2002 MINI Cooper Problems

SO I BOUGHT A 2002 MINI COOPER LESS THAN A YEAR AGO AND IT CURRENTLY HAS 74K MILES AND ATTEMPTING TO PULL INTO A PARKING SPOT AT THE GROCERY MY STEERING GOES COMPLETELY OUT WHILE I WAS TRYING TO TURN INTO MY SPOT AND RIPPED OFF A BLACK MOLDING THAT GOES OVER THE FRONT PASSENGER WHEEL AND A SIGNIFICANT DING AND SCRATCH.

TL* THE CONTACT OWNS A 2002 MINI COOPER. WHILE DRIVING APPROXIMATELY 50 MPH, THE STEERING WHEEL SEIZED AND THE POWER STEERING WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS ABLE TO COAST TO THE SIDE OF THE ROAD. THE CONTACT POWERED OFF AND RESTARTED THE VEHICLE, AND WAS ABLE TO DRIVE NORMALLY. THE CONTACT, A CERTIFIED MECHANIC, DIAGNOSED THAT THE STEERING PUMP FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND DID NOT OFFER ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

I WAS DRIVING FROM EAST LOS ANGELES TO WEST LOS ANGELES (PLAYA DEL RAY) ON THE 105 WEST HGWY WHEN THE CARS TRANSMISSION WENT OUT. THIS HAPPENED IN THE MIDDLE OF THE FREEWAY IN LA DURING RUSH HOUR. I HAD TO SLOWLY MOVE OVER TO THE RIGHT HAND SIDE OF THE HIGHWAY UNTIL I COULD FIND AN AREA WITH A SHOULDER. I BARELY MADE IT TO THE SHOULDER AND COULD HAVE DIED FROM ONE OF THE CARS SPEEDING PAST ME. LUCKILY I MADE IT. I CALLED AAA AND THEY BROUGHT A TOW TRUCK WHICH TOWED THE CAR INTO A SHOP WHICH STATED THAT THEY WOULD NOT BE ABLE TO REBUILD THE TRANSMISSION. THEY SAID I WOULD HAVE TO REPLACE THE WHOLE THING WHICH WOULD COST $7,000 MINIMUM. I CALLED MULTIPLE OTHER DEALERS AND SHOPS, WHOM ALL GAVE THE SAME ESTIMATE. I DONATED IT TO MY LOCAL NPR STATION BECAUSE I DID NOT WANT TO PAY THAT AMOUNT OF MONEY TO REPLACE A FAULTY TRANSMISSION, WITH ANOTHER FAULTY TRANSMISSION. *TR

I ALWAYS MAINTAINED MY 2002 MINI COOPER AND AT 80K MILES THE TRANSMISSION BLEW UP JUST BEFORE I WAS TO ENTER A VERY BUSY FREEWAY IN LOS ANGELES, DOWNTOWN AREA. THERE WAS PLENTY OF OIL IN THE TRANSMISSION. I WAS TOLD IT WAS NOT A FAULT OF MY CARE AFTER THE MECHANIC LOOKED AT IT UPON TOW IN. IT JUST STOPPED FAST AND SHORT WITH A HUGE JERK FORWARD AND EXPLOSIVE NOISE. THE MECHANIC SAID IT BLEW IN BIG CHUNKS. I COULDN'T MOVE IT FROM TRAFFIC IN NEUTRAL AND HAD IT TOWED TO THE SHOP. 80K IS EARLY FOR SOMETHING LIKE THIS AND I SEE MANY PEOPLE ARE REPORTING THIS HAPPENED WITH EVEN LESS MILEAGE, 34K, 48K ...NO REPLACEMENTS AND SO MANY FAILURES LIKE THIS? MINI TURNS THEIR HEADS; WOULD NOT REPLACE OR EVEN TALK TO ME. PREVIOUSLY TOO THE POWER STEERING PUMP ALSO JUST STOPPED AND NO MOVEMENT ON THE WHEEL. SERIOUSLY DANGEROUS. I WAS TOLD BY THE DEALERSHIP ONE TIME IN MOUNTAIN VIEW, I HAD AN OIL LEAK. AT THE TIME THE AMOUNT THEY WANTED ME TO PAY WAS HIGH, 700.00 OR SO (JUST AFTER WARRANTY ENDED). I TOOK IT TO ANOTHER MECHANIC. HE TOOK ME UNDER THE CAR AND SHOWED ME THERE WAS NOT A SPOT OF OIL UNDER THAT CAR IN ANY NOOK OR CRANNY. IN THINKING ABOUT THIS AFTER TRANSMISSION PROBLEM I REALIZE THESE THINGS ARE TELLING ME MINI KNOWS ABOUT THEIR MINI MECHANICAL PROBLEMS. ALSO WHEN THE NEW ($4350.00) TRANSMISSION WAS PURCHASED, LA, MINI TOLD THE MECHANIC THEY HAD 5 TRANSMISSIONS IN STOCK IN THEIR PARTS DEPARTMENT AT ALL TIMES BECAUSE THIS WAS SO COMMON. THAT'S PROOF THEY KNOW IT'S A PROBLEM. YET NO RECALL TO PEOPLE WITH THESE ISSUES AND THESE CAN CAUSE SERIOUS LIFE THREATENING PROBLEMS. *TR

DRIVER'S SIDE AUTOMATIC WINDOW DOES NOT WORK; WILL BE REPLACING WINDOW MOTOR. *TR

BOTH PASSENGER AND DRIVER'S SIDE WINDOW MOTOR FAILURE (WITH WINDOW IN UP POSITION). PROBLEM WAS INTERMEDIATE OVER THE PAST THREE OR FOUR YEARS WITH FAILURE TWO OR THREE TIMES A YEAR. CURRENTLY DRIVER'S SIDE WINDOW HAS NOT WORKED FOR WEEKS. *TR

I purchased the vehicle used with airbag light showing on the speedometer gauge cluster. Searched with vin for recalls but showed 0 unrepaired recalls. Tried clearing the light with my Launch CREADER BMW V2 scan tool. Light flashes a few times and goes away but immediately appears on the speedometer gauge cluster. This would happen everytime. Wires are intact with no signs of damages to all 3 wire connectors under the seat.

Unoccupied passenger side airbags; all front & backseat bags deployed after passenger side tires hit pothole on road. Pieces of interior, including decorative plastic, interior light covers were projected across cabin & hit me. I had no idea what had happened. Car shut off shortly after incident. It was night, I was sitting in middle of my lane, unable to start Mini. Good samaritans helped push it into parking lot while waiting for assistance. After 15 minutes, car started and was driven home. I had slight injuries from being hit by hard material projectiled across cabin. Very thankful I was the only occupant because if a passenger had been in the seat, they would have most definitely sustained injuries. I had to cut the airbags out in order to have clear lines of sight before driving the following day. I’m fearful that the drivers side air bags may do this as well. I have owned this vehicle since 2004. Not aware of history prior to 2004;(accidents, original airbags?). only know it came from a Dealer in CA. (Possibly “Friendship” may be name of town or dealership). I have not had repairs made yet. I don’t drive this vehicle daily. There are no police reports since there was no need. No insurance claims since 2002 model. There were no malfunctions with the warning light prior to incident. However, the following day when I drove, the airbag indicator light came on for passenger side. I did not find a recall but not sure if I would for a 22 year old vehicle.

Driverside headlight assembly flickers everytime when you turn the key to position 1 with selector on off or auto. Flickers multiple times but doesn'tturn on unless I cycle the key on off until headlight does. This annoyance would reoccur the very next morning. Passenger headlight assembly doesn't have any issues.

I purchased the vehicle used with airbag light showing on the speedometer gauge cluster. Searched with vin for recalls but showed 0 unrepaired recalls. Tried clearing the light with my Launch CREADER BMW V2 scan tool. Light flashes a few times and goes away but immediately appears on the speedometer gauge cluster. This would happen everytime. Wires are intact with no signs of damages to all 3 wire connectors under the seat.

TL* THE CONTACT OWNS A 2002 MINI COOPER. WHILE DRIVING VARIOUS SPEEDS, THE ENGINE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE ELECTRONIC LEARNING MODULE AND THE PYRAMID WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT SEVERAL COMPONENTS WERE REPLACED DUE TO MANUFACTURER DEFECTS. THE GEAR LEVER, TRANSMISSION, BRAKE PEDAL, MOTOR, CLUTCH, FRONT AND REAR AXLES, AND THE ACCELERATOR PEDAL POSITION SENSOR WERE ALL REPLACED. THE FAILURE MILEAGE WAS 118,457.

TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, THE TRANSMISSION HESITATED IN A JERKING MOTION AND BEGAN TO DOWN-SHIFT INTO ANOTHER GEAR CONTINUOUSLY. IN ADDITION, THE ENGINE WARNING INDICATOR AND EP CODE ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER, WHO STATED THAT THE TRANSMISSION WOULD NEED TO BE REPLACED DUE TO INTERNAL DAMAGE. THE VEHICLE HAD NOT BEEN REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 56,416.

I purchased the vehicle used with airbag light showing on the speedometer gauge cluster. Searched with vin for recalls but showed 0 unrepaired recalls. Tried clearing the light with my Launch CREADER BMW V2 scan tool. Light flashes a few times and goes away but immediately appears on the speedometer gauge cluster. This would happen everytime. Wires are intact with no signs of damages to all 3 wire connectors under the seat.

I WAS EXITING FROM 35TH STREET IN NEWPORT NEWS, VA ONTO THE WARWICK BLVD OFF RAMP IN TRAFFIC, COASTING WITH THE BRAKES AT ABOUT 5 MPH, WHEN I WAS REAR ENDED BY A NAVY OPERATED FLAT NOSE SCHOOL BUS, WHICH FORCED MY VEHICLE INTO A LATE MODEL CHEVY TRAILBLAZER. MY AIR BAGS (FRONT AND SIDE) DID NOT DEPLOY, AND WHEN I CAME TO REST MY SEAT BACK HAD RECLINED AGAINST MY CHILD'S CAR SEAT (CHILD WAS NOT IN VEHICLE). THE RIGHT REAR UNIBODY WAS CREASED DUE TO THE IMPACT FROM THE BUS. I SUFFERED NECK, BACK, AND SPINE TRAUMA. THE DRIVER OF THE TRAILBLAZER COMPLAINED OF NECK PAIN AT THE SCENE. LOCAL NEWPORT NEWS FIRE AND RESCUE UNITS ARRIVED ON SCENE, AS WELL AS A VIRGINIA STATE TROOPER. THE TROOPER HANDLED THE ACCIDENT. *TR

TL* THE CONTACT OWNS A 2002 MINI COOPER. WHILE DRIVING 15 MPH OUT OF A PARKING LOT, THE VEHICLE MADE A LEFT TURN AND THE GEAR SHIFTER FAILED. IN ADDITION, THE GEAR SHIFTER CABLE DETACHED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE FAILURE RECURRED TWICE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 02V201000 (POWER TRAIN). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 2002 MINI COOPER. WHILE DRIVING VARIOUS SPEEDS, THE ENGINE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE ELECTRONIC LEARNING MODULE AND THE PYRAMID WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT SEVERAL COMPONENTS WERE REPLACED DUE TO MANUFACTURER DEFECTS. THE GEAR LEVER, TRANSMISSION, BRAKE PEDAL, MOTOR, CLUTCH, FRONT AND REAR AXLES, AND THE ACCELERATOR PEDAL POSITION SENSOR WERE ALL REPLACED. THE FAILURE MILEAGE WAS 118,457.

MY WIFE HAS BEEN COMPLAINING OF INTERMITTENT LOSS OF POWER ASSIST. I DRIVE HER CAR VERY LITTLE HOWEVER I RECENTLY HAD THE PROBLEM HAPPEN TO ME. ONE OF MY HOBBIES IS SPORT CAR RACING (MOST RECENTLY AT SUMMIT POINT RACEWAY IN WV) SO I DO EXPECT THE UNEXPECTED HOWEVER IT IS SO INTERMITTENT IT IS OFTEN FORGOTTEN. IT WILL BE FINE FOR WEEKS THEN IT HAPPENS AGAIN. THOUSANDS OF REPORTS IN THE UK AND CANADA ISSUED A RECALL. YOU DON'T LOSE YOUR STEERING JUST THE ASSIST. NEXT TIME YOU ARE ALONE ON A BACK ROAD WITH A CURVE TURN YOUR CAR OFF AND YOU WILL SEE WHAT THE DESCRIBED PROBLEM FEELS LIKE. LETS NOT HAVE A SERIOUS INCIDENT BEFORE BMW RESOLVES THIS ISSUE. THIS HAS BEEN GOING ON FOR YEARS. *TR

POWER STEERING FAILURE--THE POWER STEERING IN MY MINI COOPER S 2002 BEGAN "CUTTING OUT" AND BECAME MORE FREQUENT OVER A FEW DAYS. THE "CUTTING OUT" HAPPENS WITHOUT WARNING AND IS POTENTIALLY QUITE DANGEROUS AS THE VEHICLE BECOMES ALMOST UNMANAGEABLE WHEN MAKING A TURN. THIS MAKES DRIVING THE VEHICLE VERY UNSAFE. UPON RESEARCHING THIS PROBLEM, THIS IS A VERY COMMON PROBLEM WHICH WILL EVENTUALLY OCCUR WITH MOST MINI COOPERS EVEN THROUGH FAIRLY RECENT YEARS OF MANUFACTURE AND OFTEN AT FAIRLY LOW MILEAGE ACCUMULATION. *TR

ABS DASH LIGHT AND BREAK LIGHT SUDDENLY CAME ON. IN ADDITION TO THE AIR BAG LIGHT THAT SUDDENLY CAME ON, THE DEALER SAID THE COMPUTER MODULE FOR THE ABS WILL COST $1,000 (IN ADDITION TO THE AIRBAG MODULE OF $1.000). I SEE ON INTERNET BLOGS AND NHTSA THAT THIS IS A COMMON INCIDENT TOTAL AIR BAG AND ABS COST WILL BE $2,000

CLUTCH AND CABLES FAIL AT 100 000KM. RATTLING NOISE AT START UP. VERY LOUD HUMMING NOISE COMING FROM THE STEERING. TRANSMISSION GONE AT 103 000KM. *TR

TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT STATED THAT WATER WAS ENTERING THE VEHICLE FROM THE SUN ROOF, WHICH CAUSED THE COMPUTER IN THE VEHICLE TO GET MOIST AND NOT OPERATE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE SUN ROOF RUBBER CONNECTOR NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 118,000.

I WAS EXITING FROM 35TH STREET IN NEWPORT NEWS, VA ONTO THE WARWICK BLVD OFF RAMP IN TRAFFIC, COASTING WITH THE BRAKES AT ABOUT 5 MPH, WHEN I WAS REAR ENDED BY A NAVY OPERATED FLAT NOSE SCHOOL BUS, WHICH FORCED MY VEHICLE INTO A LATE MODEL CHEVY TRAILBLAZER. MY AIR BAGS (FRONT AND SIDE) DID NOT DEPLOY, AND WHEN I CAME TO REST MY SEAT BACK HAD RECLINED AGAINST MY CHILD'S CAR SEAT (CHILD WAS NOT IN VEHICLE). THE RIGHT REAR UNIBODY WAS CREASED DUE TO THE IMPACT FROM THE BUS. I SUFFERED NECK, BACK, AND SPINE TRAUMA. THE DRIVER OF THE TRAILBLAZER COMPLAINED OF NECK PAIN AT THE SCENE. LOCAL NEWPORT NEWS FIRE AND RESCUE UNITS ARRIVED ON SCENE, AS WELL AS A VIRGINIA STATE TROOPER. THE TROOPER HANDLED THE ACCIDENT. *TR

THE DASH LOW TIRE AIR LIGHT SUDDENLY CAME ON; IT COMES ON AFTER DRIVING FOR ABOUT 5 MINUETS. I'VE CHECKED ALL TIRES AND THEY ARE IN COMPLIANCE. I SEE THAT ON-LINE BLOGS THIS IS A MAJOR ISSUE

MY 2002 MINI COPPER HAS HAD THE AIR BAG LIGHT COME ON ON SEVERAL OCCASIONS NOW. REPAIRED WITH NEW WIRING HARNESS IN 11/03; NOW IN 1/04 BAG LIGHT HAS COME ON AGAIN. DEALER VIA PHONE CANNOT TELL ME IF THE BAGS WORK PROPERLY UNTIL DIAGNOSED. I HAVE CHECKED WEB FORUMS FOR THIS VEHICLE AND THIS SEEMS TO BE A WIDESPREAD PROBLEM. I WOULD THINK NHTSA OR SOMEONE SHOULD LOOK INTO THIS TO DETERMINE IF THERE SHOULD BE A RECALL. *AK

WHEN THE AIR CONDITIONING IS ON, CAR STALLS OR STUMBLES WHILE STARTING MOVEMENT IN FIRST GEAR. THIS CAUSES MERGES, LEFT TURNS TO GET DANGEROUS. HOT WEATHER INCREASES THE OCCURRENCE OF THE PROBLEM.*AK

1. NORMAL AROUND TOWN DRIVING. PASSENGER REAR LOWER CONTROL ARM SNAPPED ... STEEL FAILED UNDER STRESS ONE OF SEVERAL MANUFACTURE HOLES PUNCHED INTO THE MEMBER. 2. CAUSED THE VEHICLE TO BECOME INOPERABLE. 3. REQUIRED REPLACEMENT CONTROL ARM. BMW HAS SINCE RE-ENGINEERED THE CONTROL ARM. REPLACEMENT ARMS ARE MADE STRONGER. *** I CAN PROVIDE ONLINE FORUM POSTINGS FROM NORTHAMERICANMOTORING.COM AND MINI2.COM (US AND UK ONLINE FORUMS FOR MINI OWNERS) WHICH DEMONSTRATE THAT THIS MEMBER IS ROUTINELY BREAKING ON OTHER VEHICLES OF THE SAME VINTAGE. PHOTOS OF MY FAILURE AND THE FAILURES OF OTHERS AVAILABLE. MINI IS ROUTINELY DENYING RESPONSIBILITY FOR THIS VEHICLE SAFETY ITEM CITING IMPROPER DRIVING HABITS. *** *TR

DURING A 10-MINUTE COMMUTE TO WORK, MY RIGHT REAR CONTINENTAL CONTITOURING CONTACT CH95 (GRAND TOURING ALL-SEASON) 175/65HR15, PURCHASED AND INSTALLED ON 6/29/06, FAILED. THE TREAD PORTION SEPARATED FROM THE TIRE SIDES. THE SIDES REMAINED ATTACHED TO THE WHEEL RIM. THE TREAD, MINUS THE TIRE SIDES, SEPARATED FROM THE WHEEL AND WAS FOUND OTHERWISE INTACT ON THE ROADSIDE BEHIND MY DISABLED VEHICLE. NO ACCIDENT OCCURRED AND NO DAMAGE OR PHYSICAL INJURIES WERE SUSTAINED. A CALL TO THE RETAILER (THE DEALERSHIP WHERE THE TIRES AND CAR WERE PURCHASED) RESULTED IN A RESPONSE SUGGESTING THAT SOME ROAD HAZARD CONTRIBUTED TO THE FAILURE AND THAT WOULD NOT BE CONSIDERED COMING UNDER THE TIRE WARRANTY. UPON SEEING THE FAILED TIRE, THE NC STATE TROOPER AND EMERGENCY ROADSIDE ASSISTANCE TECHNICIAN DISAGREED, FEELING THAT THE TIRE MIGHT BE DEFECTIVE. *JB

Driverside headlight assembly flickers everytime when you turn the key to position 1 with selector on off or auto. Flickers multiple times but doesn'tturn on unless I cycle the key on off until headlight does. This annoyance would reoccur the very next morning. Passenger headlight assembly doesn't have any issues.

WHILE DRIVING AT HIGHWAY SPEED FUEL TANK EXPLODED WITHOUT WARNING. AS A RESULT, ENGINE FAILED. *AK