RoadVitals

2003 New Flyer D30LF

Recalls, owner-reported complaints, investigations and safety data

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
0
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
1
Latest Jun 14, 2006
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains no NHTSA owner-reported complaints for the 2003 New Flyer D30LF. 1 safety recall has been issued covering this model year; and 3 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Safety recalls

1 campaign cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
06V212000

ENGINE AND ENGINE COOLING:ENGINE:DIESEL

Jun 14, 2006
798 units potentially affected
The defect: ON CERTAIN TRANSIT BUSES BUILT WITH CUMMINS ISL AND ISC DIESEL ENGINES EQUIPPED WITH THE CM850 FUEL SYSTEM, THE ENGINE HIGH PRESSURE FUEL LINES, FROM THE ENGINE HIGH PRESSURE PUMP TO THE ENGINE FUEL RAIL, ARE PRONE TO FAILURE.
The risk: FAILURE OF THE LINE INTRODUCES HIGH PRESSURE FUEL SPRAY INTO THE ENGINE COMPARTMENT WHICH CAN IGNITE WHEN IT COMES IN CONTACT WITH A HOT SURFACE.
The remedy: CUMMINS WILL INSTALL A FUEL LINE BRACKET TO REDUCE FUEL LINE STRESS. A NEW FUEL LINE WILL BE INSTALLED WHEN ADDING THE BRACKET. CUSTOMERS MAY CONTACT CUMMINS AT 1-800-DIESELS OR NEW FLYER AT 204-934-4876.
NEW FLYER INDUSTRIES LTDView on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

No owner complaints recorded for this model year

Either none have been filed with NHTSA, or this vehicle is too new for reports to have accumulated.

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

PMB049

EQUIPMENT

This Parts Manual Bulletin provides new part number information for the moveable arm kit for the Kongsberg brake and accelerator assembly on specifically equipped vehicles.

SMB178

EQUIPMENT; EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Service Manual Bulletin provides new OEM (Kongsberg) PM inspection requirements and new installation procedure for the adjustable floor pedal moveable arm on specifically equipped vehicles.

1571A

ENGINE AND ENGINE COOLING:COOLING SYSTEM

SUBJECT REGARDING ADDITIONAL NEWFLYER SERVICE MANUAL MAINTENANCE INSTRUCTIONS FOR SERVICING THE HYDRAULIC FAN DRIVE PUMP (PERMCO) AND POWER STEERING PUMP (VICKERS) ON A D30LF, D35LF, D40LF, C30LF, C35LF, C40LF COACHES WITH A CUMMINS 8.3 ENGINE. *TT

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

New Flyer D30LF by model year
YearComplaintsRecallsInvestigationsIssue Index
2005040—
2004040—
2003Viewing010—
2001020—
2000050—
1999040—
1998060—
1997050—
1996020—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.