2010 MINI Cooper Problems

Engine issues Engine leaks over heating seal gasket Timing bell Engine missed firing

On Thursday I was driving my 2010 Mini Cooper S with 75,000 miles on it and there was a total and sudden power outage on the high way. I was able to get to the breakdown lane and had it towed. My mini certified garage ran the computer on it and the car started right up. It was due for an inspection so we did an oil and filter and put on some new tires. No issues were found and car was running well. We picked it up on Friday and Saturday morning after a short drive I was parking and smoke started pouring out from behind the steering wheel. I ran inside a coffee shop for help and they asked if there were flames. I went back out and opened the car door and there was loud noise and the hood was in flames. The entire dash was melted, the hood had a hole burned in it and with the fire rescue interventions the car was a total loss. No one was injured.

The dealer refused to perform the required FRM recall inspection and denied the recall without providing any of the federally required documentation. I was forced to pay out‑of‑pocket for the FRM module replacement even though my VIN is listed under the safety recall. MINI of Murray stated my FRM “failed,” but admitted they never opened the module, which is required to determine internal moisture intrusion. • The Service Manager stated they based their denial on “carpet and headliner moisture,” which is not part of the FRM recall inspection procedure. • I requested the FRM inspection report, photos, and the MINI Corporate denial code. I received none of these. • MINI Corporate Recall Team confirmed they had no documentation from the dealer and incorrectly stated that the module does not need to be opened. • Without a completed inspection uploaded to MINI Corporate, a denial code cannot be generated. • I was charged for the FRM replacement part, even though the recall should cover the repair if the module is affected. • The dealer only offered to waive a $149 programming fee. Safety Concern: The dealer failed to follow required recall procedures, failed to document the inspection, and denied federally mandated recall coverage without evidence. This violates recall protocol and leaves the safety defect unresolved. The module was replaced at my expense.

The vehicle is experiencing repeated failure of the Footwell module (FRM), a known defect acknowledged by MINI/BMW. During the two years I have owned the vehicle, the FRM has required four separate reflashes due to recurring malfunctions. The failure causes loss of proper power window operation, including the passenger window reversing or rolling down unexpectedly, and loss or malfunction of other body electrical functions controlled by the FRM. Headlamps will not turn off, resulting in a dead battery and electrical/intermittent dash light surges. The FRM failed again after a software reflash, which is a documented trigger for FRM internal memory corruption. MINI/BMW issued and Extended Limited Warranty for FRM failure, acknowledging this defect; however, I received the official notice after the warranty period had already expired, leaving no opportunity to repair the defect while covered. This failure affects safe operation of the vehicle, including the inability to properly secure windows and maintain normal electrical functionality. The issue is not due to wear or misuse, but an internal electronic defect recognized by the manufacturer. The repeated nature of the failure and reliance on reflashing demonstrate the defect was never fully resolved. I am reporting this issue to document the repeated failures, late manufacturer notification, and ongoing safety-related electrical system issues. I purchased the vehicle with 86,000 miles. It now has 100,000, well below the criteria for the LW. In the 14,000 miles and two years I have owned and driven it, it has required four FRM reflashings. Had I known about the Extended Limited Warranty, I would have had BMW repair it under said warranty. That wasn't possible because I received notice of the known failure after the ELW expired.

Passenger Airbag sensor is off even when passenger is in the seat and airbag should be on.

The passenger airbag with seat belt icon is always indicating no one is in the seat or not buckled. The alert icon for the lighting is also on and we have replaced bulbs and still won’t work and the windows at times just randomly stops would have to unplug battery for it to reset for the windows only. I just bought this car and have registered since. Was told there was several recalls with the same issue I am experiencing. Please include my car for the proper recalls so I can have a safe reliable vehicle for my family.

The dealer refused to perform the required FRM recall inspection and denied the recall without providing any of the federally required documentation. I was forced to pay out‑of‑pocket for the FRM module replacement even though my VIN is listed under the safety recall. MINI of Murray stated my FRM “failed,” but admitted they never opened the module, which is required to determine internal moisture intrusion. • The Service Manager stated they based their denial on “carpet and headliner moisture,” which is not part of the FRM recall inspection procedure. • I requested the FRM inspection report, photos, and the MINI Corporate denial code. I received none of these. • MINI Corporate Recall Team confirmed they had no documentation from the dealer and incorrectly stated that the module does not need to be opened. • Without a completed inspection uploaded to MINI Corporate, a denial code cannot be generated. • I was charged for the FRM replacement part, even though the recall should cover the repair if the module is affected. • The dealer only offered to waive a $149 programming fee. Safety Concern: The dealer failed to follow required recall procedures, failed to document the inspection, and denied federally mandated recall coverage without evidence. This violates recall protocol and leaves the safety defect unresolved. The module was replaced at my expense.

The vehicle is experiencing repeated failure of the Footwell module (FRM), a known defect acknowledged by MINI/BMW. During the two years I have owned the vehicle, the FRM has required four separate reflashes due to recurring malfunctions. The failure causes loss of proper power window operation, including the passenger window reversing or rolling down unexpectedly, and loss or malfunction of other body electrical functions controlled by the FRM. Headlamps will not turn off, resulting in a dead battery and electrical/intermittent dash light surges. The FRM failed again after a software reflash, which is a documented trigger for FRM internal memory corruption. MINI/BMW issued and Extended Limited Warranty for FRM failure, acknowledging this defect; however, I received the official notice after the warranty period had already expired, leaving no opportunity to repair the defect while covered. This failure affects safe operation of the vehicle, including the inability to properly secure windows and maintain normal electrical functionality. The issue is not due to wear or misuse, but an internal electronic defect recognized by the manufacturer. The repeated nature of the failure and reliance on reflashing demonstrate the defect was never fully resolved. I am reporting this issue to document the repeated failures, late manufacturer notification, and ongoing safety-related electrical system issues. I purchased the vehicle with 86,000 miles. It now has 100,000, well below the criteria for the LW. In the 14,000 miles and two years I have owned and driven it, it has required four FRM reflashings. Had I known about the Extended Limited Warranty, I would have had BMW repair it under said warranty. That wasn't possible because I received notice of the known failure after the ELW expired.

Passenger seat occupancy sensor failure. This is a very common fault in the R56 series Mini Cooper. The manufacture has not initiated a recall. There are vendors selling "bypass" kits which will cause unsafe air bag deployment in an infant is in the seat.

The airbag occupancy detection switch in the passenger seat is defective. This is occurring so often on Mini Coopers (R56 models from 2007-2013) that a passenger occupancy defeat switch is being openly sold and YouTube videos are available showing how to fit this device. This disables the occupancy detector switch, causing grave danger of death to infants or children seated in the passenger seat during a collision. MINI is currently charging nearly $1,000 to rectify this common fault. This defect has been confirmed multiple times by MINI, including on my vehicle on 7/8/2022. The component has been inspected by the manufacturer and confirmed to be defective. There were warning lights displayed on the central console, as well as on the driver tachometer every time the car is started. This warning cannot be defeated. This Youtube video (and many others…) have been posted more than 3 years ago about the issue, showing how to disable the warning. This one has over 74,000 views! https://youtu.be/gDlmtygUipM It is WELL overdue that you do something about this clear, present and deadly danger to children! Thank you.

Passenger Airbag sensor is off even when passenger is in the seat and airbag should be on.

Passenger seat occupancy sensor failure. This is a very common fault in the R56 series Mini Cooper. The manufacture has not initiated a recall. There are vendors selling "bypass" kits which will cause unsafe air bag deployment in an infant is in the seat.

Trailer brakes disconnected in 18k lb trailer while driving down mountain. This bulletin is the issue, should be a recall. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I have made several attempts to reach out to dealer. The check engine light came on the same day I purchased car. I brought the car back, the dealer said they would replace it, but couldn't do the work that day. They provided me with a false inspection report. They never followed up with me after several months had gone by and several phone calls had been made with them refusing to return my call. The car turns off on its on while driving. The brakes are also not good on the car. I had to get an oil change, wiping blades after a month of having the car. The AC fan is also not functioning. I would like to escalate this issue, because I am unable to pass my state inspection as well as feeling unsafe to drive a car that can turn off anytime on the road while driving. I waited to take to inspection because I was waiting on the dealer to communicate when they will replace the part. after several months of refusing to respond to my phone calls and emails. I have decided to report their intentional negligence. I also purchased a warranty. through this company EPOVO auto group. I have not received a follow document certifying my warranty purchase through them. Uncertain of legitimacy of this warranty as well. I have filed a complaint with BBB and Federal Trade Commission. I have not received a response. The following failed inspection codes: P0014, P0015, MIL Command.

While driving home one night the following items failed to work: Head lights; turn signals, front windows (so no hand signals); Hazard lights; interior lights; and speedometer dash light. This occurred shortly after a battery change. I am not sure if tail of brake lights function at this time. Driving the vehicle in this condition presents a unacceptable safety concern. During daily light hours I had already noticed the turn signal issue and just thought maybe a relay was bad and had not had time to investigate. Investigation revealed the failed part is the FOOTWELL MODULE, and that this is a KNOWN ISSUE by Mini Cooper. Rather than issue a recall and fix the parts, they offered an extended warranty that lasted 10 years (which expired 13 months ago for my car). As a safety issue, this should have been a recall for all vehicles, not a wait til people have a fail to fix. This issue affects newer models as well.

I have made several attempts to reach out to dealer. The check engine light came on the same day I purchased car. I brought the car back, the dealer said they would replace it, but couldn't do the work that day. They provided me with a false inspection report. They never followed up with me after several months had gone by and several phone calls had been made with them refusing to return my call. The car turns off on its on while driving. The brakes are also not good on the car. I had to get an oil change, wiping blades after a month of having the car. The AC fan is also not functioning. I would like to escalate this issue, because I am unable to pass my state inspection as well as feeling unsafe to drive a car that can turn off anytime on the road while driving. I waited to take to inspection because I was waiting on the dealer to communicate when they will replace the part. after several months of refusing to respond to my phone calls and emails. I have decided to report their intentional negligence. I also purchased a warranty. through this company EPOVO auto group. I have not received a follow document certifying my warranty purchase through them. Uncertain of legitimacy of this warranty as well. I have filed a complaint with BBB and Federal Trade Commission. I have not received a response. The following failed inspection codes: P0014, P0015, MIL Command.

Transmission/timing chain issue/engine malfunctions

MINI COOPER TIMING CHAIN TENSONER DEFECT. I HAVE A R56 HARDTOP 2010 MINI COOPER. MY CAR STARTED HAVING ISSUES LIKE TURNING OFF WHILE DRIVING. A RATTLING NOISE UNDER THE HOOD, ESPECIALLY ON THE PASSENGER SIDE OF THE CAR. WHILE I WAS DRIVING I HEARD A LOUD SNAP NOISE AND MY CAR SHUT OFF. THE ENGINE WOULD NOT TURN OVER AFTER THAT AND WHEN I LOOKED UNDER THE HOOK THERE WAS A BROKEN VALVE COVER. THE TIMING CHAIN BROKE AND CAUSED MASSIVE AMOUNT OF DAMAGE TO MY CAR. THE MINI DEALERSHIP IN LAS VEGAS IS NOT HONORING THE LAWSUIT. NOT REALLY SURE HOW TO PROCEED. THEY WANT $3,500. IN REPAIRS. MY CAR IS ONLY AT 83,000MILES AND JUST PAID OFF. NOT SURE HOW TO PROCEED.

TL* THE CONTACT OWNS A 2010 MINI COOPER. THE CONTACT STATED WHILE DRIVING 65 MPH, THE REAR HATCH DOOR BECAME AJAR WITHOUT WARNING. THE VEHICLE WAS MERGED TO THE SIDE OF THE ROAD. THE DEALER WAS MADE AWARE OF FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 51,000.

TL* THE CONTACT OWNS A 2010 MINI COOPER. THE CONTACT STATED THAT THE VEHICLE HOOD SCOOP WAS DESIGNED WITH DEFECTIVE MATERIAL AND CAUSED IT TO MELT DUE TO THE HOT CLIMATE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE HOOD BONNET SCOOP WAS REPLACED WITH THE SAME DEFECTIVE MATERIAL AS THE PRIOR. THE MANUFACTURER WAS CONTACTED AND ADVISED THAT THEY WOULD WARRANTY THE DEFECTIVE HOOD BONNET SCOOP FOR A LIFE TIME YET, IF THE SCOOP SHOULD FAIL AGAIN, IT WOULD BE REPLACED WITH THE SAME DEFECTIVE BONNET SCOOP. THE VEHICLE WAS NOT FURTHER REPAIRED. THE FAILURE MILEAGE WAS 12,500 AND THE CURRENT MILEAGE WAS 114,496.

Engine stalling Oil pan leaks Caused the engine to shut down when slowing down or sitting in traffic on highway. No warning lights prior to incidents Only right after

02/16/2023 i purchase mini cooper s from a private owner i paid cash 6,0000 for the car 2 months later my car broke down i had my car towed to a shop i was told that my motor mounts had no bolts or screws and that what cause my car to break down it also broke my intake and wheel bearings had to be replaced total cost 1,600.00 On 08/04/2023 my car breaks down i was told that my valve broke and two cylinders needed to be replace the mechanic also told me that my card did not have the miles that it showing on the odometer when i purchase my car odometer read 156,000 miles i was told my mechanic that my car has almost 300,000 miles and the memory brain on my car is ready it a 2006 but my vin number said 2010 im having to replace my engine on my car still in th shop at i already paid up front 4200

MISS FUNCTION WITH HIGH PRESSURE FUEL PUMP, EVERY MORNING I HAVE PROBLEMS TO START UP MY MINI. LOSS OF POWER RESULT FROM THIS MISS FUNCTION WHICH REPRESENT A DANGEROUS SITUATION ON A HIGHWAY BY NOT HAVING THE POWER TO REACT TO ANY SITUATION. I TOOKED TO LOCAL DEALER AND THEY GAVE ME A LIST OF POSSIBLE SOLUTIONS, INCLUDING TO CHANGE THE HIGH PRESURE FUEL PUMP. NOW I HAD BEEN SEARCHING FOR OTHER OWNERS IF THEY HAVE EXPERIENCED THE SAME PROBLEM AND I DID FOUND OUT THAT THERE ARE SEVERAL BLOGS TALKING ABOUT THIS ISSUE. I AM CONCERN ABOUT MY SAFETY AND MY FAMILY SAFETY WHEN THEY DRIVE WITH ME. PLEAES CONTACT ME IF YOU NEED MORE DETAILS ON THIS ISSUE. [XXX] I DO NOT UNDERS STAND WHY MINI/BMW CONTINUES NOT ACCEPTING THIS IS A MANUFACTURING PROBLEM, HOPE NO BODY GET HURT AS A RESULT. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

TL* THE CONTACT OWNS A 2010 MINI COOPER S HATCH BACK. THE CONTACT STATED THAT THE VEHICLE WOULD STALL SPORADICALLY WHILE DRIVING AT VARIOUS SPEEDS AND WOULD OFTEN RESIST STARTING ATTEMPTS. THE CONTACT WAS ABLE TO RESTART THE VEHICLE EVERY TIME THE STALLING FAILURE OCCURRED WITH THE ILLUMINATION OF THE INSTRUMENT CHECK ENGINE LIGHT. THE DEALER WAS CONTACTED AND THE VEHICLE WAS TAKEN TO HAVE THE FAILURE DIAGNOSED WHERE THE FAILURE WAS CONTRIBUTED TO EXCESSIVE CARBON BUILDUP. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 16,000 AND THE CURRENT MILEAGE WAS 18,000. UPDATED 03/14/12 *BF THE TIMING CHAIN WAS LEAKING AND HAD TO BE REPLACED. THE CONSUMER HAS SINCE TRADED THE VEHICLE. UPDATED 04/18/12

On Thursday I was driving my 2010 Mini Cooper S with 75,000 miles on it and there was a total and sudden power outage on the high way. I was able to get to the breakdown lane and had it towed. My mini certified garage ran the computer on it and the car started right up. It was due for an inspection so we did an oil and filter and put on some new tires. No issues were found and car was running well. We picked it up on Friday and Saturday morning after a short drive I was parking and smoke started pouring out from behind the steering wheel. I ran inside a coffee shop for help and they asked if there were flames. I went back out and opened the car door and there was loud noise and the hood was in flames. The entire dash was melted, the hood had a hole burned in it and with the fire rescue interventions the car was a total loss. No one was injured.