RoadVitals

2002 Monaco Coach Knight Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
5
Newest Jun 5, 2008
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
1 investigation on file

Recall campaigns

5 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

08V257000

EQUIPMENT:RECREATIONAL VEHICLE/TRAILER

Jun 5, 2008
8,587 units potentially affected
The defect: MONACO IS RECALLING CERTAIN MOTOR HOMES EQUIPPED WITH NORCOLD REFRIGERATORS. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK.
The risk: EXTENDED OPERATION OF A LEAKING COOLING UNIT COULD LEAD TO A FIRE FROM GAS WHICH MIGHT ESCAPE.
The remedy: MONACO IS WORKING WITH NORCOLD TO REPAIR THESE REFRIGERATORS. NORCOLD WILL PROVIDE THERMAL SWITCH KITS TO OWNERS ALONG WITH THE NECESSARY FORMS AND INSTRUCTIONS. THE RECALL BEGAN ON AUGUST 29, 2008. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR MONACO AT 1-800-685-6545.
MONACO COACH CORPORATIONManufacturer number R08017View on NHTSA.gov
05V053000

SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY

Feb 14, 2005
2,827 units potentially affected
The defect: ON CERTAIN CLASS A MOTOR HOMES, THE SPACER PLATE UNDER THE TRAILING ARMS HAD A TRANSVERSE WELD WHICH CREATES A HEAT RISER AND CAUSE THE TRAILING ARMS TO CRACK.
The risk: THIS COULD CREATE ROUGH DRIVING CONDITIONS AND DAMAGE TO REAR SUSPENSION SYSTEM. THE DRIVER COULD LOOSE CONTROL OF THE MOTORHOME AND A CRASH COULD OCCUR WITHOUT PRIOR NOTICE.
The remedy: DEALERS WILL INSPECT THE REPLACE THE TRAILING ARMS FOR CRACKS AND REPLACING THE TRAILING ARMS AND U-BOLTS IN THE REAR SUSPENSION OF THE MOTORHOMES FREE OF CHARGE. THE RECALL BEGAN ON MARCH 29, 2005. OWNERS MAY CONTACT MONACO AT 1-800-685-6545.
MONACO COACH CORPORATIONManufacturer number R04062View on NHTSA.gov
04V038000

SUSPENSION:FRONT

Jan 28, 2004
2,156 units potentially affected
The defect: ON CERTAIN MOTORHOMES, THE I-BEAM LEAF IMITATOR IN THE FRONT AXLE SUSPENSION COULD CRACK AND BREAK DUE TO AN INADEQUATE WELDING PROCESS.
The risk: THE I-BEAMS ON THE FRONT AXLE AND THE PANARD BRACKET ON THE REAR AXLE COULD CRACK AND BREAK CAUSING THE DRIVER TO LOSE CONTROL OF THE VEHICLE INCREASING THE RISK OF A CRASH.
The remedy: DEALERS WILL REPLACE THE ORIGINAL I-BEAM. ALSO, DEALERS WILL WELD THE STIFFENERS FROM THE PANARD BAR BRACKET TO THE CENTER DIFFERENTIAL OF THE REAR AXLE HOUSING. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT MONACO AT 1-877-466-6226.
MONACO COACH CORPORATIONManufacturer number R03024View on NHTSA.gov
02V278000

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

Oct 22, 2002
8,581 units potentially affected
The defect: ON CERTAIN MOTOR HOMES, THE BRAKE ASSEMBLIES EXHIBIT ELEVATED TEMPERATURES THAT CAN LEAD TO CATASTROPHIC DETERIORATION OF THE WHEEL END COMPONENTS SUCH AS BEARINGS, RACES, SPINDLES, KNUCKLES, SEALS, HUBS, ROTORS, PATCH BOLTS, CALIPERS, BRAKE PADS, AND ABS SENSORS.
The risk: THIS COULD RESULT IN LOSS OF CONTROL, AND/OR THE POTENTIAL FOR A FIRE.
The remedy: DEALERS WILL INSPECT THE FRONT AND REAR BRAKE CALIPERS FOR CORROSION AND REPLACE OR REBUILD THE CALIPERS AS NECESSARY. THE RECALL BEGAN ON AUGUST 18, 2004. OWNERS SHOULD CONTACT MONACO AT 1-800-685-6545.
MONACO COACH CORP.Manufacturer number R02175View on NHTSA.gov
01V256000

STEERING: STEERING WHEEL/HANDLE BAR

Aug 15, 2001
98 units potentially affected
The defect: VEHICLE DESCRIPTION: MOTOR HOMES. A UNIT IS AFFECTED IF THE INTERMEDIATE STEERING SHAFT IS FULLY COMPRESSED OR IS TOO SHORT TO MEET MAXIMUM EXTENSION SPECIFICATIONS.
The risk: THIS CONDITION CAN CAUSE A LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.
The remedy: DEALERS WILL INSPECT AND/OR REPLACE THE INTERMEDIATE STEERING SHAFT. OWNER NOTIFICATION BEGAN AUGUST 13, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MONACO AT 1-800-685-6545.
MONACO COACH CORP.View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

PE04068ClosedPreliminary Evaluation

UNPROTECTED LP GAS LINE

Opened Sep 29, 2004
Closed Jan 13, 2005

MONACO INFORMED ODI THAT IT HAS RECEIVED NO OWNER REPORTS OF MISSING LP GAS LINE SHILEDS OTHER THAN THE ONE FORWARDED BY ODI.ODI HAS FOUND NO OTHER VEHICLE THAT WAS MISSING THE LP LINE SHIELD. DURING THE COURSE OF THE INVESTIGATION ODI: ?CONDUCTED FIELD INSPECTIONS AT NUMEROUS DEALERS; ?REQUESTED WARRANTY CLAIMS AND FIELD REPORTS FROM MONACO(THERE WERE NONE);REVIEWED ENGINEERING DRAWINGS;AND?REVIEWED THE ANSI A119.2 AND THE NATIONAL FIRE PROTECTION ASSOCIATION 1192 STANDARDS ON RECREATION VEHICLES (RV?S) PERTAINING TO LP GAS LINE INSTALLATION ON RV?S. BASED ON MONACO?S DATA AND THE ABSENCE OF ANY FURTHER COMPLAINTS, A SAFTEY RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FUTHER USE OF AGENCY RESOURCES IS NOT CURRENTLY WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFTEY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION ON THE VEHICLES IF WARRANTED BY THE CIRCUMSTANCES. ODI WILL CONTINUE TO MONITOR FIELD REPORTS AND TAKE APPROPRIATE ACTION IF INDICATED.

EQUIPMENT:RECREATIONAL VEHICLE/TRAILER:LPG SYSTEMS:LINES AND FITTINGS

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .