RoadVitals

2003 New Flyer D60HF Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
3
Newest Sep 2, 2009
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
1 investigation on file

Recall campaigns

3 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

09V346000

EQUIPMENT ADAPTIVE/MOBILITY

Sep 2, 2009
325 units potentially affected
The defect: NEW FLYER IS RECALLING MODEL YEAR 2002-2006 D60HF DIESEL 60 FOOT HIGH FLOOR TRANSIT BUSES EQUIPPED WITH A LIFT-U WHEELCHAIR LIFT, OR HAVE AFTERMARKET LIFT-U CONTROL BOXES INSTALLED. A DEFECT IN THE CONTROL BOX COULD CAUSE THE OUTBOARD RAMP BARRIER TO FOLD IN TOWARD A LIFT PASSENGER.
The risk: THE RAMP BARRIER COULD PINCH THE PASSENGER'S FEET.
The remedy: NEW FLYER IS WORKING WITH LIFT-U (PLEASE SEE RECALL 09E-051) AND WILL REPAIR THE TRANSIT BUSES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 26, 2009. OWNERS MAY CONTACT NEW FLYER CUSTOMER SERVICE AT 1-204-934-4876 OR LIFT-U AT 1-209-838-2400.
NEW FLYER INDUSTRIES LTDView on NHTSA.gov
07V268000

STEERING

Jun 11, 2007
1,768 units potentially affected
The defect: ON CERTAIN TRANSIT BUSES, THE U-JOINT ASSEMBLIES HAVE INADEQUATE SPLINE ENGAGEMENT ON ONE OF THE TWO END YOKES.
The risk: EXCESSIVE PLAY IN THE STEERING SYSTEM COULD DEVELOP AND, IF NOT CORRECTED, CAUSE A LOSS OF STEERING CONTROL WHICH COULD RESULT IN A CRASH.
The remedy: THE U-JOINT ASSEMBLY WILL BE INSPECTED AND REPLACED IF NECESSARY. THE RECALL BEGAN ON JUNE 10, 2007. OWNERS MAY CONTACT NEW FLYER AT 1-204-934-4874.
NEW FLYER INDUSTRIES LTDView on NHTSA.gov
04V042000

WHEELS

Feb 2, 2004
782 units potentially affected
The defect: ON CERTAIN TRANSIT BUSES, THE CENTER AXLE WHEEL END BRAKES MAY NOT RELEASE AFTER BEING PARKED FOR AN EXTENDED PERIOD OF TIME.
The risk: THE DRIVER COULD LOSE CONTROL OF THE VEHICLE WHEN DRIVING AWAY FROM A PARKED POSITION, WHICH COULD RESULT IN A CRASH.
The remedy: NEW FLYER WILL INSTALL AN ADDITIONAL AIR SYSTEM R14 RELAY VALVE, #4 NOTCH AUTOMATIC SLACK ADJUSTERS, AND TYPE 30 LONG STOKE BRAKE CHAMBERS ON THE CENTER AXLE; THE LOGIC CONTROL MODULE WILL BE REPROGRAMMED, ADD NEW ABS COMPONENTS (SENSORS, SPEED RINGS AND HARNESSES) IF NOT ALREADY EQUIPPED WITH ABS; AND WILL REVISE PLC PROGRAMMING. OWNERS MAY CONTACT NEW FLYER AT 1-204-982-8400.
NEW FLYER INDUSTRIES LTDView on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

PE04003ClosedPreliminary Evaluation

BRAKES FAIL TO RELEASE, BUS JACK-KNIFES

Opened Jan 8, 2004
Closed Apr 30, 2004

THIS INVESTIGATION WAS PROMPTED BY A TRANSIT FLEET, WHICH INFORMED ODI IN NOVEMBER, 2003, THAT THEY WERE EXPERIENCING BRAKE PROBLEMS ON THEIR HIGH FLOOR ARTICULATING STYLE BUSES.IN THE LETTER, THE FLEET STATED THAT THEY HAD EXPERIENCED OVER 50 INCIDENTS WHERE THE REAR BRAKES FAILED TO RELEASE DURING MORNING PULLOUT FROM THEIR PARKING LOCATION.THEY ALLEGED THAT THERE HAD BEEN THREE CRASHES RESULTING IN PROPERTY DAMGE AS THE RESULT OF THIS STICKING BRAKE PHENOMENON.THE CRASHES ORIGINATE WHEN THE MIDDLE AXLE BRAKES FAIL TO RELEASE AND THE REAR ENGINE VEHICLE PUSHES THE MIDDLE AXLE RESULTING IN A JACK-KNIFE CONDITION OF THE ARTICULATED BUS. AS A RESULT OF ODI'SINVESTIGATION, NEW FLYER HAS AGREED TO INITIATE A SAFETY RECALL AND CORRECT THIS CONDITION ON ALL AFFECTED BUSES.THE ACTION TAKEN BY NEW FLYER IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION. A COPY OF THE RECALLIS ATTACHED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.

SERVICE BRAKES, AIRLed to recall 04V042000

Elsewhere on this vehicle

Data sources