2003 Mitsubishi Lancer Electrical Problems

THE AIR CONDITIONING AND HEATER CONTROLS KNOBS ON DASHBOARD. DO NOT TURN. CAN'T. ADJUST TEMPERATURE ELECTRICAL CERCUIT IN THE EMISSIONS SYSTEM HAS LOW VOLTAGE THAT CAUSES THE ENGINE.LIGHT TO CPME ON AND TURN OFF AT RANDOM. THE FRONT HEADLIGHTS ARE VERY WEEK IN LUMINS. WHEN DRIVING ON THE HIGHWAY AND CITY STREETS , THE CAR ACCELERATES ON ITS OWN WITHOUT. ME PUSHING. ON THE FOOT PEDEL.. THE SUNROOF MOTER CAME UNATTENDED ON IT OWN.

NHTSA ID

11286324

Incident

Jan 5, 2019

Mileage

165,000 mi

AIRBAG HORN DOESN'T WORK I CHANGED THE CLOCK SPRING BUT STILL DOESN'T WORK, SUSPENSION IS TERRIBLE I FELL LIKE I AM GOING TO CRASH. THE HEATER ALSO DOESN'T WORK AND THE CONTROL KNOB IS NOT WORKING. *JS

NHTSA ID

10661840

Incident

Dec 2, 2014

Mileage

137,000 mi

THE TEMPERATURE CONTROL KNOB WAS VERY HARD TO TURN ON THE AC/HEATER MODULE AND EVENTUALLY BROKE OFF. A FAILURE OF THE TEMPERATURE SELECTION COULD RESULT IN INABILITY TO DEFROST THE WINDSHIELD PROPERLY, RESULTING IN UNSAFE DRIVING ENVIRONMENT. *TR

NHTSA ID

10511594

Incident

May 12, 2013

Mileage

180,000 mi

THE HOT/COLD SWITCH BROKE OFF. SINCE I BOUGHT THIS CAR IT HAS BEEN DIFFICULT TO TURN THE SWITCH FOR TEMPERATURE CONTROL. BOTH KNOBS ARE DAMAGED AND NOW IM NOT ABLE TO CONTROL THE DIRECTION OF THE AIR NEITHER THE TEMPERATURE. THIS HAS TO BE A MANUFACTURE DEFECT SINCE. DURING MY RESEARCH ONLINE I'VE FOUND MANY SIMILAR PROBLEMS LIKE THIS ONE. MITSUBISHI SHOULD MAKE A RECALL AND FIX IT . *TR

NHTSA ID

10500998

Incident

Mar 1, 2005

Mileage

60,000 mi

TEMPERATURE KNOB WAS ALWAYS DIFFICULT TO TURN, THEN IT BROKE COMPLETELY OFF. NOT A PROBLEM FOR THE SUMMER (IT'S STUCK ON COLD) BUT NEEDS TO BE FIXED FOR THE WINTER SO THAT THE CAR CAN DEFROST THE WINDSHIELD. TECHNICIAN SAID IT WOULD BE BETWEEN $1500-2000 TO REPAIR BECAUSE YOU HAVE TO REMOVE THE DASHBOARD AND REPLACE THE ENTIRE KNOB PANEL PLUS FIX THE REAL PROBLEM WHICH IS THE "AIR MIX DOOR LEVER". APPARENTLY THIS IS A COMMON PROBLEM FOR MISTUBISHI OWNERS AND THE COMPANY HAS NOT DONE A RECALL TO FIX IT; THEREFORE OWNERS ARE DROPPING $1000S OF DOLLARS TO GET THEIR CAR OPERATIONAL FOR SEASONAL TEMP CHANGES. ISN'T IT A SAFETY HAZARD IF YOUR DEFROSTER DOES NOT WORK??? *TR

NHTSA ID

10418080

Incident

Oct 10, 2010

Mileage

130,000 mi

ALL THREE BRAKE LIGHTS STOPPED WORKING WITH NO WARNING. 1. NORMAL DRIVING TO AND FROM WORK, UNSURE OF ANYTHING LEADING UP TO FAILURE. WAS ALERTED BY ANOTHER DRIVER THAT WAS BEHIND ME WHILE DRIVING AND THEN PULLED UP NEXT TO ME AT A LIGHT. WAS LUCKY THERE WAS NO CRASH. 2. LIGHTS ARE COMPLETELY OUT, HAVE NOT BEEN ABLE TO GET THEM BACK ON 3. HAVE CHECKED THE FUSE AS LABELED IN THE MANUFACTURERS HANDBOOK, CHECKED THE BRAKE LIGHT SWITCH, CHECKED THE LIGHT BULBS, ALL ARE IN OK FASHION AND WORK WHEN TESTED SEPARATELY. *TR

NHTSA ID

10251547

Incident

Dec 11, 2008

Mileage

86,000 mi

I HAD JUST LEFT MY HOME. I HAD NOT BEEN DRIVING FOR MORE THAN 2 MINUTES WHEN MY FRONT SPEAKERS SHUT OFF. I THEN START TO NOTICE A BURNING SMELL. I SEE THE INTERIOR START TO FILL UP WITH SMOKE. I THOUGHT IT WAS AN ENGINE FIRE AT FIRST UNTIL I NOTICED A FIRE IN MY PASSENGER DOOR SPEAKER. I PULLED OVER BUT WAS NOT ABLE TO EXTINGUISH THE FLAMES. I MADE A CALL TO 911 TO SEND THE FIRE DEPARTMENT. THANKFULLY THE FIRE HOUSE WAS VERY CLOSE AND WAS ABLE TO PUT THE FIRE OUT BEFORE IT DAMAGED MORE THAN JUST THE DOOR. I HAVE THE DOOR AND SUBSEQUENT DAMAGE SCHEDULED TO BE REPAIRED AUG 18TH 2008. I HAVE NOT TAKEN APART, REPLACED, OR UPGRADED ANY DASH, RADIO OR ELECTRICAL COMPONENT OF THE CAR. I DON'T KNOW WHAT WOULD HAVE CAUSED THIS. ADDITIONALLY I AM ALSO MISSING THE HEAT AND A/C KNOB AS IT BROKE OFF LAST WINTER. *TR

NHTSA ID

10237314

Incident

Aug 2, 2008

Mileage

186,000 mi

SENSOR ONE HAD AN INTERNAL FAILURE. MITISUBISHI SERVICE TECH STATED IT WAS DUE TO THE BAD GAS IN NORTH CAROLINA. ACCORDING TO THAT IT WOULD BE MANUFACTURING PROBLEM. BUT WAS TOLD SINCE NO RECALLS, WOULD HAVE TO PAY $400 PLUS TAX TO HAVE IT FIXED. IF NOT FIXED WOULD AFFECT THE CATALYTIC CONVERTER AND WOULD CAUSE THE CAR NOT TO RUN. *TR

NHTSA ID

10208624

Incident

May 16, 2007

WHEN I FIRST GOT THE LANCER IN 2003 ONE OF THE FIRST THINGS I NOTICED THAT THE KNOB FOR THE AIR AND HEAT WAS REALLY DIFFICULT TO TURN. I TOOK IT TO THE DEALER, AND WAS TOLD THAT IT WAS JUST A LITTLE STICKY , AND IF I KEPT TURNING IT WOULD WORK ITSELF OUT AND BE FINE. I AVOIDED USING IT AS MUCH AS POSSIBLE BECAUSE IT NEVER GOT BETTER. A YEAR OR SO LATER I HAD TO TAKEN THE VEHICLE TO DEALER FOR A FACTORY RECALL, AND DURING THAT VISIT I ONCE AGAIN ASKED ABOUT THE KNOB. THE TECHNICIAN LOOKED UNDER THE PANEL AND SAID IT WAS JUST STICKING A BIT AND PUT SOME GREASE ON THE GEARS AND SAID TO JUST WORK IT, TURN IT BACK AND FORTH, AND IT WOULD WORK ITSELF OUT. IT WAS FINE FOR A COUPLE DAYS BUT WENT BACK TO THE WAY IT WAS SHORTLY THERE AFTER. FINALLY, A FEW WEEKS AGO, WHILE ON MY WAY TO THE AIRPORT TO PICK UP A FRIEND, I WENT TO TURN THE HEAT ON AND THE KNOB JUST SNAPPED OFF. THIS TIME WHEN I TOOK IT IN TO THE DEALER THEY TOLD ME SINCE THE ROD THAT CONNECTED THE KNOB TO THE GEARS INSIDE WAS WHAT SNAPPED IT WOULD BE ABOUT $500-$600 TO REPAIR. HE EVEN ASKED WHY I NEVER HAD IT LOOKED AT AND FIXED BEFORE IT SNAPPED OFF. I TOLD HIM I DID NUMEROUS TIMES AND WAS BLOWN OFF EACH TIME. BUT NOW THAT IT WAS AN ACTUAL PROBLEM . THEY WERE WILLING TO FIX IT FOR A FEE OF COURSE. UPON DOING SOME RESEARCH I REALIZED THAT OTHER PEOPLE HAD THIS PROBLEM WITH THEIR LANCERS, AND HAD SIMILAR PROBLEMS TRYING TO GET IT FIXED. THIS WAS THE CAUSE FOR COMPLAINT. THE DEALER WAS NOT WILLING TO FIX IT. WHEN I MENTIONED THE PROBLEM NUMEROUS TIMES WHILE THE VEHICLE WAS UNDER WARRANTY. NOW THIS HAS TURNED INTO A COSTLY PROBLEM THAT I BELIEVE IS A DEFECT IN THE VEHICLES. *AK

NHTSA ID

10191347

Incident

Apr 10, 2007

WHEN I BOUGHT THE LANCER IN 2003 THE FIRST THING I NOTICED WAS THE KNOB FOR THE AIR AND HEAT WAS REALLY HARD TO TURN. MY DAD AND I TOOK IT BACK TO THE DEALER AND EXPLAINED IT WAS HARD TO TURN. THE SALESMAN GOT IN THE CAR AND TURNED THE KNOB HE SAID YEAH IT IS A LITTLE HARD TO TURN BUT THEY ARE MADE LIKE THAT. I TOLD HIM IT FELT LIKE IT WAS GOING TO BREAK AND HE SAID IT WONT AND ONCE AGAIN THEY ARE ALL MADE LIKE THAT. I ONLY TURNED THE KNOB ONLY WHEN I HAD TO BECAUSE I DIDN'T WANT IT TO BREAK. I TOOK IT BACK IN AND THE DEALER SAID THEY GET THIS COMPLIANT ALL THE TIME AND IT WOULD BE $800 DOLLARS TO FIX THE PROBLEM. I TOLD HIM IF THEY GET A LOT OF COMPLAINTS MAYBE THERE IS A DEFECT. IN 2006 I WAS ON MY WAY HOME FROM A TRIP AND I TURNED THE KNOB FROM AIR TO HEAT AND IT BROKE OFF. WHEN I GOT HOME THE NEXT DAY I CALLED THE DEALERSHIP AND THEY TOLD ME I SHOULD HAVE BROUGHT THE CAR IN FOR A CHECK I EXPLAINED THAT I DID AND EVERY TIME THEY BLEW IT OFF. HE SAID WELL TO FIX IT, AND IT WILL COST $800-$900 DOLLARS. IS THIS CAUSE FOR COMPLAINT. *AK

NHTSA ID

10185862

Incident

Jun 28, 2006

WHILE DRIVING 2003 MITSUBISHI LANCER EVOLUTION IN A RAINSTORM, I ENCOUNTERED A SEVERE LOSS OF ACCELERATION MULTIPLE TIMES. RESULTING IN ERRATIC BEHAVIOR OF THE CAR.*AK OTHERS HAVE EXPERIENCED SIMILAR PROBLEMS IN THEIR LANCER EVOLUTIONS DOCUMENTED HERE: HTTP://FORUMS.EVOLUTIONM.NET/SHOWTHREAD.PHP?S=&THREADID=34867

NHTSA ID

10037213

Incident

Aug 9, 2003

Mileage

1,800 mi