVING BECAUSE OF A FAULTY PLASTIC TENSIONER PIECE BRAKING. THIS ISSUE HAS SURFACED REPEATEDLY GLOBALLY, BUT NO RECALL ISSUED. THIS NEEDS TO BE RECALLED, IT IS CLEARLY A SAFETY ISSUE AND BECAUSE OF ONE SMALL LITTLE PLASTIC FAULTY PART COST ME CLOSE TO $5000. MINI/BMW NORTH AMERICA DOES NOT ACKNOWLEDGE THIS ISSUE NOR WANTS TO REIMBURSE ME FOR THE EXPENSES INCURRED TO KEEP DRIVING SAFELY. *TR

NHTSA ID

10492944

Incident

Jun 13, 2012

Mileage

92,000 mi

THE TRANSMISSION IN MY CAR IS GOING OUT AT ONLY 53 THOUSAND MILES... EVERY TIME I GOT TO TURN OFF MY CAR THE LIGHT POPS ON SAYING THEIR IS A ISSUE WITH MY TRANSMISSION..IT ALSO TAKES ME TURNING OFF MY CAR AND BACK ON FOR IT TO GET UN STUCK OUT OF PARK.. IM GETTING FED UP AND FEAR THAT SOMETHING WORSE WILL HAPPEN WITH MY CAR WHEN MY CHILD OR HUSBAND IS IN THE CAR WITH ME.. I'VE ONLY HAD THIS CAR A YEAR AND ALREADY PUT $1200 INTO A WATERPUMP AND THERMOSTAT WITH HOUSING ... AND THAT WAS HARDSHIP ON ME. *TR

NHTSA ID

10478895

Incident

Sep 28, 2012

Mileage

53,225 mi

I CAME HOME FROM WORK AND PARKED THE CAR IN HIS NORMAL PARKING SPACE ON THE BLACK TOP. I TURNED OFF THE CAR, PUT THE VEHICLE IN GEAR WITH THE PARKING BRAKE AND LOCKED THE DOOR. A MINUTE LATER, THE VEHICLE WAS ON FIRE. THE FIRE DEPT REPORT WAS UNABLE TO DETERMINE IF THERE WAS A KEY LEFT IN THE IGNITION.

NHTSA ID

10458361

Incident

Mar 8, 2012

Mileage

35,000 mi

Customer complains of a musty odor or damp front footwell carpet.

MINI electrical systems have continued to develop over the past few years. As a result, the demand on the batteries has increased. Breakdowns due to an empty battery or problems in the vehicles electrical system can have various causes, most of which are not due to the battery itself. For this reason, a battery replacement will permanently eliminate the problem only in the rarest of cases. The energy diagnosis test module helps to localize these causes. This document covers important information for the dealer on how to handle “discharged battery” complaints. Without performing the energy diagnosis test plan, the root cause of a discharged battery cannot be identified. In order to properly repair the vehicle the first time, it is very important that the diagnostic test plan is performed to completion; with all results taken into consideration.

New RDC wheel electronics will be introduced with future generation MINI models. The new wheel electronics are identified as Huf Generation 5. These new wheel electronics will need to be programmed using the new tool when replaced or when depressurized (0 psi) for more than 2 minutes.

OC3 SEAT OCCUPANCY MAT - LIMITED WARRANTY EXTENSION TO 10 YEARS/120,000 MILES: Component-Specific Limited Warranty Extension For the above-referenced vehicles, MINI USA, a division of BMW of North America, LLC (MINI USA) is extending the limited warranty for the front passenger's OC3 seat occupancy mat (shown) to: 10 years/120,000 miles as determined by the vehicle's original in-service date.

CLASS ACTION SETTLEMENT: N14 HIGH-PRESSURE FUEL PUMP (HDP) SERVICE BENEFIT CLASS VEHICLES: The MINI vehicle may experience a sudden engine operational failure reduced or loss of power while driving and the malfunction indicator lamp (MIL) may be illuminated along with high-pressure fuel pumprelated faults stored in the Engine Control Module (DME). PROCEDURE Perform the corresponding diagnosis/vehicle test and run the test plans to completion as applicable.

Air Conditioning System Leak Testing. The customer complains of poor or no air conditioning cooling. After further diagnosis, the system is found to be low or empty of a refrigerant charge, but when using an electronic leak detector, no leak can be found. CAUSE: In most cases, an electronic leak detector is not sufficient for identifying small leaks in the system. Electronic leak detectors can give false alarms and can lead to an improper diagnosis of small leaks. A leak cannot be located exactly if accessibility is impaired (in the case of the expansion valve, evaporator or condenser).