2006 MINI Cooper S Electrical Problems

TL* THE CONTACT OWNS A 2006 MINI COOPER S. THE CONTACT STATED THAT WHILE IN PARK, THE VEHICLE FAILED TO START. IN ADDITION, THE CONTACT STATED THAT WHILE REVERSING AT A LOW SPEED, THE STEERING WHEEL WAS DIFFICULT TO TURN. THE CONTACT HAD TO APPLY FORCE TO THE STEERING WHEEL IN ORDER TO STEER THE VEHICLE. ONCE IN PARK, THE VEHICLE FAILED TO TURN OFF WITH THE KEY IN THE OFF POSITION. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE POWER STEERING MOTOR HAD FAILED AND MELTED. THE POWER STEERING MOTOR, WIRES, BATTERY, PUMP, FAN, PRESSURE HOSE AND ALTERNATOR WERE REPLACED. AFTER REPAIRS, THE MECHANIC WAS UNABLE TO DIAGNOSE THE VEHICLE USING THE DIAGNOSTIC TOOL. THE VEHICLE WAS THEN TAKEN TO A DEALER WHO STATED THAT THE WIRING HARNESS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS AWARE OF NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING) BUT THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 98,000.

NHTSA ID

10864096

Incident

Apr 10, 2016

Mileage

98,000 mi

I WAS DRIVING ON THE ROAD MY I TURNED THE AC ON AND ABOUT 20MIN OF ME RIDING IN THE VEHICLE ME AND MY INFANT SON MY MY VEHICLE STARTED SMOKING UNDER THE HOOD HEAVY WHITE SMOKE UNDER THE HOOD OF THE 2006 MINI COOPER S. MY CAR BEGAN TO LOOSE POWER WHILE ENGINE BAY STILL HEAVILY SMOKING I MANAGED TO GET CAR IN A NEARBY DEALERSHIP GET MY SON AND I OUT OF THE CAR I PUT WATER ON THE SIDE OF THE ENGINE THAT WAS BURNING TO KEEP THE REST OF THE CAR FROM BURNING UP.THE REST OF THE CAR I HAD TO CALL MY INSURANCE COMPANY THE CAR WONT DO ANYTHING AT ALL THE ELECTRIC SYSTEM OR THE WIRES BURNT UNDER THE HOOD.

NHTSA ID

10716604

Incident

May 14, 2015

Mileage

71,056 mi

ENGINE CRANKED BUT DID NOT START. AAA FLATBED TO MINI OF ALLENTOWN. RECEIVED CALL FROM DEALER POSSIBLE WATER DAMAGE TO ELECTRICAL, CONTINUING DIAGNOSIS. VEHICLE FRM FAILURE.

NHTSA ID

10716341

Incident

May 7, 2015

Mileage

82,200 mi

FRONTAL AIR BAG LIGHTS STAY ON.

NHTSA ID

10716339

Incident

May 1, 2015

Mileage

82,000 mi

THE PASSENGER SEAT AIR BAG LIGHT CAME ON AND WILL NOT GO OFF. I WAS ADVISED BY AN AUTHORIZED MINI COPPER MECHANIC THAT THE PASSENGER SEAT AIR BAG SENSOR IS BAD. IT'S MY UNDERSTANDING THAT MINI COOPER USA IS NOT OWNING UP TO THEIR RESPONSIBILITY TO RECALL AND REPAIR WHAT COULD POSSIBLY BE A LIFE SAFETY PROBLEM. THE LEATHER SEAT IS PRACTICALLY NEW AND THERE'S NO EXCUSE FOR THIS FAULTY AIR BAG SENSOR SEAT/EQUIPMENT. THERE WAS A RECALL FOR BMW'S WITH THE SAME ISSUE. IT'S VERY DISAPPOINTING. *TR

NHTSA ID

10692253

Incident

Mar 14, 2014

Mileage

46,220 mi

AIRBAG PASSENGER SEAT SENSOR IS BAD $1500 TO REPAIR AND NO GUARANTEE IT WILL WORK CORRECTLY IN THE FUTURE. WHY HASN'T THIS BEEN RECALLED??? BMW WHO OWNS MINI COOPER RECALLED THIS SENSOR FOR THEIR CARS BUT WHY NOT THE COOPERS? I'M SO ANGRY THAT THEY COULD CARE LESS ABOUT MY FAMILIES SAFETY. AUTOMOBILES ARE REQUIRED TO HAVE AIRBAG SYSTEMS BUT THEY AREN'T REQUIRED TO WORK PROPERLY?? *TR

NHTSA ID

10651954

Incident

Oct 1, 2014

Mileage

72,000 mi

I BOUGHT MY DAUGHTER A 2006 MINI COOPER S A LITTLE OVER A YEAR AGO. TODAY I DECIDED TO DRIVE IT TO WORK HERE AT FORT HOOD, TEXAS. A LITTLE OVER AN HOUR AFTER I GOT TO WORK I DECIDED TO GO GET BREAKFAST SO WHEN I WALKED OUT OF MY OFFICE I HEARD A CAR ALARM GOING OFF AND WHEN I ROUNDED THE CORNER I SAW MY DAUGHTER'S CAR BILLOWING SMOKE! I RAN INSIDE TO GET HELP AND WAS ABLE TO FIND TOOLS TO DISCONNECT THE BATTERY. I RAISED THE HOOD AND WAS MEET WITH A LOT OF HEAT, SMOKE AND A STRONG ODOR OF BURNT PLASTIC. THE CAR WASN'T RUNNING AND LIKE I STATED, HAD BEEN SITTING FOR OVER AN HOUR. AFTER CONDUCTING RESEARCH ONLINE I FOUND OUT MINI USA HAD RECALLED SEVERAL MINI COOPERS FOR THE POWER STEERING PUMP THAT HAD THE SAME EXACT SYMPTOMS. AFTER CALLING THE CLOSEST DEALERSHIP, AN HOUR AWAY, AND MINI USA I WAS TOLD THAT MY CAR WAS NOT PART OF THIS RECALL AND I AM LEFT TO PAY FOR THIS REPAIR MYSELF. THE DEALERSHIP QUOTED ME A COST OF $1000 TO REPLACE THE POWER STEERING PUMP. DURING MY ONLINE RESEARCH I HAVE FOUND MANY OTHER MINI OWNERS WITH THE SAME YEAR MODEL THAT HAD THE SAME PROBLEM. IT SEEMS THAT MINI USA ISN'T WANTING TO FULLY COVER THE REPAIRS. I AM GLAD I WASN'T DRIVING DOWN THE HIGHWAY WHEN THIS HAPPENED! *TR

NHTSA ID

10619109

Incident

Aug 5, 2014

Mileage

84,000 mi

AS I TURN ON THE ENGINE, BATTERY LIGHT CAME ON, 5 SECONDS LATER, ENGINE STARTED TO SMOKE. I TURNED OFF THE ENGINE. ENGINE WON'T TURN BACK ON AND LOST ALL POWER, STEERING WHEEL WON'T TURN. BEFORE THIS INCIDENT, GEAR WOULD SHIFT UP AND DOWN ON IT'S OWN WHILE I'M DRIVING. VERY DANGEROUS! *TR

NHTSA ID

10507380

Incident

Mar 27, 2013

Mileage

7,300 mi

THE O2 SENSOR FAILED ON MY CAR. MINI ISSUED AN EXTENDED WARRANTY ON 2006 MODELS BUT MY VIN WAS NOT INCLUDED. THIS IS RIDICULOUS THAT I HAVE THE EXACT SAME ISSUE BUT MY VIN IS NOT INCLUDED. *TR

NHTSA ID

10500699

Incident

Feb 22, 2013

Mileage

70,000 mi

DRIVING AT 55 MPH ON PARKWAY. ENGINE MADE CLUNK AND LOST POWER. PULLED CAR ONTO SHOULDER AND STARTED WITH WHITE SMOKE UNDER HOOD, PROGRESSING TO BLACK SMOKE AND FLAME. EXITED CAR AT FIRST SIGN OF SMOKE. CAR BURNED IN ENGINE COMPARTMENT, MOVED INTO CABIN. FINAL DAMAGE WAS A TOTAL. FRONT END OF CAR IS COMPLETELY BURNED. FIRE IN CABIN MELTED DASHBOARD, MOVED ACROSS AND MELTED CEILING, AND MELTED FRONT WINDSHIELD. TOOK PICTURES OF FINAL DAMAGES AT GARAGE FOLLOWING INCIDENT. *TR

NHTSA ID

10490161

Incident

Dec 26, 2012

THE PASSENGER SEAT OCCUPANCY SENSOR IS WEAK AND PRONE TO FAILURE. MINI DOES NOT COVER REPLACEMENT AND CHARGES $1200-$2000 TO REPLACE THE PART LEADING MANY OWNERS, INCLUDING MYSELF TO DRIVE THE CAR IN AN UNSAFE CONDITION (LOW SPEED OR NON DEPLOYING AIRBAGS). *TR

NHTSA ID

10479955

Incident

Oct 1, 2012

Mileage

80,000 mi

TRAVELING ON HIGHWAY AT 70MPH AND INSTRUMENT PANEL LIGHTS UP, SPEEDS DROPS TO MAXIMUM 30MPH CREATING UNSAFE DRIVING CONDITION. FIRST OCCURRENCE MARCH 2012 WAS DIAGNOSED AS FAILED "THROTTLE BODY", SECOND OCCURRENCE IN JULY 2012 WAS DIAGNOSED AS FAILED "WIRING HARNESS". *TR

NHTSA ID

10467218

Incident

Mar 25, 2011

Mileage

49,000 mi

TL* THE CONTACT OWNS A 2006 MINI COOPER S. THE CONTACT WAS TRAVELING 60 MPH WHEN ALL OF THE LIGHTS ALONG THE DASHBOARD ILLUMINATED AND THE VEHICLE ABNORMALLY ACCELERATED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE THE MECHANIC CONFIRMED THAT THE TACHOMETER NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED AND THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 54,000 AND THE CURRENT MILEAGE WAS 55,000. ..UPDATED 07/11/12 *BF THE CONTACT WAS TRAVELING 60 MPH WHEN ALL OF THE WARNING LIGHTS ON THE DASHBOARD ILLUMINATED. THE VEHICLE THEN CHANGED DOWN TO 2ND GEAR( THE VEHICLE HAS SIX FORWARD GEARS) CAUSING HUGE ACCELERATION AND THEN SLOWING OF THE VEHICLE OF THE VEHICLE. AFTER EXTENSIVE DIAGNOSTIC WORK BY THE MECHANIC, IT WAS DETERMINED THAT THE TACHOMETER HAD FAILED WHICH CAUSED THE VEHICLE TO DOWNSHIFT TO 2ND GEAR. THE FAILURE ALSO NECESSITATED THE REPLACEMENT OF THE TRANSMISSION.

NHTSA ID

10462775

Incident

May 2, 2012

Mileage

54,000 mi

EXECUTING A LEFT TURN AND ALL OF A SUDDEN THE POWER STEERING WENT OUT. WAS UNABLE TO CONTROL THE CAR DUE TO THE FACT THAT I WAS NOT EXPECTING THIS ISSUE. DAMAGE FRONT RIGHT SIDE OF CAR AGAINST CURB. I HAVE LEARNED THAT THIS IS A SERIOUS PROBLEM. THIS ISSUE NEEDS TO BE ADDRESSED ON A RECALL!

NHTSA ID

10458712

Incident

May 14, 2012

Mileage

78,000 mi

PLETHORA OF ELECTRICAL PROBLEMS. HEATED SEATS ARE A MAJOR CONCERN. THEY GO ON AND OFF BY THEMSELVES, SEEM HAUNTED. SOMETIMES, THEY GET SO HOT THEY LEAVE BURN MARKS IN MY LEGS. I AM AFRAID OF AN ELECTRICAL FIRE. THE HEATED SEATS GET SO HOT, THEY LEFT BURN MARKS IN MY SEAT. AISIN 6 SPEED AUTOMATIC TRANSMISSION, EQUIPPED WITH "LIFETIME" FLUID, BEGINS SLIPPING GEARS AT 70K THE SUPERCHARGER HAD TO BE REPLACED DUE TO THE "DESIGN" OF THE SUPERCHARGER IT COULD NOT BE REPAIRED, I WAS FORCED BY BMWUSA TO PURCHASE A REMANUFACTURED SUPERCHARGER. I WAS TOLD IT WAS A "COMMON PROBLEM" I HAVE ALSO FOUND OUT FROM FORUMS SUCH AS NORTHAMERICANMOTORING.COM THIS IS A PROBLEM THAT BMW DOES NOT WANT TO ADMIT ITS AT FAULT FOR HOWEVER THEY ARE ACKNOWLEDGING THE WIDESPREAD HAPPENINGS ACROSS THE COUNTRY. THE AVAILABILITY OF NEW SUPERCHARGERS IS VERY LOW BECAUSE OF THIS PROBLEM, HENCE ME PURCHASING A REMFGD ONE. REAR WIPER MOTOR FAILED AT 40K QUOTED HUNDREDS TO REPLACE, NOT WORTH IT!!!!! *TR

NHTSA ID

10440113

Incident

Dec 1, 2011

Mileage

60,000 mi

ON 29SEP2007, MY 2006 MINI COOPER S WAS SERVICED TO PERFORM THE LOW MILEAGE SERVICE AT 3,354 MILES. THE CAR WAS NOT DRIVEN ON 30SEP2007. ON 01OCT2007, THE CAR WAS DRIVEN A DISTANCE OF APPROXIMATELY ONE MILE EACH WAY TO A BUS STOP. THE CAR WAS PARKED OVERNIGHT IN THE GARAGE BENEATH MY TOWNHOUSE. AT 6:00 AM ON 02OCT2007, WHEN I WANT TO THE LOWER LEVEL OF MY TOWNHOUSE AND OPENED THE DOOR TO THE GARAGE, I SAW THAT THE GARAGE WAS FILLED A "FOGGY SMOKE" AND THERE WAS A "BURNING ODOR". THE POLICE WERE CALLED TO INVESTIGATE THE CAUSE OF THE SMOKE. AS THE SMOKE BEGAN TO SPREAD INTO THE UPPER LEVEL OF MY HOME, THE FIRE DEPT WAS CALLED AS BACK-UP. THE FIREMEN LOCATED THE SOURCE UNDER THE HOOD OF MY CAR AND DETERMINED THE SMOKE TO BE FROM A "BURNED POWER STEERING BELTON THE VEHICLE IN THE GARAGE". THE FIREMEN MOVED THE CAR TO THE PARKING LOT AND DISCONNECTED THE BATTERY. I WAS INSTRUCTED TO HAVE THE CAR TOWED TO THE DEALERSHIP. I TOLD THE DEALERSHIP THAT THIS VEHICLE WAS DEFECTIVE AND WOULD NO LONGER FEEL SAFE DIVING THE CAR. THEY AGREED TO REPLACE THE CAR WITH A NEW 2007 MINI COOPER S ([XXX]). I WAS LED TO BELIEVE THAT MINE WAS AN "ISOLATED INCIDENT" BUT HAVE NOW BECOME AWARE THAT OTHERS HAVE HAD SIMILAR PROBLEMS WITH MINI COOPER S FROM 2007-2009. WHEN I CONTACTED THE DEALER, I WAS ADVISED TO NOT PARK MY CAR IN THE GARAGE UNTIL THE CAUSE OF THE PROBLEM HAS BEEN DETERMINED OR IF THERE IS A RECALL. I NOW AM NOT PARKING IN THE GARAGE. I AM SUBMITTING THIS REPORT ON THE 2007 INCIDENT SINCE IT WAS NEVER REPORTED AND I AM AFRAID THAT THE RATE OF OCCURRENCE MAY BE UNDER-REPORTED. THANK YOU. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

10436509

Incident

Oct 2, 2007

Mileage

3,354 mi

I HAVE A 2006 MINI COOPER. RECENTLY, COMPLETE POWER TO THE VEHICLE HAS BEEN LOST WHILE THE VEHICLE IS IN OPERATION. THIS HAS OCCURRED TWICE OVER THE PAST MONTH. THE VEHICLE WAS BEING OPERATED ON A PAVED CITY STREET AT SPEEDS OF APPROXIMATELY 20-25 MILES PER HOUR WHEN THE POWER FAILURES OCCURRED. THE VEHICLE WAS REQUIRED TO BE BROUGHT TO A COMPLETE STOP BEFORE POWER TO THE VEHICLE COULD BE RESTORED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED MINI COOPER REPAIR CENTER (NIELLO MINI, SACRAMENTO, CA) ON 07/26/11. THE DEALERSHIP COULD FIND NO FAULTS WITH THE VEHICLE AND HAD US DRIVE THE VEHICLE OFF THE LOT "AS IS" WITH INSTRUCTIONS TO BRING IT BACK IN FOR FURTHER TESTING IF THE PROBLEM HAPPENED AGAIN. NEXT TIME COULD BE TOO LATE AS THIS PROBLEM COULD CAUSE AN ACCIDENT TO OCCUR. *TR

NHTSA ID

10415289

Incident

Jul 20, 2011

Mileage

69,000 mi

SUDDEN COMPLETE LOSS OF POWER STEERING. SEVERAL DAYS AFTER THE ORIGINAL BATTERY FAILED AND WAS REPLACED, THERE WAS A CONTINUING SOUND LIKE A FAN OR ELECTRIC MOTOR RUNNING CONSTANTLY. THIS NOISE CONTINUED UNTIL THE POWER STEERING CEASED COMPLETELY DURING A PARKING MANEUVER. AFTER THE STEERING FAILED THE PREVIOUSLY NOTED NOISE STOPPED.

NHTSA ID

10404713

Incident

May 7, 2011

Mileage

37,600 mi

I WAS DRIVING HOME FROM WORK AND THE CHARGE CIRCUIT LIGHT CAME ON AND I SMELLED A HEATED ELECTRICAL SMELL. THE POWER STEERING HAD CUT OUT, SHORTLY AFTER, THE ENGINE TEMPERATURE BEGAN TO RISE. I TURNED THE CAR OFF, THEN BACK ON AND DROVE HOME. AFTER SOME RESEARCH, IT SEEMS THAT THIS MODEL MINI COOPER HAVE POWER STEERING PUMPS THAT FAIL AROUND 70,000 MILES. I DROVE TO MY JOB ON SUNDAY, AND THE CAR MADE THE ROUND TRIP, EXCEPT JUST BEFORE GETTING HOME, THE FAILURE OCCURRED AGAIN. I HAVE NOT BEEN ABLE TO TAKE THE CAR TO A MECHANIC YET. *TR

NHTSA ID

10398440

Incident

Apr 30, 2011

Mileage

70,668 mi

DRIVING ON HIGHWAY ABOUT 60 MPH. EXTREMELY LOUD SCREECHING BURST OF SOUND OCCURRED. SOUND WAS SIMILAR TO SMOKE DETECTOR TEST SOUND, LASTING ABOUT A SECOND, BUT HORRIBLY LOUD, ESPECIALLY IN A SMALL ENCLOSED AREA WITH THE WINDOWS UP. NEARLY HAD AN ACCIDENT. OUR EARS HURT BADLY (I STILL FEEL SOME SORENESS A DAY LATER, AS I NOW WRITE. SIMILAR OCCURRENCES FOR MINI COOPER NOTED IN WEB FORUMS, REFERENCING A POSSIBLE STEREO AMPLIFIER PROBLEM. OUR RADIO WAS NOT ON. FORTUNATELY THE DEALER WAS OPEN (ON SUNDAY) AND WE HAVE AN APPOINTMENT SCHEDULED TODAY. FROM WHAT I'VE RESEARCHED ON THE INTERNET, WE ARE NOT THE ONLY ONES VICTIMIZED BY THIS ISSUE. WE ARE ACTUALLY FEARFUL AND UNCOMFORTABLE DRIVING THE CAR, WORRYING THAT AT ANY TIME THIS COULD OCCUR AGAIN. THIS IS AN UNNECESSARY HARDSHIP AND DISTRACTION THAT KEEPS US FROM PAYING FULL ATTENTION TO SAFELY DRIVING THE CAR. UNTIL THE DEALER CAN SPECIFICALLY EXPLAIN WHAT THE PROBLEM IS AND PERFORM WHATEVER WORK IS NEED TO GUARANTEE IT WON'T HAPPEN AGAIN, I DO NOT FEEL SAFE DRIVING THIS ONE-YEAR-OLD CAR, BEING CONCERNED THAT I'LL HAVE AN ACCIDENT IF IT HAPPENS AGAIN. THIS IS WITHOUT QUESTION A SERIOUS SAFETY ISSUE. IF I STILL FEEL SORENESS IN MY LEFT EAR LATER TODAY, I PLAN TO CONTACT MY DOCTOR. *TR

NHTSA ID

10232670

Incident

Jun 29, 2008

Mileage

13,000 mi

PURCHASED A 2007 MINI COOPER IN APRIL OF THIS YEAR, AND THERE ARE TWO ISSUES THEY REFUSE TO LOOK AT OR FIX: 1. THE SPEEDOMETER REGISTERS 7% FASTER THAN THE ACTUAL SPEED. 2. THE ODOMETER REGISTERS 1% MORE THAN THE ACTUAL MILEAGE. THEY CLAIM BOTH OF THESE ARE WITHIN ACCEPTABLE LEVELS. *JB

NHTSA ID

10198491

Incident

Jul 31, 2007

I HAVE A 2006 MINI COOPER JOHN COOPER WROKS GP. THE DSC (DIRECTIONAL STABILITY CONTROL), LOW TIRE WARNING LIGHT, AND ABS (ANTI LOCK BRAKING) WARNING LIGHTS CAME ON AS I TRAVELED ON THE INTERSTATE. NO INCIDENT OCCURRED TO CAUSE A FAILURE. THE ABS AND DSC SYSTEMS DO NOT WORK, OR WORK INAPPROPRIATELY. DISCUSSING THIS WITH OTHER MINI COOPER OWNERS WITH THE SO CALLED WORKS BRAKES, I FIND OUT IT IS A FREQUENT PROBLEM. *JB

NHTSA ID

10197562

Incident

Jul 20, 2007

Mileage

9,500 mi

DT*: THE CONTACT OWNS A 2006 MINI COOPER MODEL S. THREE DAYS AFTER PURCHASE AT 130 MILES THE VEHICLE STALLED AND OPERATED AT A REDUCED SPEED WHILE ATTEMPTING TO ACCELERATE. ALTHOUGH THE VEHICLE DID NOT STALL OUT COMPLETELY, THE VEHICLE WAS TOWED TO THE DEALER. THE DEALER REPROGRAMMED THE COMPUTER SOFTWARE. AFTERWARDS, THE CONTACT WAS PULLING INTO A PARKING SPACE WITH BRAKE PRESSURE APPLIED, THE ENGINE ROARED AND THE VEHICLE LURCHED FORWARD AND STRUCK A TREE. THE POLICE WERE ON THE SCENE AND A REPORT WAS TAKEN. THE VEHICLE SUSTAINED MINOR DAMAGE, BUT NO INJURIES WERE SUSTAINED. THE VEHICLE WAS TOWED TO A DEALER. THE DEALER PERFORMED A DIAGNOSTIC TEST AND WAS UNABLE TO DUPLICATE THE PROBLEM. THE SERVICE DEPARTMENT SUGGESTED REPLACING THE ENGINE. *AK UPDATED 3/3/2006 - *NM

NHTSA ID

10148982

Incident

Oct 15, 2005

Mileage

180 mi