RoadVitals

1997 Navistar 3800 Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
5
Newest Nov 23, 1999
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
1 investigation on file

Recall campaigns

5 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

99V331000

SERVICE BRAKES, AIR:SUPPLY:HOSES, LINES/PIPING, AND FITTINGS

Nov 23, 1999
277 units potentially affected
The defect: VEHICLE DESCRIPTION: SCHOOL BUS. AN AIR BRAKE LINE CONTROLLING THE REAR BRAKES MAY BE TOO CLOSE TO THE EXHAUST PIPE AND COULD RUPTURE AT ANY TIME WITHOUT WARNING.
The risk: EXHAUST PIPE HEAT CAN MELT OR CAUSE PREMATURE FAILURE OF THIS AIR LINE IF THE AIR LINE IS ROUTED TOO CLOSE TO THE EXHAUST PIPE.
The remedy: DEALERS WILL INSTALL A NEW ELBOW FITTING AND REROUTE THE AIR LINE. THE AIR LINE WILL ALSO BE INSPECTED AND REPLACED IF FOUND TO BE DAMAGED FROM THE EXHAUST PIPE.
INTERNATIONAL TRUCK AND ENGINEView on NHTSA.gov
99V033001

STEERING:LINKAGES:ROD:RELAY:CONNECTING

Feb 16, 1999
40,091 units potentially affected
The defect: SCHOOL, TRANSIT, OR HEAVY DUTY VEHICLES EQUIPPED WITH SPICER 6,000 OR 8,000 LB. FRONT STEER AXLES. THE TIE ROD END CAN PULL OUTBOARD AND SEPARATE FROM THE TIE ROD TUBE DUE TO IMPROPER THREAD ENGAGEMENT BETWEEN THE MALE TIE ROD END AND THE FEMALE TUBE.
The risk: SEPARATION OF THE TIE ROD END COULD RESULT IN LOSS OF STEERING CONTROL, INCREASING THE RISK OF A VEHICLE CRASH.
The remedy: DEALERS WILL REPLACE THE COMPLETE TIE ROD ASSEMBLY.
INTERNATIONAL TRUCK AND ENGINEManufacturer number 99501View on NHTSA.gov
98V291000

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

Nov 9, 1998
22,032 units potentially affected
The defect: VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH T444E DIESEL ENGINES. A FUEL LEAK CAN OCCUR BECAUSE OF OVERCRIMPING OF THE HOSE END FITTINGS ON THE HOSE FROM THE REGULATOR TO THE LEFT HEAD AND THE HOSE FROM THE FUEL TRANSFER PUMP TO THE REGULATOR.
The risk: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, CAN RESULT IN A FIRE.
The remedy: DEALERS WILL INSPECT THE OIL HOSE AND PLACE AN ADDITIONAL CONVOLUTED LOOM AROUND THE EXISTING OIL HOSE, OR REPLACE THE HOSE ASSEMBLY.
INTERNATIONAL TRUCK AND ENGINEView on NHTSA.gov
97V143002

VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

Sep 8, 1997
3,292 units potentially affected
The defect: VEHICLE DESCRIPTION: BUSES AND HEAVY TRUCK CHASSIS EQUIPPED WITH CUMMINS N-14, CATERPILLAR, AND DETROIT DIESEL ELECTRONIC ENGINES. THE ACCELERATOR PEDAL ROD MATERIAL IS EXCESSIVELY BRITTLE AND CAN BREAK DURING A FULL THROTTLE APPLICATION.
The risk: THE UNEXPECTED BREAKAGE CAN RESULT IN THE INABILITY TO ACCELERATE THE VEHICLE PROPERLY INCREASING THE RISK OF A VEHICLE CRASH.
The remedy: DEALERS WILL REPLACE THE ELECTRONIC ACCELERATOR PEDAL RODS WITH NEW RODS.
INTERNATIONAL TRUCK & ENGINE CORPORATIONManufacturer number 97508View on NHTSA.gov
97V143001

VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

Sep 8, 1997
2,235 units potentially affected
The defect: VEHICLE DESCRIPTION: BUSES AND HEAVY TRUCK CHASSIS EQUIPPED WITH T444E ENGINES. THE ACCELERATOR PEDAL ROD MATERIAL IS EXCESSIVELY BRITTLE AND CAN BREAK DURING A FULL THROTTLE APPLICATION.
The risk: THE UNEXPECTED BREAKAGE CAN RESULT IN THE INABILITY TO ACCELERATE THE VEHICLE PROPERLY INCREASING THE RISK OF A VEHICLE CRASH.
The remedy: DEALERS WILL REPLACE THE ELECTRONIC ACCELERATOR PEDAL RODS WITH NEW RODS.
INTERNATIONAL TRUCK AND ENGINEManufacturer number 97508View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

PE98004ClosedPreliminary Evaluation

UNDERHOOD FIRES

Opened Feb 5, 1998
Closed Apr 21, 1998

ALLEGED UNDERHOOD FIRES DUE TO ELECTRICAL OR FUEL SYSTEM MALFUNCTION

ELECTRICAL SYSTEM

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .