2007 MINI Cooper S Recalls

In a January 10, 2012 letter to NHTSA, BMW of North America, LLC. (BMW) submitted a Defect Information Report (DIR) identifying a defect in the electric auxiliary water pump in approximately 88,911 model year (MY) 2007-2011 Mini Cooper vehicles manufactured from November 14, 2006 through January 18, 2011 (Recall 12V-008).According to BMW, the auxiliary water pump on vehicles equipped with 4-cylinder turbocharged engines may overheat.Electro-migration can cause the pump electronic circuit board to overheat resulting in smoldering of the water pump. If smoldering occurs, it may lead to an engine compartment or vehicle fire.The pump supplier, Pierburg Pump Technology GmbH, redesigned the pump to address factors that may contribute to circuit board overheating.The redesigned pumps were completely implemented in production vehicles by January 2011.Recall 12V-008 was the third recall initiated by BMW to address electric auxiliary water pump fires in vehicles equipped with Pierburg pumps.In two October 20, 2011 letters to NHTSA, BMW submitted DIRs for similar auxiliary water pump defect conditions in approximately 32,084 MY 2008-2011 BMW 5-Series, 7-Series, X5 and X6 models equipped with 8- and 12-cylinder engines and manufactured from May 2008 through December 2010 (Recall 11V-521); and for approximately 589 MY 2010 Rolls-Royce Ghost vehicles manufactured from September 2009 through September 2010 (Recall 11V-522).In three separate April 5, 2012 letters to NHTSA, BMW submitted amendments to Recalls 11V-521, 11V-522 and 12V-008.The amendments all described a common defect condition related to a manufacturing process deviation in a certain production range of the redesigned Pierburg water pumps that could result in cracks in the pump housing, which may allow coolant to enter and contact the pump?s circuit board.BMW indicated that further analysis identified a specific machine process error at the sub-supplier that manufactures the water pump housing.Pump housing cracks may cause the circuit board to overheat and lead to smoldering of the water pump.Recall 12V-008 was, thus, amended to include approximately 1,457 MY 2011 Mini Cooper vehicles manufactured from March 31, 2011 through April 22, 2011, when pumps manufactured with the suspect manufacturing process may have been used in vehicle assembly.The amendment to Recall 11V-521 was assigned a new recall number, Recall 12V-161, and covered approximately 2,846 MY 2011-2012 BMW 5-Series, 6-Series, 7-Series, X5, and X6 vehicles manufactured from April 1, 2011 through August 1, 2011.The amendment to Recall 11V-522 was assigned a new recall number, Recall 12V-166, and covered approximately 69 MY 2011 Rolls-Royce Ghost vehicles manufactured from April 7, 2011 through June 2, 2011.The Office of Defects Investigation (ODI) analyzed complaint data provided by BMW as well as complaints submitted to ODI from consumers. In total, there were 30 unique Mini Cooper reports indicating engine fire.In addition, BMW provided warranty data showing 493 claims for replacement of the subject component on Mini Cooper vehicles.Owners of the recalled vehicles are notified to take their vehicle to a BMW dealer, who will replace the auxiliary water pump to prevent any incidents related to this issue.This preliminary evaluation is closed.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers (ODI Nos.):10286597, 10286663, 10289793, 10310677, 10314796, 10342365, 10394808, 10394192, 10403982, 10418325, 10422646, 10429003.

BMW WILL CONDUCT A SAFETY RECALL (08V-657) ON 28,450 MINI COOPER S VEHICLES MANUFACTURED FROM NOVEMBER 18, 2006 THROUGH JULY 8, 2008.DEALERS WILL INSTALL MODIFIED EXHAUST PIPE TIPS THAT DO NOT EXTEND BEYOND THE REAR BUMPER.THE TWO EXHAUST PIPE TIPS OF THE SUBJECT VEHICLES EXIT THE UNDERSIDE OF THE VEHICLE AT THE CENTER OF THE VEHICLE AND EXTEND BEYOND THE REAR BUMPER.THE COMPLAINANTS REPORTED BEING BURNED ON THEIR LEGS WHEN THEY INADVERTENTLY TOUCHED THE EXPOSED HOT EXHAUST PIPE TIPS WHILE REMOVING ITEMS OF CARGO FROM THE REAR OF THEIR VEHICLE VIA THE HATCH BACK DOOR.SOME COMPLAINANTS REPORTED BEING BURNED ON MORE THAN ONE OCCASION OR THAT OTHER FAMILY MEMBERS WERE ALSO BURNED.THE 50 INJURIES REPORTED IN THIS INVESTIGATION INCLUDE SIGNIFICANT SECOND DEGREE BURNS CAUSING BLISTERED AND SCARED SKIN AND ONE INCIDENT RESULTED IN A THIRD DEGREE BURN.THIS INVESTIGATION ALSO RESULTED IN AN INITIAL DECISION OF A DEFECT.FOR INFORMATION REGARDING THE INITIAL DECISION AND DETAILS OF THE INVESTIGATION SEE DOCUMENTS, INRM-EA08020-31646.PDF (INITIAL DECISION LETTER) AND INIR-EA08020-31648.PDF (INITIAL DECISION REPORT), IN THE INVESTIGATION FILE.THIS INVESTIGATION IS CLOSED.

THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION BASED ON THREE CONSUMER REPORTS.THE COMPLAINANTS REPORTED BEING BURNED ON THEIR LEGS BY THE HOT EXHAUST PIPE TIP WHILE THEY WERE REMOVING CARGO ITEMS FROM THE REAR HATCH AREA OF THEIR VEHICLES.THE MINI COOPER S MODEL HAS DUAL EXHAUST PIPE TIPS THAT ARE LOCATED AT THE CENTER LINE OF THE VEHICLEUNDER THE REAR BUMPER.THE EXHAUST PIPE TIPS EXTEND BEYOND THE EDGE OF THE BUMPER.ODI IS UPGRADING THIS INVESTIGATION TO ENGINEERING ANALYSIS EA08-020 BASED ON INFORMATION PROVIDED BY BMW IN RESPONSE TO ODI'S PE08-031 INFORMATION REQUEST LETTER.