2007 MINI Cooper S Owner Complaints

The contact owns a 2007 Mini Cooper S. The contact stated that water was entering the vehicle through the sunroof. The contact stated that the water was collecting inside the headliner and would overflow and leak down the driver’s and passenger’s side sun visors and into the electronics of the footwell. Additionally, the front driver’s and passenger’s seats, floorboards, and dashboard would become soaked from moisture. Due to the failure, the vehicle would fail to start or operate as needed. Upon investigation, the contact discovered NHTSA Campaign Number: 23V337000 (Electrical System); however, the VIN was not included in the recall. An independent mechanic was notified about the failure and the contact was advised to park the vehicle outside as the failure could cause the vehicle to catch on fire. The manufacturer was then notified of the failure and the contact was referred to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 140,000.

NHTSA ID

11658879

Incident

May 2, 2025

Mileage

140,000 mi

The contact owns a 2007 Mini Cooper S. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that while the vehicle was parked, the sunroof was inoperative. The contact waited for several minutes for the sunroof to return to normal operation. The "Passenger Air Bag Disabled" message was displayed on the instrument panel; however, the passenger’s seat was occupied. The infotainment system was unintentionally turned on while the vehicle was turned off. The check engine and low tire pressure warning light were intermittently illuminated. The failures occurred on several different occasions. The contact stated that there was no local dealer; a dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. Parts distribution disconnect.

NHTSA ID

11633249

Incident

Dec 30, 2022

The contact owns a 2007 Mini Cooper S. The contact stated that while driving approximately 35-40 MPH, the parking brake engaged, and the vehicle came to a stop. The contact manually pulled the parking brake lever several times until the parking brake released. There were no warning lights illuminated. The vehicle was taken to an independent mechanic, who was unable to determine the cause of the failure. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 48,000.

NHTSA ID

11524779

Incident

Jun 1, 2023

Mileage

48,000 mi

VEHICLE WAS STATIONARY IN MY DRIVEWAY, WAS NOT STARTED AND WAS UNATTENDED, HAD NOT BEEN STARTED IN OVER A WEEK AND KEYS WERE NOT IN THE VEHICLES. THE VEHICLE SPONTANEOUSLY BURST INTO FLAMES WHICH BURNED THE ENGINE BAY AND FRONT END OF THE CAR BEFORE THE FIRE DEPT. ARRIVED AND EXTINGUISHED THE FIRE WITH FOAM. THE CAR HAD BEEN SITTING UNSTARTED FOR OVER A WEEK. I AM UNSURE OF WHAT CAUSED THE FIRE AND BECAUSE OF THE EXTENSIVE DAMAGE TO THE ENGINE BAY I COULD NOT DETERMINE WERE THE FIRE ORIGINATED. PERHAPS A PROFESSIONAL FIRE EXAMINER COULD DETERMINE THAT. I AM BLESSED THAT THIS DID NOT HAPPEN WHILE PARKED IN MY GARAGE BUT WAS SCARY. I JUST WANT THIS INCIDENT ON RECORD SO THAT OTHERS WHICH OWN THIS PARTICULAR TYPE OF VEHICLE CAN BE WARNED ABOUT THE POTENTIAL DANGERS. I HAVE OWNED THIS VEHICLE SINCE NEW AND HAD A COUPLE OF UPDATES DONE PER BMW SUCH AS THE TAILPIPES AND TIMING CHAIN IN THE ENGINE. I WAS NOT AWARE OF ANY ADDITIONAL RECALLS OR UPDATES BUT APPARENTLY THERE HAVE BEEN SOME INCIDENCES OF FIRES SUCH AS MINE WHICH I LEARNED ABOUT AFTER SEARCHING THE INTERNET TO SEE IF SIMILAR ISSUES HAD BEEN DOCUMENTED. I WILL ATTACH A FEW PICTURES FOR YOU TO HELP WITH YOUR ASSESSMENT. THANK YOU FOR YOUR TIME AND CONSIDERATION. I HOPE THIS INFORMATION WILL BE SOME HELP TO OTHERS IN PREVENTING A SIMILAR SITUATION. I THANK GOD NO ONE WAS INJURED OR PROPERTY DAMAGED OTHER THAN MY CAR. THE FIRE DEPARTMENT MADE A REPORT BUT IT DID NOT INCLUDE INVESTIGATING THE CAUSE JUST A RESPONSE TO A FIRE. *TR

NHTSA ID

11323318

Incident

May 2, 2020

Mileage

92,000 mi

PASSENGER SEAT MAT OCCUPANCY SENSOR/PAD HAS GONE BAD AGAIN AFTER THE RECALL.*DT SAFETY RECALL REPORT XXX-XXX 'PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *JB

NHTSA ID

11246321

Incident

Aug 5, 2019

Mileage

52,000 mi

I HAVE BEEN DRIVING MINI S 2007 FOR MORE THAN A YEAR WITH NO SERIOUS ISSUES OTHER THAN ONE CHECK ENGINE LIGHT ISSUE, WHICH WAS RESOLVED SIMPLY BY A MECHANIC CHECK AT BMW SERVICE CENTER. ON SUNDAY EVENING MAY 26, 2019, AS I WAS PLANNING TO GO OUT, I OBSERVED THE STEERING ALERT SIGN ON. I TRIED RESTARTING AND SHUTTING OFF ENGINE MULTIPLE TIMES THINKING IT MAY BE AN ELECTRONIC ABERRATION WHICH MAY BE KICKED AWAY BY BRUTE FORCE OF RESTARTING THE IGNITION. AFTER 30-45 MINUTES OF THIS FRUITLESS EXERCISE, I TURNED MY ATTENTION ONLINE WHERE I FOUND NUMEROUS AUTO BLOGS OF STARTING THE CAR WITH JUMPERS BATTERY TO REPLACING POWER STEERING FLUID. SINCE MINI SERVICE WAS CLOSED, I HAD TO SEEK HELP FROM MY INSURANCE COMPANY. THEY SENT A PERSON AFTER TWO HOURS TO USE JUMPERS, BUT THAT DID NOT HELP EITHER. WE WERE ABLE TO CHECK THE POWER STEERING FLUID , AND THAT WAS ALSO FULL TO THE MARK. ON FURTHER RESEARCH ONLINE, I DISCOVERED TO MY UTTER DISAPPOINTMENT THAT MINI COOPERS HAVE BEEN PLAGUED WITH POWER STEERING ISSUES DUE TO INHERENT FLAW OF PLACEMENT AND DESIGN OF POWER STEERING PUMP. IT IS VERY WELL DOCUMENTED ACROSS REPUTED CAR JOURNALS/MAGAZINES THAT THE POWER STEERING PUMP FAILURE WILL DEFINITELY HAPPEN IN MINI COOPERS, AND THE ONLY VARIABLE IS THE TIME. I WAS THOROUGHLY CRESTFALLEN GIVEN I HAD PLACED SO MUCH TRUST IN THE BRAND AND THE QUALITY OF MINI COOPER. THE PURPOSE OF THIS COMPLAINT IS TWO PRONGED- ONE IS OBVIOUSLY TO HIGHLIGHT THE PROBLEM ONCE AGAIN AND MAKING SURE MINI ENGINEERS SOLVE THIS PROBLEM IN THEIR ENGINEERING DESIGN PROCESSES. SECOND- IS TO REQUEST TO HAVE THE POWER STEERING ISSUE FIXED IN MY CAR BY MINI. GIVEN THAT THE ISSUE HAS BASIS IN THE INHERENT FLAW OF THE DESIGN, I BELIEVE MINI COOPER WILL WAIVE OFF THE COST OF SERVICES AND PARTS TO GET THIS ISSUE FIXED. THIS IS NOT USUAL WEAR AND TEAR WHOSE COSTS SHOULD BE BORNE BY THE CUSTOMER.

NHTSA ID

11210203

Incident

May 25, 2019

Mileage

129,000 mi

THE TURBOCHARGER HAD TO BE REPLACED, NEW TURBO GOT HOT AND MELTED THE VALVE COVER. THEN THE TURBOCHARGER CAUGHT FIRE WHILE IN MOTION IN A RURAL NEIGHBORHOOD. ALL WITHIN 6 MONTHS.

NHTSA ID

11182392

Incident

Jan 18, 2019

Mileage

153,368 mi

TIMING CHAIN TENSIONER BROKE AND MESSED UP THE ENGINE

NHTSA ID

11153691

Incident

Jul 22, 2018

Mileage

100,000 mi

TO THE RIGHT OF MY GAS PEDAL IN MY CAR GETS SUPER HOT! IT REACHES OVER 207 FAHRENHEIT DEGREES. IT GETS WORSE WHEN I USE MY AC. WHEN I WEAR MY FLIP FLOPS IT BURNS MY TOES.

NHTSA ID

11123608

Incident

Aug 1, 2018

Mileage

10 mi

TL* THE CONTACT OWNS A 2007 MINI COOPER S. THE CONTACT STATED THAT THERE WAS A CATASTROPHIC ENGINE FAILURE WITHOUT WARNING. THE VEHICLE WAS UNABLE TO BE DRIVEN AND WAS TOWED TO BRAMAN MINI OF PALM BEACH (2815 OKEECHOBEE BLVD, WEST PALM BEACH, FL 33409, (561) 257-4774). THE DEALER INDICATED THAT THE MANUFACTURER SERVICE CAMPAIGN WAS ONLY TO ADDRESS REPLACING THE TIMING CHAIN AND THAT THE REPLACEMENT OF THE ENGINE ASSEMBLY WAS NOT INCLUDED IN THE MANUFACTURER'S GUIDELINES OF THE SERVICE CAMPAIGN. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS WAITING FOR A RESPONSE FROM THE MANUFACTURER TO DETERMINE IF THEY COULD APPROVE THE DEALER REPLACING THE TIMING CHAIN AND THE ENGINE ASSEMBLY. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA ID

11114990

Incident

Jul 30, 2018

MY VEHICLE IS CURRENTLY @ BRAMAN BMW WPB (5612423210) FOR A TIMING CHAIN PROBLEM WHICH WAS UNDER RECALL. THE SERVICE ADVISOR CALLED ME AND NOTIFIED ME THAT THE TIMING CHAIN BROKE INSIDE THE ENGINE & COMPLETELY DESTROYED THE MOTOR. TE TIMING CHAIN JOB ALONE ESTIMATE IS $3800, BUT THEYVE NOTIFIED ME THAT THE ENGINE IS UNREPAIRABLE & MUST BE REPLACED! THEY ALSO FAILED TO ACKNOWLEDGE THAT THIS HAPPEN WHILST DRIVING ON AN INTERSTATE, ALMOST CAUSING A HUGE ACCIDENT!! PLEASE HELP!! MINI APPARENTLY CARES MORE ABOUT MONEY THAN LIVES!!

NHTSA ID

11114985

Incident

Jul 30, 2018

Mileage

80,000 mi

TAKATA RECALL, I HAVE A 2007 MINI COOPER THAT ONLY HAS 84000 MILES AND HAVE HAD TO HAVE THE TIME CHAIN REPLACE 4 TIMES. THE REPAIR GARAGE IS TELLING ME THAT MINI KEEPS UPDATING THE KITS FOR EVERY REPAIR. THE TIME CHAIN WAS REPLACED IN 2009, 2012,2016,2018. ONCE THING THEY DID TELL ME THAT I DON'T KEEP ENOUGH OIL IN THE CAR, BUT IF THE OIL LIGHT DOESN'T COME ON HOW AM I TO KNOW THIS. I DON'T HAVE $2000.00 TO $2500.00 EVERY COUPLE OF YEARS TO KEEP GETTING THE CAR REPAIRED. SO I'M THINKING ABOUT GETTING READ OF THE CAR. HAS ANYONE ELSE HAD THIS PROBLEM.

NHTSA ID

11104067

Incident

Jun 11, 2018

Mileage

400 mi

THERE WAS A RECALL FOR THE TIMING CHAIN, SO I HAD IT REPLACED IN THE RECALL PROGRAM THAT WAS OFFERED THROUGH MINI COOPER. LESS THEN 2 YEARS LATER, MY TIMING CHAIN BROKE AGAIN, AND HAS DAMAGED THE MOTOR OF MY CAR. IT WOULD NOT START

NHTSA ID

11084013

Incident

Mar 19, 2018

Mileage

89,000 mi

MY CAR IS LITTLE OVER 102,000 MILES. IT SUDDENLY STOPPED, NEAR MY HOUSE AND I WAS NOT ABLE TO START AGAIN. REPLACED BATTERY, HOWEVER FOUND OUT THAT HIGH PRESSURE FUEL PUMP FAILED. WARRANTY REPORTED BY MINI EXPIRED EARLIER THIS YEAR. THIS COULD BE SAFETY ISSUE, IF CAR STOPS IN MIDDLE OF HIGHWAY.

NHTSA ID

11052627

Incident

Nov 27, 2017

Mileage

102,000 mi

TIMING CHAIN MAKING LOUD NOISE WHEN STARTED

NHTSA ID

11019830

Incident

Aug 19, 2017

PASSENGER DOOR SEAL FAILED RESULTING IN FLOODING OF THE ENTIRE PASSENGER SIDE. MOISTURE CAUSED THE STARTING SENSOR TO FAIL AND THE VEHICLE NOT TO START. THERE WAS ALSO RAPID GROWTH OF MOLD IN THE VEHICLE FROM THIS MOISTURE. THE ONLY RESOLUTION WAS TO REMOVE THE ENTIRE INTERIOR, SHAMPOO THE CARPET, AND DRY EVERYTHING OUT. ON-LINE RESEARCH (AFTER THE FACT) REVEALED THAT APPARENTLY THIS IS A KNOWN ISSUE BUT THERE DOESN'T SEEM TO BE A RECALL ISSUED.

NHTSA ID

11013436

Incident

May 1, 2017

Mileage

69,456 mi

CAR CRASH MAY 30, 2017, DRIVER'S AIR BAG DID NOT DEPLOY CAUSING GREAT BODILY INJURY TO DRIVER.. DRIVER WAS TRAVELING 25 MPH IN TOWN AT AROUND 10:30 A.M.. DRIVER HAD A STROKE, PASSED OUT, CROSSED OVER TO OPPOSITE SIDE OF ROAD AND HIT AN UNOCCUPIED PARKED CAR. THAT CAR HIT ANOTHER PARKED VEHICLE AND CHAIN REACTION LEFT FOUR CARS IN THE ACCIDENT. STATE FARM OR GENE'S AUTO BODY SHOP HAVE PHOTOS.

NHTSA ID

10993982

Incident

May 30, 2017

Mileage

29,500 mi

THIS CAR HAS BEEN A CONSISTENT USER OF OIL. IT USES A QUART AT ABOUT 500 MILES. THIS ENGINE HAS A REPUTATION FOR PROBLEMS ON MINI COOPER S MODELS AND THE PEUGEOT MODELS WITH THAT SAME ENGINE. I'VE HEARD THAT LATER MODELS DON'T BURN OIL. I'D LIKE TO KNOW WHY BMW HAS NOT RECALLED THEM. FIRST THE TIMING CHAIN, COOLING SYSTEM AND HIGH PRESSURE FUEL PUMP., THEY PAID FOR THE TIMING CHAIN AND THE FUEL PUMP.

NHTSA ID

10969563

Incident

Sep 14, 2016

Mileage

100,000 mi

MINI COOPER S - NUMEROUS ISSUES FOUND HAVING PURCHASED A USED 2007 MINI COOPER S FROM A SMALL DEALER IN TALLAHASSEE, FLORIDA, WE DID OUR RESEARCH UP-FRONT WITH A 'CARFAX REPORT' WHICH SHOWED NO ISSUES, WE ALSO DID A VIN DATABASE SEARCH FOR RECALLS AND FOUND NO OPEN RECALLS AND ASSUMED THAT IT WAS SAFE TO PURCHASE WHICH WE DID FOR JUST OVER $5,000. NOW THAT WE ARE NEARING A YEAR INTO OUR 4-YEAR PAYMENT PLAN, ON JANUARY 17, 2016, MY WIFE WAS DRIVING NORTH ON I-75 IN GEORGIA AND AT APPROX. MILE MARKER 211, THE ENGINE SEIZED AND SHE REQUIRED A TOW OFF THE INTERSTATE. LUCKILY, THERE WAS NO ACCIDENT OR INJURY- BUT IT SEEMS THAT WOULD HAVE HELPED OUR CASE' UPON ATTEMPTING REPAIRS, WE FIND NUMEROUS ISSUES WITH THE ENGINE (2007 R56/N16 4 CYLINDER TURBOCHARGED) INCLUDING TIMING CHAIN, WATER PUMP, VACUUM PUMP, ETC' BELOW ARE PHOTOS OF REMOVED PARTS FROM THE ENGINE ' THE VACUUM PUMP SEIZED AND BENT THE METAL COMPONENTS ' SINCE THIS IS CONNECTED TO THE 'EXHAUST CAMSHAFT', WHEN IT SEIZED IT SEIZED THE EXHAUST CAMSHAFT ' ON THE OPPOSITE END OF THIS CAMSHAFT IS A SPROCKET WHICH CONNECTS THE TIMING CHAIN (ANOTHER KNOWN ISSUE WITH THIS VEHICLE) ' THE BOLT AND SPROCKET DROPPED INTO THE ENGINE AND TIMING CHAIN AREA, CREATING A CATASTROPHIC FAILURE WHICH IT APPEARS WE ARE GOING TO BE 'LEFT HOLDING THE BAG' FOR

NHTSA ID

10949916

Incident

Jan 17, 2017

Mileage

177,765 mi

PASSENGER AIRBAG LIGHT IS ERRATIC, SOMETIMES IT WORKS, MOST TIMES NOT.

NHTSA ID

10910019

Incident

Sep 20, 2016

Mileage

120,000 mi

ENGINE, THERMOSTAT, GASKET, RADIATOR, COOLANT TUBE, AND BATTERY WENT OUT ON THE V AT THE SAME TIME. IT WAS RUNNING ROUGH AND JUST STOP RUNNING.

NHTSA ID

10909978

Incident

Jun 24, 2016

Mileage

87,555 mi

WE ARE A SECOND OWNER OF THIS MINI COOPER HAD IT ABOUT A YEAR. TURN THE CAR ON AND HEAR A RATTLE IN MOTOR. WORSE WHEN IT'S COLD. TOOK IT IN TO BE CHECKED IT THE TIMING TENSIONER. APPARENTLY THERE HAS BEEN AN ISSUE WITH THIS FOR SOMETIME. REPAIR COST IS AROUND $2000. CAR ONLY HAS 76,000 MILES THIS PART SHOULD BE PROVIDED UNDER WARRANTY. BUT WHEN IT BREAKS IT AFFECTS THE MOTOR AS WELL BECAUSE IT IS METAL IT TEARS THE MOTOR UP. MAKING A 10 DOLLAR PART COST THOUSANDS OF DOLLARS FOR REPAIR. I DON'T FEEL LIKE I AM LIABLE FOR THE EXPENSE THAT MINI KNEW WAS A PROBLEM AND NEVER RECALLED.

NHTSA ID

10898458

Incident

Aug 20, 2016

Mileage

76,000 mi

TL* THE CONTACT OWNS A 2007 MINI COOPER S. WHILE DRIVING 20 MPH, THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FRONT PASSENGER SIDE MAT SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS AWARE OF NHTSA CAMPAIGN NUMBER: 15V205000 (AIR BAGS). THE FAILURE MILEAGE WAS 39,000.

NHTSA ID

10894488

Incident

Jul 21, 2016

Mileage

39,000 mi

2007 MINI COOPER S, HATCHBACK. THE PASSENGER AIRBAG (OFF) LIGHT, INDICATING THE PASSENGER AIRBAG IS DISARMED, IS ON AT ALL TIMES REGARDLESS OF PASSENGER. ADDITIONALLY, THE DASHBOARD WARNING LIGHTS FOR MY AIRBAG SYSTEM AND SEATBELT ARE ILLUMINATED AT ALL TIMES. THE CODES IDENTIFIED BY THE MINI DEALERSHIP IN HONOLULU INDICATE THE PASSENGER SEAT OCCUPANCY SENSOR HAS A FAULT. LOOKING UNDER THE SEAT, IT COULD BE A FAULTY WIRING HARNESS OR FAULTY CONNECTER AS THEY APPEAR VULNERABLE TO SEAT MOVEMENT FORWARD OR BACKWARDS. THE MINI DEALERSHIP ALSO STATED THE OBNOXIOUSLY EXPENSIVE PART WAS ON NATIONAL BACK-ORDER.

NHTSA ID

10881329

Incident

Apr 19, 2016

Mileage

98,000 mi

THE PASSENGER SEAT AIR BAG LIGHT IS ILLUMINATED AND CANNOT BE RESET DUE TO A FAULTY OCCUPATION SENSOR. ACCORDING TO THE SERVICE TECHNICIAN THIS WILL CAUSE THE AIR BAG TO MALFUNCTION IF AN ACCIDENT WERE TO OCCUR. THIS IS A COMMON PROBLEM WITH THESE CARS AND COSTS OVER $1000 TO REPAIR AND IS NOT COVERED BY THE MANUFACTURER.

NHTSA ID

10861598

Incident

Apr 4, 2015

Mileage

69,721 mi