2005 Mitsubishi Fuso FE83D Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2005 Mitsubishi Fuso FE83D, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure133.3%
- Engine133.3%
- Fuel system133.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
PREVIOUSLY REPORTED SEVERE RUST & ROT OF CHASSIS / FRAMES. THIS IS A 6 YR OLD TRUCK SHOWING ACCELERATED SIGNS OF RUST LARGE BLISTERS 6-8" IN DIA OF RUST ARE PUSHING OUT FROM BENEATH THE UNDERCOAT AND PAINT. IF THIS PROGRESSES AS IN MY OLDER TRUCKS THIS TRUCK WILL BE UNSAFE AND UNUSABLE IN 3-5 YEARS. PROBLEM HAS BEEN REPORTED TO THE MANUFACTURER WITH NO RESPONSE! *JS
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
ENGINE FAILED IN TRAFFIC SECOND TIME THE FIRST TIME MITSUBISHI FIXED IT UNDER WARRANTY 25K MILES SAME THING HAPPENED AND THEY WILL NOT FIX THE VEHICLE. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
TL*THE CONTACT OWNS A 2005 MITSUBISHI FUSO FE83D. THE CONTACT HAD PROBLEMS WITH THE FUEL PUMP AND THE FUEL INJECTED. THE DEALER STATED THAT THEY HAD TO USE A HIGH PRESSURE FUEL PUMP BECAUSE OF THE CLEAN AIR REGULATIONS WHICH CAUSED THE FUEL LINES TO BREAK APART INTO THE ENGINE AND CAUSE IT TO FAIL. THE FAILURE MILEAGE WAS 157846 AND THE CURRENT MILEAGE WAS 158300. UPDATED 9/1/10 *CN THE FUEL PUMP AND INJECTORS WERE REPLACED. UPDATED 09/14/10
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .