RoadVitals

2005 National Rv Tropi-Cal Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
2
Latest Feb 21, 2008
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
1
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2005 National Rv Tropi-Cal, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Brakes2100.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Brakes

Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.

2
reports

From owner reports, verbatim

A FEW DAYS AGO AN AIR LEAK NOISE WAS CALLED TO MY ATTENTION AND ON EXITING THE COACH IT WAS PRETTY OBVIOUS THAT SOMETHING WAS AMISS. I PERFORMED THE PRESCRIBED AIR LEAK TEST AND FOUND THAT WE DID INDEED HAVE A MASSIVE AIR LEAK. MAKING OUR WAY (VERY CAREFULLY!) TO THE FONTANA, CA FTL FACILITY, THEY WERE ABLE TO FIND THAT THE AIR HOSES TO THE TWO REAR AIR BRAKE CHAMBERS HAD BEEN RUBBING TOGETHER AND PRODUCED A HOLE IN ONE HOSE AND VERY NEARLY IN THE OTHER. THIS WAS WITH ONLY 14,000 MILES AND 26 MONTHS ON THE COACH! *TR

NHTSA ID 10218703 · filed Feb 21, 2008

DT: CONSUMER STATES THAT DUTCHMEN THOR PRODUCES A CAMPER, TAB, AND THEY HAVE AN ALCO BRAKE SYSTEM THAT THEY HAVE MODIFIED. THEY STATE IT HAS NOT BEEN MODIFIED. ACCORDING TO ALCO IN UNITED KINGDOM, THE COMPANY IS SETTING UP THE SYSTEM WRONG ON THE VEHICLE. WHEN HE TRIES TO GET INFORMATION FROM DUTCHMEN THOR THEY SEND HIM THE MANUAL FOR THE GERMAN BRAKE SYSTEM. ON THE TOE SHAFT, THE DAMPENING UNIT, IT IS SUPPOSE TO SLIDE BACK AND HIT AN OVERRUN LEVER THAT IS HOW IT IS BEING SET UP IN THE US. ON THE MANUAL, THERE IS NO CLEARANCE BETWEEN THE TOE SHAFT AND THE OVERRUN LEVER. ON THE UNITS THEY ARE PRODUCING THERE IS 1 5/8 INCH CLEARANCE. THE COMPANY IS NO LONGER CORRESPONDING WITH THE CONSUMER AND THEY ARE NOT OFFERING ANY INFORMATION TO THE DEALERS. THERE IS NO INFORMATION ON HOW MUCH THE CLEARANCE SHOULD BE. THE COMPANY CONTINUES TO REFER HIM TO THE WEBSITE WITH THE GERMAN MANUAL IN IT. CONSUMER NOTICED THE PROBLEM WHEN HE TRIED TO STOP AND THE TRAILER SLAMMED INTO THE BACK OF HIS VEHICLE. THE CAMPER TYPE WAS NOT AVAILABLE IN THE DATABASE, IT IS A 2005 DUTCHMEN THOR TAB.NM

NHTSA ID 10128343 · filed Jul 11, 2005

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .