2005 MINI Cooper Problems

The contact owns a 2005 Mini Cooper. The contact stated while driving 35 MPH, the steering wheel was difficult to turn. The vehicle lost power steering functionality. The contact stated that the failure was related to NHTSA Campaign Number: 15V660000 (Steering). The vehicle was taken to an independent mechanic, who determined that the power steering pump needed to be replaced. The vehicle was taken to the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 117,300.

The vehicle experienced a loss of power steering assist. The dealer was made aware of the failure; however, the vehicle was not repaired. The dealer informed me that there was no recall associated with the VIN. The failure is NHTSA Campaign Number: 15V660000 (Steering) however, the VIN was not included in the recall.

WHILE DRIVING CAR MY STEERING WHEEL BECAME VERY HEAVY AND HARD TO STEER.

FRONT DRIVER SEAT OCCUPANT DETECTION MAT DOESN'T SEEM TO BE WORKING CORRECTLY AS IT DOESN'T DETECT SOMETIMES WHEN THERE IS AN OCCUPANT. SECOND ISSUE IS THE CVT TRANSMISSION OF THIS VEHICLE. I GET A JERKING MOTION EVERY NOW AND THEN AND FOUND A CLASS ACTION LAWSUIT LINKED WITH THESE TRANSMISSIONS. I PURCHASED THIS CAR AFTER THIS LAWSUIT BUT APPARENTLY THIS PARTICULAR VEHICLE WAS NOT TAKEN CARE OF. MY VEHICLE ONLY HAS 70,000 MILES ON IT AND FIND THIS UNACCEPTABLE.

The contact owns a 2005 Mini Cooper. The contact stated that there was water accumulated on the passenger's side front floorboard. The contact stated that the heater was causing some undisclosed issues. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 23V337000 (Electrical System). The contact called the local dealer and was informed that the VIN was not included in the recall. The vehicle was diagnosed, and it was determined that the sunroof drain tubes were clogged, the drain tubes were cleared, and an undisclosed reprogramming was completed. The vehicle was repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 172,843.

Driving at approximately 10-15 miles an hour entering a parking lot when I noticed flames coming out of the hood scoop of my 2005 Mini Cooper S. After brief inspection from my mechanic, it is believed to have been caused by the wiring harness for ABS or possibly the power steering unit since the fire originated from the rear/right hand side of the engine and those two components. I have a claim opened with USAA but during simple research, I have found tens, if not close to a hundred issues with similar characteristics. I know I am not the first R53 Mini Cooper (2002-2006 run) with this problem and this should be considered a hazard and public safety issue. I have included the link to many of the cases captured by the North American Motoring Association (a primarily North American Mini car association) which details 24 pages of these issues. https://www.northamericanmotoring.com/forums/stock-problems-issues/73527-spontaneous-engine-bay-fires.html?ispreloading=1

The contact owns a 2005 Mini Coop S Hardtop. The contact stated that while the vehicle was parked and unoccupied, the vehicle alarm activated inadvertently and the contact noticed smoke coming from underneath the hood. The contact stated that he lifted the hood open and noticed fire coming from underneath the engine. The contact extinguished the fire with a fire extinguisher. There were no injuries sustained. The vehicle was towed to an independent mechanic; however, the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 160,000.

Driving at approximately 10-15 miles an hour entering a parking lot when I noticed flames coming out of the hood scoop of my 2005 Mini Cooper S. After brief inspection from my mechanic, it is believed to have been caused by the wiring harness for ABS or possibly the power steering unit since the fire originated from the rear/right hand side of the engine and those two components. I have a claim opened with USAA but during simple research, I have found tens, if not close to a hundred issues with similar characteristics. I know I am not the first R53 Mini Cooper (2002-2006 run) with this problem and this should be considered a hazard and public safety issue. I have included the link to many of the cases captured by the North American Motoring Association (a primarily North American Mini car association) which details 24 pages of these issues. https://www.northamericanmotoring.com/forums/stock-problems-issues/73527-spontaneous-engine-bay-fires.html?ispreloading=1

WHEN DRIVING VEHICLE TRANSMISSION SLIPS CAUSING A JERK REACTION IN THE VEHICLE AND THEN IT WILL RENEGADE CAUSING ANOTHER JERK REACTION IN THE VEHICLE AND MAKES GOING AND OR STOPPING UNPREDICTABLE. TURNING LEFT IS DANGEROUS AS THE CAR MAY NOT MOVE FORWARD AT A SPEED THAT IT SHOULD OR MAY JERK IN THE MIDDLE CAUSING THE VEHICLE TO STOP IN FRONT OF ONCOMING TRAFFIC. I HAVE HAD A MACHANIC CHANGE THE TRANSMISSION AND IT STILL DOES THE SAME THING. I HAVE CONTACTED THE MANUFACTURERS WHO INFORMED ME THAT THERE WERE NO RECALLS AND NOTHING THEY WOULD DO.

THE POWER STEERING ASSIST HAS ALL BUT STOPPED WORKING, WITH STEERING NOW DIFFICULT AT LOWER SPEED--ESPECIALLY WHEN I FIRST START THE ENGINE IN THE MORNING. THE CLUTCH DOESN'T RESPOND WELL AND THE VEHICLE NO LONGER GOES INTO SECOND GEAR. THE REAR LEFT BRAKE CALIPER SEIZED IN PLACE, NOT ALLOWING THE BRAKE PAD TO RETRACT COMPLETELY AND THEREFORE THE BRAKE PAD CONTINUOUSLY RUBBED AGAINST THE DISC, BUT WITHOUT NOISE. NOT UNTIL THE LEFT REAR BRAKE MADE NOISE BECAUSE OF THE METAL ON METAL BRAKING WAS THE SEIZED OEM CALIPER IDENTIFIED, WHEN I PUT ON A SET OF NEW BRAKE PADS. NONE OF THE OTHER THREE BRAKES HAD THE SEIZED OEM CALIPER.

I HAVE NOTICED FOR THE LAST 2 YEARS THAT MY CAR HAS BEEN LURCHING. IN JUST THE LAST WEEK I HAVE NOTICED THAT WHEN I GET TO ABOUT 55-65 MPH, MY RPM'S ARE AROUND 4000. I TAKE MY FOOT OFF THE GAS AND THE RPM'S INCREASED. I HAD SOME MINOR WORK DONE ON THE AUTO-SEQUENTIAL TRANSMISSION IN 2010. I HAD BROKEN THE LINE AND HAS BEEN WELDED BACK IN AND HAD NO MAJOR PROBLEMS ASIDE FROM THE LURCHING UNTIL RECENTLY. ALL FACTORY PARTS ARE STILL ON THE CAR. TRANSMISSION HAS NOT BEEN REPLACED. I AM OUTSIDE MY WARRANTY. *TR

TRANSAXLE ON THE MINI COOPER FAILED. UNIT CONTAINS SEALED BEARINGS (SO I'M TOLD), THAT ARE NOT SERVICEABLE. THEREFORE, I HAD TO BUY A COMPLETE NEW UNIT AT A COST OF $3,000 ()INCLUDED $900 LABOR). I UNDERSTAND THIS IS NOT AN UNCOMMON FAILURE FOR MINIS, AND THAT MINI AND BMW ARE REFUSING TO WORK WITH CONSUMERS TO ADDRESS THIS PROBLEM. HOWEVER, THEY HAVE APPARENTLY CHANGED THE DESIGN, RECOGNIZING THE POOR DESIGN OF THE ORIGINAL UNIT. *TR

I RECEIVED A NOTICE FROM MINI COOPER IMPORTANT SAFETY RECALL NOTICE BY MAIL AND CALLED TO TRY AND SCHEDULE A REPLACEMENT OF THE SEAT SENSOR. I WAS TOLD THAT A DIAGNOSTIC TEST MIGHT BE CHARGED FOR THIS AND IT WOULD BE $150.00 FOR THE REPLACEMENT. THIS IS FREAKING RIDICULOUS, THIS IS THE SECOND TIME THEY TRY TO CASH OUT AT MY EXPENSE... NHTSA RECALL NUMBER: OPENS NEW WINDOW TAKES AWAY FROM VIN LOOKUP SECTION> 15V205 RECALL DATE: APRIL 3, 2015 MANUFACTURER RECALL NUMBER: NA

THE WRITTEN "SAFETY RECALL NOTICE" THAT I RECEIVED IN THE MAIL YESTERDAY, OCTOBER 14, 2015, OF WHICH BMW/MINI LIKELY PROVIDED NHTSA A COPY IS BOTH FALSE AND MISLEADING. FOUR MONTHS AFTER BMW/MINI NOTIFIED ME NOT TO ALLOW AN ADULT-SIZE PERSON TO RIDE IN THE FRONT PASSENGER SEAT OF THIS FOUR-SEAT, TWO-DOOR AUTOMOBILE, THE CURRENT WRITTEN NOTICE INDICATES THAT BMW'S MINI DEALERS "ARE NOW READY" AND I SHOULD "SCHEDULE AN APPOINTMENT FOR RECALL REPAIR SERVICE AS SOON AS POSSIBLE." IN USING THE WEBSITE PROVIDED IN THE NOTICE TO LOCATE THE NEAREST DEALER, I WAS UNABLE TO SCHEDULE AN APPOINTMENT. THE DEALER HAD NO PARTS AND WOULD NOT EVEN SCHEDULE AN APPOINTMENT TO OCCUR IN THE FUTURE. A CALL TO THE BMW/MINI TOLL-FREE NUMBER INCLUDED IN THE NOTICE CAUSED THE BMW/MINI "CUSTOMER RELATIONS AND SERVICES" REPRESENTATIVE TO ADMIT THAT THE NOTICE WAS FALSE AND THAT MANY DEALERS ARE NOT READY TO SCHEDULE APPOINTMENTS FOR THIS SERVICE. THE NOTICE FOR RECALL CAMPAIGN NO. 15V-205 INDICATES THAT IT WAS SENT TO ME "IN ACCORDANCE WITH THE NATIONAL TRAFFIC AND MOTOR VEHICLE SAFETY ACT." DOES NHTSA REALLY CONDONE FALSE AND MISLEADING WRITTEN NOTICES PURPORTED TO BE IN ACCORDANCE WITH FEDERAL SAFETY LAW?

WHEN DRIVING VEHICLE TRANSMISSION SLIPS CAUSING A JERK REACTION IN THE VEHICLE AND THEN IT WILL RENEGADE CAUSING ANOTHER JERK REACTION IN THE VEHICLE AND MAKES GOING AND OR STOPPING UNPREDICTABLE. TURNING LEFT IS DANGEROUS AS THE CAR MAY NOT MOVE FORWARD AT A SPEED THAT IT SHOULD OR MAY JERK IN THE MIDDLE CAUSING THE VEHICLE TO STOP IN FRONT OF ONCOMING TRAFFIC. I HAVE HAD A MACHANIC CHANGE THE TRANSMISSION AND IT STILL DOES THE SAME THING. I HAVE CONTACTED THE MANUFACTURERS WHO INFORMED ME THAT THERE WERE NO RECALLS AND NOTHING THEY WOULD DO.

WAS DRIVING NORMALLY ON 4/8/14 , TURNED NORMALLY UNTIL I TOOK A SLIGHT CURVE AND STEERING WHEEL GOT VERY STIFF & HARD TO TURN FROM THEN ON . UNTIL NOW IT REMAINS VERY HARD TO DRIVE . *TR

THE POWER STEERING ASSIST HAS ALL BUT STOPPED WORKING, WITH STEERING NOW DIFFICULT AT LOWER SPEED--ESPECIALLY WHEN I FIRST START THE ENGINE IN THE MORNING. THE CLUTCH DOESN'T RESPOND WELL AND THE VEHICLE NO LONGER GOES INTO SECOND GEAR. THE REAR LEFT BRAKE CALIPER SEIZED IN PLACE, NOT ALLOWING THE BRAKE PAD TO RETRACT COMPLETELY AND THEREFORE THE BRAKE PAD CONTINUOUSLY RUBBED AGAINST THE DISC, BUT WITHOUT NOISE. NOT UNTIL THE LEFT REAR BRAKE MADE NOISE BECAUSE OF THE METAL ON METAL BRAKING WAS THE SEIZED OEM CALIPER IDENTIFIED, WHEN I PUT ON A SET OF NEW BRAKE PADS. NONE OF THE OTHER THREE BRAKES HAD THE SEIZED OEM CALIPER.

IN COLD WEATHER THE DRIVER SIDE PARKING BRAKE FREEZES/STICKS. ONE OF MANY EXAMPLES WAS THIS MORNING. IT WAS 27 DEGREES IN MY GARAGE AND I WAS ABLE TO DRIVE WITH NO PROBLEMS, I DROVE FOR A FEW MILES WITH THE CAR FULLY WARMED UP. I STOPPED FOR COFFEE AND LEFT THE CAR RUNNING (WIFE IN CAR) AND RETURNED NO MORE THAN 5 MINUTES LATER. WHEN I TRIED TO DRIVE THE PARKING BRAKE WAS NOT RELEASED ALL THE WAY. AFTER DRIVING A SHORT DISTANCE THE PASSENGER REAR BRAKE WAS COOL TO THE TOUCH BUT THE DRIVER SIDE WAS RADIATING HEAT AND SMELLED OF BURNING BRAKES. THIS IS AN UNACCEPTABLE FLAW AND CAN BE DANGEROUS. THE REAR CALIPERS ARE RELATIVELY NEW AND THE BRAKE FLUID IS FLUSHED EVERY TWO YEARS. I ALSO HAVE A 2006 MINI COOPER THAT DOES NOT HAVE THIS ISSUE. A QUICK INTERNET SEARCH PROVIDES NUMEROUS EXAMPLES ALL SEEM TO BE ISOLATED IN THE 2004-2005 YEARS AND IN COLD CLIMATES.

Driving at approximately 10-15 miles an hour entering a parking lot when I noticed flames coming out of the hood scoop of my 2005 Mini Cooper S. After brief inspection from my mechanic, it is believed to have been caused by the wiring harness for ABS or possibly the power steering unit since the fire originated from the rear/right hand side of the engine and those two components. I have a claim opened with USAA but during simple research, I have found tens, if not close to a hundred issues with similar characteristics. I know I am not the first R53 Mini Cooper (2002-2006 run) with this problem and this should be considered a hazard and public safety issue. I have included the link to many of the cases captured by the North American Motoring Association (a primarily North American Mini car association) which details 24 pages of these issues. https://www.northamericanmotoring.com/forums/stock-problems-issues/73527-spontaneous-engine-bay-fires.html?ispreloading=1

WHILE TURNING INTO A SHOPPING PLAZA PARKING LOT THE STEERING WHEEL LOCKED UP AND I WAS NOT ABLE TO CONTROL OR COMPLETE THE TURN. THANK GOD I WAS DRIVING AT A SLOW SPEED AND PEDISTRIANS WERE NOT NEAR BY. I EXPERIENCED THE SAME THING WHEN I WAS LEAVING TO RETURN HOME AND TWO MORE TIMES AFTER THAT. SOMETHING NEEDS TO BE DONE ,INNOCENT LIVES ARE AT RISK. *TR

The contact owns a 2005 Mini Cooper. The contact stated that there was water accumulated on the passenger's side front floorboard. The contact stated that the heater was causing some undisclosed issues. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 23V337000 (Electrical System). The contact called the local dealer and was informed that the VIN was not included in the recall. The vehicle was diagnosed, and it was determined that the sunroof drain tubes were clogged, the drain tubes were cleared, and an undisclosed reprogramming was completed. The vehicle was repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 172,843.

WINDSHIELD SPONTANEOUSLY CRACKED. CRACK STARTED AT TOP CENTER EXTENDED DOWN ABOUT 4 INCHES, THEN HORIZONTALL FOR ABOUT 4 INCHES AND IS NOW MOVING DOWN AGAIN. *NM

2005 MINI COOPER 2-DOOR CONVERTIBLE: THE LEFT REAR UPPER AND LOWER (ORIGINAL/FACTORY) CONTROL ARMS (METAL STRUT) FAILED WHILE DRIVING ON A MAIN ROAD; WARNING SIGN WAS A SLIGHT NOISE FROM THE REAR LEFT TIRE, WHICH WENT AWAY WHEN TURNING THE WHEEL SLIGHTLY LEFT, THEN CAME BACK WHEN TURNING THE WHEEL SLIGHTLY TO THE RIGHT. (SOUNDED LIKE INTERMITTENT RUBBING/ TIRE ISSUE.) THE CAR WAS DRIVING NORMALLY AND THE TIRE LOW PRESSURE INDICATOR LIGHT WAS NOT ILLUMINATED. WHILE TURNING OFF MAIN ROAD TO INVESTIGATE, SECOND CONTROL ARM FAILED AND CAR CAME DOWN TO REST ON REAR TIRE AND WOULD NOT ROLL FORWARD. UNEXPECTED AND COMPLETE FAILURE WITH CLEAN FRACTURE TO BOTH CONTROL ARMS. NO COLLISION OCCURRED TO THE VEHICLE/PART. VEHICLE NOT RUSTED. GOOGLE SEARCH BRINGS UP MANY OTHER MINI COOPER POSTS OF THIS CONTROL ARM FAILING UNEXPECTEDLY AND WITHOUT WARNING. CONSUMER IS VERY CONCERNED THAT THIS COULD HAVE HAPPENED WHILE ON THE HIGHWAY (THAT THEY HAD RECENTLY EXITED). OTHERS POSTING ONLINE HAVE EXPERIENCED 'UNCONTROLLED 180 SPINS' WHEN THEIRS FAILED. CONSUMER CONCERNED THAT THE ORIGINAL FACTORY CONTROL ARMS ON OTHER SIDE MAY EXHIBIT SAME UNEXPECTED FAILURE IN THE FUTURE. NOT CLEAR IF THIS IS A DESIGN FLAW OR MATERIALS/PARTS BAD BATCH. MINI COOPER DEALERSHIP EMPLOYEE MENTIONED THE SAME FAILURE (TO HIS PERSONAL CAR) WITH NO WARNING RECENTLY. ONLINE POSTS OF CONSUMERS WITH THE SAME UNEXPECTED FAILURE: HTTP://WWW.MINI2.COM/FORUM/FIRST-GENERATION-FAULTS-FIXES/80969-REAR-SUSPENSION-FAILURE.HTML HTTP://WWW.MINI2.COM/FORUM/FIRST-GENERATION-FAULTS-FIXES/108796-REAR-CONTROL-ARM-ISSUES.HTML HTTP://WWW.MINI2.COM/FORUM/FIRST-GENERATION-FAULTS-FIXES/69981-BROKEN-PART-UNDERSIDE-WHATS-CALLED.HTML HTTP://WWW.PSMINI.ORG/FORUM/EXPENSIVE-REPAIR-CONTROL-ARM-BUSHINGS-AND-STRUTS_TOPIC6569.HTML

RIGHT REAR LOWER TRAILING ARM BROKE WHILE DRIVING. THERE WAS NO IMPACT WITH ANY OBJECT, IT BROKE ON ITS OWN. *TR

I REPORTED A FEW MONTHS AGO THAT MY POWER STEERING HAD FAILED. IT IS A 2005 MINI COOPER, AND SOME 2002-2005 MINI COOPERS WERE EFFECTED, BUT SUPPOSEDLY NOT MY MINI WITH MY VIN NUMBER. THE RECALL HAD ENDED IN FEBRUARY 2005 AND MY CAR WAS MANUFACTURED IN APRIL 2005. HOWEVER I BELIEVE THAT BMW (MAKERS OF MINI COOPER) WERE USING FAULTY POWER STEERING UNITS AFTER FEBRUARY 2005. MY CAR HAS LOW MILES, I AM THE ORIGINAL OWNER AND I TAKE PRISTINE CARE OF MY MINI. AS A RESULT, I HIT A CURB AND HAD TO HAVE THE FRONT LEFT TIRE CHANGED. THE WEATHER WAS CLEAR, NO RAIN AND MY TIRES ARE ALL JUST ABOUT BRAND NEW RUN FLAT TIRES. THE RANGE OF MINI COOPERS AFFECTED NEEDS TO INCREASED. THIS IS OBVIOUSLY A PROBLEM AND BMW (MAKERS OF MINI COOPER) SEEM TO NOT TAKE IT SERIOUSLY. MY POWER STEERING IS A MAJOR SAFETY ISSUE AND NEEDS TO BE ADDRESSED ASAP

(1) EVENTS: DRIVING LONG DISTANCE, AFTER APPROXIMATELY 4 HOURS I NOTICED THAT THE LEFT FRONT WHEEL WAS MAKING CLUNKING NOISES. I SLOWED DOWN, AND THE NOISE GOT WORSE. EVENTUALLY, I SLOWED DOWN, PULLED OVER, AND THE CAR KEEPS BOUNCING UP AND DOWN, AND THEN AFTER I STOPPED IT WOULD NOT MOVE FORWARD ANYMORE. (2) FAILURE: LOST 3 OUT OF 4 LUG BOLTS ON THE LEFT FRONT WHEEL, AS A RESULT, THE LEFT FRONT WHEEL IS ALMOST FALLING OFF OF THE CAR. THE LEFT FRONT RIM WAS ALSO BENT. (3) CALLED BMW ROADSIDE ASSISTANCE, TOWED THE CAR TO THE NEAREST DEALER, AND THE DEALER REPLACED 3 OF 4 LUG BOLTS AND ALSO REPLACED THE BENT RIM. *JB

PURCHASED CAR NEW 10/2004. IN FEBRUARY 2005 IT BEGAN TO ACT AS IF IT WAS GOING TO DIE AT LOW SPEEDS, ESPECIALLY WHEN FIRST STARTED. WHEN THE RPMS ARE LOW IT ACTS AS IF IT IS NOT GETTING FUEL. CALLS TO THE DEALERSHIP RE: THIS PROBLEM WERE MET W/ "MINI KNOWS ABOUT THE PROBLEM, IT IS A SOFTWARE PROBLEM AND THERE SHOULD BE A FIX BY MAY." I BROUGHT UP MY CONCERNS REGARDING SAFETY AND WAS TOLD TO "BE CAREFUL". HAVING THE CAR DIE IN MID-TURNS OR WHEN TRYING TO DRIVE ACROSS AN INTERSECTION IS NOT ACCEPTABLE.I CALLED THE DEALERSHIP AGAIN TODAY AND WAS TOLD THEY HAVE BEEN TOLD BY MINI THERE IS NO FIX TO THIS PROBLEM AND OWNERS WILL HAVE TO WAIT UNTIL THE GASOLINE IN THE USA IS "BETTER".I HOPE THE NHTSA WILL BE ABLE TO DO SOMETHING BEFORE SOMEONE IS KILLED BECAUSE OF THIS "UNFIXABLE" PROBLEM.NUMBER OF FAILURES NOTED WAS CALCULATED BY MULTIPLYING APPROX.# OF DAYS SINCE THIS PROBLEM BEGAN BY THE AVE # OF STARTS PER DAY.

ALL BULBS ARE GOOD BUT YET I HAVE NO BRAKE LIGHTS ARE TURNING SIGNALS TOP BRAKE LIGHT IS ALL I HAVE WHEN I TURN ON SIGNALS WINDOWS GO DOWN SUNROOF OPENS. *TR

TL* THE CONTACT OWNS A 2005 MINI COOPER. THE CONTACT STATED THAT THE PASSENGER SIDE SEAT BELT LIGHT ILLUMINATED EVEN WHEN THE SEAT WAS OCCUPIED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V205000 (AIR BAGS); HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 86,000. MA 10/14 *CN