2011 MINI Cooper S Clubman

In a January 10, 2012 letter to NHTSA, BMW of North America, LLC. (BMW) submitted a Defect Information Report (DIR) identifying a defect in the electric auxiliary water pump in approximately 88,911 model year (MY) 2007-2011 Mini Cooper vehicles manufactured from November 14, 2006 through January 18, 2011 (Recall 12V-008).According to BMW, the auxiliary water pump on vehicles equipped with 4-cylinder turbocharged engines may overheat.Electro-migration can cause the pump electronic circuit board to overheat resulting in smoldering of the water pump. If smoldering occurs, it may lead to an engine compartment or vehicle fire.The pump supplier, Pierburg Pump Technology GmbH, redesigned the pump to address factors that may contribute to circuit board overheating.The redesigned pumps were completely implemented in production vehicles by January 2011.Recall 12V-008 was the third recall initiated by BMW to address electric auxiliary water pump fires in vehicles equipped with Pierburg pumps.In two October 20, 2011 letters to NHTSA, BMW submitted DIRs for similar auxiliary water pump defect conditions in approximately 32,084 MY 2008-2011 BMW 5-Series, 7-Series, X5 and X6 models equipped with 8- and 12-cylinder engines and manufactured from May 2008 through December 2010 (Recall 11V-521); and for approximately 589 MY 2010 Rolls-Royce Ghost vehicles manufactured from September 2009 through September 2010 (Recall 11V-522).In three separate April 5, 2012 letters to NHTSA, BMW submitted amendments to Recalls 11V-521, 11V-522 and 12V-008.The amendments all described a common defect condition related to a manufacturing process deviation in a certain production range of the redesigned Pierburg water pumps that could result in cracks in the pump housing, which may allow coolant to enter and contact the pump?s circuit board.BMW indicated that further analysis identified a specific machine process error at the sub-supplier that manufactures the water pump housing.Pump housing cracks may cause the circuit board to overheat and lead to smoldering of the water pump.Recall 12V-008 was, thus, amended to include approximately 1,457 MY 2011 Mini Cooper vehicles manufactured from March 31, 2011 through April 22, 2011, when pumps manufactured with the suspect manufacturing process may have been used in vehicle assembly.The amendment to Recall 11V-521 was assigned a new recall number, Recall 12V-161, and covered approximately 2,846 MY 2011-2012 BMW 5-Series, 6-Series, 7-Series, X5, and X6 vehicles manufactured from April 1, 2011 through August 1, 2011.The amendment to Recall 11V-522 was assigned a new recall number, Recall 12V-166, and covered approximately 69 MY 2011 Rolls-Royce Ghost vehicles manufactured from April 7, 2011 through June 2, 2011.The Office of Defects Investigation (ODI) analyzed complaint data provided by BMW as well as complaints submitted to ODI from consumers. In total, there were 30 unique Mini Cooper reports indicating engine fire.In addition, BMW provided warranty data showing 493 claims for replacement of the subject component on Mini Cooper vehicles.Owners of the recalled vehicles are notified to take their vehicle to a BMW dealer, who will replace the auxiliary water pump to prevent any incidents related to this issue.This preliminary evaluation is closed.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers (ODI Nos.):10286597, 10286663, 10289793, 10310677, 10314796, 10342365, 10394808, 10394192, 10403982, 10418325, 10422646, 10429003.

When I bought the car, John, a sales representative, promised me that he would have the car inspected by a mechanic before finalizing the paperwork, addressing issues with the tire pressure monitor, tail light sensor, and license plate light. However, the mechanic couldn't fix these issues, and Mike, the owner, directed me to his “personal mechanic” in San Bruno. After multiple reschedules from Mike, the car began to display an engine malfunction error. I informed Mike, and he advised me to mention the issue to the mechanic when I brought the car in. When I finally took the car to his mechanic, I was told that there were no errors, but the error lights needed to be reset at a different shop, as the mechanic didn’t have the required equipment. Despite this, the engine malfunction light remained on, and the car started to shake noticeably while driving. A few weeks later, while driving, the car began emitting white smoke from the hood. I texted Mike, asking why the issues weren’t fixed, and I had to tow the car to my house. He did not respond, so I called him days later. He told me to call back after New Year's to have the car fixed, even offering to tow it to his mechanic. After New Year's, I followed up, but Mike forgot about the original arrangement and told me to call back in a week. I reminded him of our previous conversation, and he said he would check with his mechanic and call me back. He never did and ignored my follow-up text. On 01/21/2025, I had a mobile mechanic inspect the car, as it had not been operable since December 2024. The mechanic confirmed that the car had never been tuned, the spark plugs weren’t replaced, and it was not roadworthy at the time of sale. On 01/22/2025, I shared my experience in reviews on Yelp and Google. Later that night, Mike called me, but I returned his call on 01/23/2025. He said that if I removed my reviews, dropped my complaints with the DMV, BAR, and Attorney General, he would fix the car at his expense.

NHTSA ID

11638064

Incident

Nov 19, 2024

MINI/BMW ISSUED RECALL INFORMATION MAY OF 2023 FOR THE FRM ELECTRONIC CONTROL UNIT, AS OF 12/30/2024 THEY ARE STILL UNABLE TO REPAIR THE VEHICLE, TOYOTA WEBSITE SAYS THEY ARE STILL WORKING ON A RESOLUTION. DEALERS OFFER NO SOLUTION TO PROBLEM. IT HAS BEEN A YEAR SINCE RECALL WAS ISSUED. NHTSA Recall Number - 23V337

NHTSA ID

11633027

Incident

Dec 30, 2024

The contact owns a 2011 Mini Cooper S Clubman. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11580147

Incident

Mar 29, 2024

The contact owns a 2011 Mini Cooper S Clubman. The contact stated that water was entering the motherboard and fuse box. While driving at an undisclosed speed, the vehicle stalled. The check engine warning light was illuminated. The vehicle failed to restart. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the failure was related to NHTSA Campaign Number: 23V337000 (Electrical System). The manufacturer was contacted. The failure mileage was approximately 50,000.

NHTSA ID

11534408

Incident

Mar 1, 2020

Mileage

50,000 mi

THE PASSENGERS SEAT OCCUPANCY DETECTOR IS NOT FUNCTIONING AND IT WON'T ALLOW ANY AIRBAG TO ACTIVATE. THE PASSENGER AIRBAG LIGHT IS CONSTANTLY ON AND IT IS A SAFETY HAZARD. THIS IS A COMMON PROBLEM WITH THESE CARS, AND NO RECALL HAS BEEN ISSUED.

NHTSA ID

11395359

Incident

Jul 31, 2018

Mileage

54,000 mi

I WAS TRYING TO MAKE A RIGHT TURN GOING ON A 35MPH STREET AND MY CAR DID NOT TURN RIGHT WHEN I TRIED TO GO INTO A STREET AND IT WENT STRAIGHT INTO A TREE AND MY CAR WAS ALMOST OR MAY BE TOTALED BECAUSE OF THIS. I BELIEVE THE STEERING WHEEL WAS FAULTY. I COULD HAVE HIT A CONCRETE WALL BUT THE TREE I RAN INTO SAVED MY LIFE. I AM NOT SURE IF THERE HAS BEEN OTHER REPORTS FOR THIS LATELY BUT I WANT TO BE SAFE AND IF THE STEERING WHEEL DID NOT FUNCTION RIGHT THEN I BELIEVE THERE SHOULD BE A RECALL FOR THIS.

NHTSA ID

11104507

Incident

Jun 27, 2018

Mileage

99,999 mi

ONLY HAD THIS VEHICLE FOR 6 MONTHS. ON THE WAY TO THE MINI OF SAN DIEGO DEALERSHIP TO GET AN OIL CHANGE, THE CAR SHUTS DOWN AS I STOPPED AT A RED LIGHT. I WAS STILL IN MOTION AND ON THE STREET. I WAS COMING OFF THE HIGHWAY. I TRIED RESTARTING THE CAR. I WAS IN THE MIDDLE OF THE STREET. THERE WERE OVERHEATING LIGHTS AND SMOKE A COUPLE OF DAYS BEFORE SO DISCONTINUED DRIVING THE VEHICLE UNTIL MY APPOINTMENT WITH MINI OF SAN DIEGO. THE DAY OF THE APPOINTMENT, THERE WAS NO INDICATION LIGHT OF OVERHEATING. THE DEALERSHIP WAS ONLY 15 MINS AWAY FROM MY HOME. I ALSO FOUND THAT THE MODEL OF MY VEHICLE WAS RECALLED FOR THE SAME REASONS THAT MY CAR IS CURRENTLY IN THE SHOP FOR CURRENTLY. MINI OF SAN DIEGO IS TELLING ME THERE'S NO RECALL ON MY CAR BASED OFF THE VIN NUMBER. BUT BASED OFF THE YEARS AND MODEL, MY CAR FITS INTO THE RECALL.

NHTSA ID

11061437

Incident

Jan 8, 2018

Mileage

77,200 mi

4 FAULTY IGNITION COILS WITHIN 3 MONTHS: CYLINDERS #1 & # 2 HAD TO BE REPLACED ON 4/7/17 CYLINDERS #3 & #4 ON 7/4/17. FIRST INCIDENT OCCURRED WHEN I WAS PULLING INTO ONCOMING TRAFFIC AND RESULTED IN COMPLETE LOSS OF ENGINE POWER. THE SECOND INCIDENT HAPPENED ON THE HIGHWAY WHILE CHANGING LANES, AGAIN COMPLETE LOSS OF ENGINE POWER AND NEARLY CAUSED ME TO BE HIT BY A SEMI-TRUCK. I NARROWLY ESCAPED AN ACCIDENT IN FIRST INCIDENT AS WELL. I DO NOT FEEL SAFE DRIVING MY CHILDREN IN THIS CAR ANY LONGER. EACH TIME THE PARTS AND LABOR COST MORE THAN $300, NOT TO MENTION THE AGGRAVATION OF BEING WITHOUT A CAR FOR WORK AND FAMILY TRANSPORTATION FOR SEVERAL DAYS. THIS IS NOT WHAT I EXPECTED FROM A QUALITY AUTOMOBILE MADE BY BMW. DOCUMENTATION/INVOICES CAN BE PROVIDED UPON REQUEST.

NHTSA ID

11002796

Incident

Jul 3, 2017

Mileage

41,128 mi

While performing a 12-Volt battery jump start, disconnect, or replacement, vehicle test, and/or programming procedure- the MINI Footwell Module (FRM) may become unresponsive. As a result, one or more of the following vehicle electric system-related issues may occur: Headlights including the high beams, and/or taillights are not turning on or off Interior lights are not turning on Turn indicators are not working Instrument cluster indicator lights stay on The IHKA climate control system is not working Power windows are not working Folding mirrors are not working, and/or a Functional remote-control key FOB will not unlock and lock the doors

Customer complains of a musty odor or damp front footwell carpet.

MINI electrical systems have continued to develop over the past few years. As a result, the demand on the batteries has increased. Breakdowns due to an empty battery or problems in the vehicles electrical system can have various causes, most of which are not due to the battery itself. For this reason, a battery replacement will permanently eliminate the problem only in the rarest of cases. The energy diagnosis test module helps to localize these causes. This document covers important information for the dealer on how to handle “discharged battery” complaints. Without performing the energy diagnosis test plan, the root cause of a discharged battery cannot be identified. In order to properly repair the vehicle the first time, it is very important that the diagnostic test plan is performed to completion; with all results taken into consideration.

New RDC wheel electronics will be introduced with future generation MINI models. The new wheel electronics are identified as Huf Generation 5. These new wheel electronics will need to be programmed using the new tool when replaced or when depressurized (0 psi) for more than 2 minutes.

OC3 SEAT OCCUPANCY MAT - LIMITED WARRANTY EXTENSION TO 10 YEARS/120,000 MILES: Component-Specific Limited Warranty Extension For the above-referenced vehicles, MINI USA, a division of BMW of North America, LLC (MINI USA) is extending the limited warranty for the front passenger's OC3 seat occupancy mat (shown) to: 10 years/120,000 miles as determined by the vehicle's original in-service date.

CLASS ACTION SETTLEMENT: N14 HIGH-PRESSURE FUEL PUMP (HDP) SERVICE BENEFIT CLASS VEHICLES: The MINI vehicle may experience a sudden engine operational failure reduced or loss of power while driving and the malfunction indicator lamp (MIL) may be illuminated along with high-pressure fuel pumprelated faults stored in the Engine Control Module (DME). PROCEDURE Perform the corresponding diagnosis/vehicle test and run the test plans to completion as applicable.